Temperature-dependent changes of physicochemical and tribological properties of acrylonitrile-butadiene rubber elastomer upon ageing in hexadecane and diethylene glycol dibutyl ether

Abstract

Acrylonitrile-butadiene rubber elastomers are widely used in seal and tire industries. Physiochemical, surface and tribological properties of acrylonitrile-butadiene rubber exposed to a lubricant in a sealed mechanical contact may gradually change, in particular, at elevated temperatures. In this study, industrial-grade acrylonitrile-butadiene rubber elastomers were aged in two model non-additivated base oils, namely non-polar hexadecane and polar diethylene glycol dibutyl ether at both ambient (298 K) and elevated (398 K) temperatures from 1 to 168 h. Mass changes of acrylonitrile-butadiene rubber before and after ageing indicated that acrylonitrile-butadiene rubber had distinct ageing dynamics in different model base oils and at different temperatures. For acrylonitrile-butadiene rubber aged in nonpolar hexadecane, the rate of weight loss of the rubber was larger at 398 K compared to that at 298 K. On the contrary, distinct weight-gaining (swelling) dynamics were observed for acrylonitrile-butadiene rubber aged in polar diethylene glycol dibutyl ether at 298 and 398 K. Based on Fourier transform infrared spectroscopy, liquid and solid-state nuclear magnetic resonance spectroscopy and energy dispersive spectroscopy analyses, it was found that aldehydes and sulfur- and zinc-containing compounds were leached out from acrylonitrile-butadiene rubber aged in both hexadecane and diethylene glycol dibutyl ether. The results of tribological studies showed that the non-aged acrylonitrile-butadiene rubber has a good wear-resistance. Acrylonitrile-butadiene rubber samples had a very similar surface topography before and after tribo-tests. However, the worn surfaces of acrylonitrile-butadiene rubber samples were characterized by fine scoring (abrasion) marks after ageing in both model base oils. This has been attributed to changes in the steel–rubber contact environment during the sliding process and degradation of mechanical properties of acrylonitrile-butadiene rubber after ageing. For one acrylonitrile-butadiene rubber sample (after ageing in hexadecane at 398 K), very stable friction in the steel–rubber contact was observed.

Keywords

Acrylonitrile-butadiene rubber aging oil polarity friction Fourier transform infrared spectroscopy nuclear magnetic resonance

Get full access to this article

View all access options for this article.

References

Philippoff

. Mechanical investigations of elastomers in a wide range of frequencies. J Appl Phys 1953; 24(6): 685–689.

Davenas

Stevenson

Celette

. Stability of polymers under ionising radiation: the many faces of radiation interactions with polymers. Nucl Instrum Methods Phys Res B: Beam Inter Mater Atoms 2002; 191(1-4): 653–661.

McCarthy

. What's new in asphalt materials. Better Roads 1990; 60(1): 24–25.

Kresge

. Polyolefin thermoplastic elastomer blends. Rubber Chem Technol 1991; 64(3): 469–479.

Coran

Patel

. Rubber-thermoplastic compositions-2. NBR-nylon thermoplastic elastomeric compositions. Rubber Chem Technol 1980; 53(4): 781–794.

Tashlykov

Kasperovich

Shadrukhin

. Elastomer treatment by arc metal deposition assisted with self-ion irradiation. Surface Coatings Technol 1999; 116-119: 848–852.

Barney

Keller

Van Gulick

. High-performance fluorocarbon elastomer. J Polym Sci Part A: Polym Chem 1970; 8(5): 1091–1098.

Weissert

. Elastomer technology. Ind Eng Chem 1969; 61(8): 53–59.

Vinogradov

Malkin

A Ya

Yanovsky Yu

. Correlation of stationary and dynamic mechanical characteristics of elastomers. Rheol Acta 1969; 8(4): 490–496.

10.

Railsback

Haws

Wheat

. Elastomers for the building industry. Preprints 1965; 10(4): A-113–A-120.

11.

Findik

Yilmaz

Koksal

. Investigation of mechanical and physical properties of several industrial rubbers. Mater Des 2004; 25(4): 269–276.

12.

Simmons

Mofidi

Prakash

. Friction evaluation of elastomers in lubricated contact. Lubr Sci 2009; 21(10): 427–440.

13.

Mofidi

Kassfeldt

Prakash

. Tribological behaviour of an elastomer aged in different oils. Tribol Int 2008; 41(9–10): 860–866.

14.

De Vicente

Stokes

Spikes

. Lubrication properties of non-adsorbing polymer solutions in soft elastohydrodynamic (EHD) contacts. Tribol Int 2005; 38(5): 515–526.

15.

Persson

BNJ

. Theory of rubber friction and contact mechanics. J Chem Phys 2001; 115(8): 3840–3840.

16.

Roberts

. A guide to estimating the friction of rubber. Rubber Chem Technol 1992; 65(3): 673–673.

17.

Moore

Geyer

. A review of adhesion theories for elastomers. Wear 1972; 22(2): 113–141.

18.

Persson

BNJ

. On the theory of rubber friction. Surface Sci 1998; 401(3): 445–454.

19.

Persson

BNJ

Tosatti

. Qualitative theory of rubber friction and wear. J Chem Phys 2000; 112(4): 2021–2029.

20.

Schallamach

. A theory of dynamic rubber friction. Wear 1963; 6(5): 375–382.

21.

Grosch

. The relation between the friction and visco-elastic properties of rubber. Proc R Soc Lond Ser A Math Phys Sci 1963; 274(1356): 21–39.

22.

Flom

. Rolling friction of polymeric materials. I. Elastomers. J Appl Phys 1960; 31(2): 306–314.

23.

Myant

Spikes

Stokes

. Influence of load and elastic properties on the rolling and sliding friction of lubricated compliant contacts. Tribol Int 2010; 43(1–2): 55–63.

24.

Leong

Reddyhoff

Sinha

. Hydrodynamic friction reduction in a MAC–hexadecane lubricated MEMS contact. Tribol Lett 2013; 49(1): 217–225.

25.

Kajdas

Makowska

Gradkowski

. Influence of temperature on the tribochemical reactions of hexadecane. Lubr Sci 2003; 15(4): 329–340.

26.

Naveira

Grahn

Pasaribu

. The influence of base oil polarity on the tribological performance of zinc dialkyl dithiophospate additives. Tribol Int 2010; 43(12): 2268–2278.

27.

Mofidi

Prakash

. Influence of counterface topography on sliding friction and wear of some elastomers under dry sliding conditions. Proc IMechE Part J: J Engineering Tribology 2008; 222(5): 667–673.

28.

Magryta

Dębek

. Mechanical properties of swelled vulcanizates of polar diene elastomers. J Appl Polym Sci 2006; 99(5): 2010–2015.

29.

Chakraborty

Bandyopadhyay

Ameta

. Application of FTIR in characterization of acrylonitrile-butadiene rubber (nitrile rubber). Polym Test 2007; 26(1): 38–41.

30.

Colthup

Daly

Wiberley

. Introduction to infrared and Raman spectroscopy, 3rd ed. San Diego, CA: Academic Press, 1990.

31.

Chakraborty

Kar

Dasgupta

. Montmorillonite clay nanocomposites based on vinyl pyridine-styrene-butadiene terpolymer (VPR)/acrylonitrile-butadiene rubber (NBR) blend. Polym Eng Sci 2011; 51(8): 1675–1681.