Investigations on reactivity controlled compression ignition combustion with different injection strategies using alternative fuels produced from waste resources

Abstract

Reactivity-controlled compression ignition (RCCI) is a promising low-temperature combustion (LTC) strategy that results in low oxides of nitrogen (NO_x) and soot emissions while maintaining high thermal efficiency. At the same time, RCCI leads to increased unburned hydrocarbon (HC) and carbon monoxide (CO) emissions in the exhaust, particularly under low loads. The current work experimented novel port-injected RCCI (PI-RCCI) strategy to overcome the high unburned emission limitations at low load conditions in RCCI. PI-RCCI is a port injection strategy in which low-reactivity fuel (LRF) is injected using a low-pressure injector, and the high-reactivity fuel (HRF) is injected through a high-pressure common rail direct injection (CRDI) injector. The low volatile HRF is injected into a heated fuel vaporizer maintained at 180°C in the intake manifold during the suction stroke. Modifying a single-cylinder, light-duty diesel engine with the necessary intake and fuel injection systems allows engine operation in both RCCI and PI-RCCI modes. Alternative fuels from waste resources such as waste cooking oil biodiesel (WCO) and plastic waste oil (WPO) are used as the HRF and LRF fuel in RCCI and PI-RCCI. To achieve maximum thermal efficiency in RCCI, the premixed energy ratio and the start of injection of the direct-injected fuel are optimized at all load conditions. The engine performance and exhaust emissions characteristics in PI-RCCI are compared with RCCI as a baseline reference. The results show a 70% and 48% reduction in CO and HC emissions, respectively, in PI-RCCI than in RCCI. Further, the brake thermal efficiency (BTE) was enhanced by around 20%, and the brake-specific fuel consumption (BSFC) was reduced by 13% in PI-RCCI. The NO_x emissions decreased without any considerable changes in soot emission in PI-RCCI. The current study shows that fuels derived from waste resources can be used in RCCI and PI-RCCI modes with better engine performance and lower emissions.

Keywords

Plastic waste oil waste cooking oil RCCI PI-RCCI engine performance reduced emissions

Get full access to this article

View all access options for this article.

References

Anuar Sharuddin

Abnisa

Wan Daud

WMA

Aroua

. Energy recovery from pyrolysis of plastic waste: study on non-recycled plastics (NRP) data as the real measure of plastic waste. Energy Convers Manag 2017; 148: 925–934.

Sharuddin

SDA

Abnisa

Wan Daud

WMA

Aroua

. A review on pyrolysis of plastic wastes. Energy Convers Manag 2016; 115: 308–326.

Miandad

Barakat

Aburiazaiza

Rehan

Nizami

. Catalytic pyrolysis of plastic waste: a review, process saf. Environ. Prot 2016; 102: 822–838.

Areeprasert

Asingsamanunt

Srisawat

, et al. Municipal plastic waste composition study at transfer station of bangkok and possibility of its energy recovery by pyrolysis. Energy Procedia 2017; 107: 222–226.

Briassoulis

Hiskakis

Babou

Antiohos

Papadi

. Experimental investigation of the quality characteristics of agricultural plastic wastes regarding their recycling and energy recovery potential. Waste Manag 2012; 32: 1075–1090.

Jeswani

Krüger

Russ

, et al. Life cycle environmental impacts of chemical recycling via pyrolysis of mixed plastic waste in comparison with mechanical recycling and energy recovery. Sci Total Environ 2021; 769.

Huang

Wang

Ahmad

, et al. Plastic waste management strategies and their environmental aspects: a scientometric analysis and comprehensive review. Int J Environ Res Public Health 2022; 19(8): 4556.

Al-Salem

Antelava

Constantinou

Manos

Dutta

. A review on thermal and catalytic pyrolysis of plastic solid waste (PSW). J Environ Manag 2017; 197: 177–198.

Das

Sahoo

Panda

. Production of plastic wastes oil and its prospective use in a variable compression CI engine. J Hazard Toxic Radioact Waste 2021; 25: 04021008.

10.

Das

Sahu

Panda

. Current status and prospects of alternate liquid transportation fuels in compression ignition engines: a critical review, Renew. Sustain Energy Rev 2022; 161: 112358.

11.

Kalghatgi

. The outlook for fuels for internal combustion engines. Int J Engine Res 2014; 15: 383–398.

12.

Reitz

. Directions in internal combustion engine research, Combust. Flame 2013; 160: 1–8.

13.

Kimura

Aoki

Kitahara

Aiyoshizawa

. Ultra-clean combustion technology combining a low-temperature and premixed combustion concept for meeting future emission standards. SAE technical paper 2001-01-0200, 2001.

14.

Splitter

Reitz

. Fuel reactivity effects on the efficiency and operational window of dual-fuel compression ignition engines. Fuel 2014; 118: 163–175.

