Improving the performance of the condenser fan in a subway train against the effects of crosswind flow by placing barriers

Abstract

In this paper, the effect of crosswind flow and barrier placement on the performance of the condenser fan in a subway train is investigated. In addition, the amount of heat transfer on the condenser tubes is also analyzed. At different velocities of the train, variations in the velocity profile and drag force are determined for various geometries including triangular, rectangular, symmetric triangular barriers, and a barrier with parallel lines outside of the fan. Navier–Stokes, energy equations, and k–ω turbulence model have been used for the numerical modeling of the turbulent and incompressible flow. The results show that due to the created vortices behind the triangular and rectangular barriers, a negative velocity on the outflow of the fan is observed. Also, the symmetric triangular barrier minimizes the rotational flow on the top of the fan, and parallel paths have the most impact on the improvement of the fan's performance due to the elimination of all rotating flows. Finally, variations in temperature on the condenser tubes in the presence of barriers that are placed in the middle gap between the holes on the top of the condenser tubes are determined. These barriers move the crosswind flow toward the condenser tubes and decrease the output air temperature of the condenser.

Keywords

Condenser fan performance crosswind flow effect barrier drag force air conditioning system of train

Get full access to this article

View all access options for this article.

References

Ding

Zhang

, et al. Numerical simulation of pressure pulsation and transient flow field in an axial flow fan. Energy 2017; 129: 185–200.

Dai

Zhu

, et al. Influence from the blade installation angle of the windward axial fans on the performance of an air-cooled power plant. Energy 2013; 60: 416–425.

Stafford

Walsh

Egan

. Local heat transfer performance and exit flow characteristics of a miniature axial fan. Int J Heat Fluid Flow 2010; 31: 952–960.

Wei

Zhang

Liu

, et al. A study of the unfavorable effects of wind on the cooling efficiency of dry cooling towers. J Wind Eng Ind Aerodyn 1995; 98: 633–643.

Mondal

Mukherjee

Kundu

, et al. Investigation of the crosswind-influenced thermal performance of a natural draft counterflow cooling tower. Int J Heat Mass Transfer 2015; 85: 1049–1057.

Chen

Sun

Wang

, et al. Experimental research of the cross walls effect on the thermal performance of wet cooling towers under crosswind conditions. Appl Therm Eng 2011; 31: 4007–4013.

Wang

Zhang

Liu

. The cooling performance of a natural draft dry cooling tower under crosswind and an enclosure approach to cooling efficiency enhancement. Appl Energy 2017; 186: 336–346.

Wang

Zhang

, et al. Adoption of enclosure and windbreaks to prevent the degradation of the cooling performance for a natural draft dry cooling tower under crosswind conditions. Energy 2016; 116: 1360–1369.

Guan

Gurgenci

, et al. Windbreak walls reverse the negative effect of crosswind in short natural draft dry cooling towers into a performance enhancement. Int J Heat Mass Transfer 2013; 63: 162–170.

10.

Reshadatjoo

Pormahmod

Moltagh

. The effect of cross-winds on an indirect dry cooling tower with or without windbreaks. Proc IMechE, Part A: J Power and Energy 2011; 225: 635–646.

11.

Zhai

. Improving cooling efficiency of dry-cooling towers under crosswind conditions by using wind-break methods. Appl Therm Eng 2006; 26: 1008–1017.

12.

Paradot

Grégoire

Stiepel

, et al. Crosswind sensitivity assessment of a representative Europe-wide range of conventional vehicles. Proc IMechE, Part F: J Rail and Rapid Transit 2015; 229: 594–624.

13.

Diedrichs

. Aerodynamic crosswind stability of a regional train model. Proc IMechE, Part F: J Rail and Rapid Transit 2010; 224: 580–591.

14.

Hemida

Baker

. Large-eddy simulation of the flow around a freight wagon subjected to a crosswind. Comput Fluids 2010; 39: 1944–1956.

15.

Shuanbao

Dilong

Zhenxu

, et al. Optimization design for aerodynamic elements of high speed trains. Comput Fluids 2014; 95: 56–73.

16.

Report of air conditioning system in subway train wagon. Chapter 10, 1–32.

17.

Copeland Scroll ZR72KCE-TFD R407C 50HZ, 2012, 1–2.

18.

Wilcox

. Turbulence modeling for CFD, 2nd ed. La Canada, CA: DCW Industries, 1998.

19.

Sui D, Wang SS, Mao JR, et al. Exit flow behavior of axial fan flows with/without impingement. J Fluids Eng 2009; 131: 1–7.

20.

Incropera FP and Dewitt DP. Introduction to heat transfer. Vol. 1, 4th ed, 2002, pp.479–490.

21.

Zhukauskas A. Heat transfer from tubes in cross flow. Adv Heat Transfer 1972; 8: 93–160.