15.

Park

Shim

Bae

. Expansion of low-load operating range by mixture stratification in a natural gas-diesel dual-fuel premixed charge compression ignition engine. Energy Convers Manag 2019; 194: 186–198.

16.

Pandian

Anand

. Comparison of different low temperature combustion strategies in a light duty air cooled diesel engine. Appl Therm Eng 2018; 142: 380–390.

17.

Jia

Chang

Xie

Reitz

. Towards a comprehensive understanding of the influence of fuel properties on the combustion characteristics of a RCCI (reactivity controlled compression ignition) engine. Energy 2016; 99: 69–82.

18.

Pandian

Anand

. Experimental optimization of reactivity controlled compression ignition combustion in a light duty diesel engine. Appl Therm Eng 2018; 138: 48–61.

19.

Kokjohn

Hanson

Splitter

Kaddatz

Reitz

. Fuel reactivity controlled compression ignition (RCCI) combustion in light- and heavy-duty engines. SAE Int J Engines 2011; 4: 360–374.

20.

Anand

Reitz

Kurtz

Willems

. Modeling fuel and EGR effects under conventional and low temperature combustion conditions. Energy Fuels 2013; 27: 7827–7842.

21.

Benajes

Pastor

García

Monsalve-Serrano

, The potential of RCCI concept to meet EURO VI NOx limitation and ultra-low soot emissions in a heavy-duty engine over the whole engine map. Fuel. 2015; 159: 952–961.

22.

Zhu

Qian

Wang

. Effects of direct injection timing and premixed ratio on combustion and emissions characteristics of RCCI (Reactivity controlled compression ignition) with N-heptane/gasoline-like fuels. Energy 2015; 93: 383–392.

23.

Benajes

Molina

García

Monsalve-Serrano

. Effects of direct injection timing and blending ratio on RCCI combustion with different low reactivity fuels. Energy Convers Manag 2015; 99: 193–209.

24.

Park

Shin

Park

. Effect of ethanol fraction on the combustion and emission characteristics of a dimethyl ether-ethanol dual-fuel reactivity controlled compression ignition engine. Appl Energy 2016; 182: 243–252.

25.

Pedrozo

May

Dalla Nora

Cairns

Zhao

. Experimental analysis of ethanol dual-fuel combustion in a heavy-duty diesel engine: an optimisation at low load. Appl Energy 2016; 165: 166–182.

26.

Jia

Denbratt

. Experimental investigation into the combustion characteristics of a methanol-diesel heavy duty engine operated in RCCI mode. Fuel 2018; 226: 745–753.

27.

Zhou

Yang

Shu

. A numerical study on RCCI engine fueled by biodiesel/methanol. Energy Convers Manag 2015; 89: 798–807.

28.

Mohebbi

Reyhanian

Hosseini

Muhamad Said

Aziz

. Performance and emissions of a reactivity controlled light-duty diesel engine fueled with n-butanol-diesel and gasoline. Appl Therm Eng 2018; 134: 214–228.

29.

Gupta

Anand

. Experimental investigations to reduce unburned emissions in reactivity controlled compression ignition through fuel modifications. Appl Therm Eng 2019; 146: 622–634.

30.

Pan

Han

Huang

. An experimental investigation on multi-cylinder RCCI engine fueled with 2-butanol/diesel. Energy Convers Manag 2017; 154: 92–101.

31.

Cha

Kwon

Park

. Combustion and emission characteristics of a gasoline–dimethyl ether dual-fuel engine. Proc IMechE, Part D: J Automobile Engineering 2012; 226: 1667–1677.

32.

Duraisamy

Rangasamy

Govindan

. A comparative study on methanol/diesel and methanol/PODE dual fuel RCCI combustion in an automotive diesel engine. Renew Energy 2020; 145: 542–556.

33.

Nemade

Krishnasamy

. Experimental investigation on reactivity controlled compression ignition with oxygenated alternative fuel blends to reduce unburned hydrocarbon emissions. SAE Technical Paper, 2021.

34.

Hanson

Kokjohn

Splitter

, et al. Fuel effects on reactivity controlled compression ignition (rcci) combustion at low load. SAE Int J Engines 2011; 4: 394–411.

35.

Wang

Zhu

Yao

, et al. An investigation into the RCCI engine operation under low load and its achievable operational range at different engine speeds. Energy Convers Manag 2016; 124: 399–413.

36.

Wissink

Curran

Kavuri

, et al. Spray-wall interactions in a small-bore, multi-cylinder engine operating with reactivity-controlled compression ignition. In: Proceedings of the ASME 2017 internal combustion engine division fall technical conference, Seattle, Washington, USA, 15–18 October 2017. ASME.