In this research, main objective is to study the effect of heat transfer in a hybrid radiator (wavy and rectangular louvered) tube on the thermophysical properties of Aluminium oxide and copper oxide-based nanofluids. ANSYS Fluent has been used in the simulation and the SST-K-ε model is used since the flow condition is turbulent. The study presents a thorough comparison in physical properties of nanofluids with variable volume concentrations between 0.05 and 0.30 per cent. An increase in Nusselt number of 174% was established with CuO-based nanofluid compared to a 162% increase with Al2O3-based nanofluid. For a CuO-based nanofluid at a volume concentration of 3% and a mass flow rate of 6 l/min, convective heat transfer of 37021.41 W/mK is recorded, a 142% increase over the base fluid. Increasing mass flow and volume concentration reduces the friction factor. As volume concentration increases, heat transfer capacity increases and reaches a maximum of 8.93% higher than base fluid at a flow rate of 6 l/min.
AliMEl-LeathyAMAl-SofyanyZ.The effect of nanofluid concentration on the cooling system of vehicles radiator. Adv Mech Eng2014; 6: 962510.
2.
DevireddySMekalaCSRVeeredhiVR.Improving the cooling performance of automobile radiator with ethylene glycol water based TiO2 nanofluids. Int Commun Heat Mass Transf2016; 78: 121–126.
3.
AlEssaAHMaqablehAMAmmourahS.Enhancement of natural convection heat transfer from a fin by rectangular perforations with aspect ratio of two. Int J Phys Sci2019; 4(10): 540–547.
4.
NambeesanKPParthibanRRam KumarK, et al. Experimental study of heat transfer enhancement in automobile radiator using Al2O3/water-ethylene glycol nanofluid coolants. Int J Automot Mech Eng2015; 12: 2857–2865.
5.
ZhangZYuZFangX.An experimental heat transfer study for helically flowing outside petal-shaped finned tubes with different geometrical parameters. Appl Therm Eng2007; 27(1): 268–272.
6.
AkbarzadeSSedighiKFarhadiM.Experimental investigation of force convection heat transfer in a car radiator filled with SiO2-water nanofluid. Int J Eng2014; 27(2): 333–340.
7.
HeyhatMMKowsaryFRashidiAM, et al. Experimental investigation of laminar convective heat transfer and pressure drop of water-based Al2O3 nanofluids in fully developed flow regime. Exp Therm Fluid Sci2013; 44: 483–489.
8.
SaidurRLeongKYMohammedHA.A review on applications and challenges of nanofluids. Renew Sustain Energy Rev2011; 15(3): 1646–1668.
9.
AfrandM.Experimental study on thermal conductivity of ethylene glycol containing hybrid nano-additives and development of a new correlation. Appl Therm Eng2017; 110: 1111–1119.
10.
RushTANewellTAJacobiAM.An experimental study of flow and heat transfer in sinusoidal wavy passages. Int J Heat Mass Transf1999; 42(9): 1541–1553.
11.
GuptaHKDas AgrawalGMathurJ.An experimental investigation of a low temperature Al2O3-H2O nanofluid based direct absorption solar collector. Solar Energy2015; 118: 390–396.
12.
HusseinAMAbu BakarRKadirgamaK, et al. Heat transfer enhancement using nanofluids in an automotive cooling system. Int Commun Heat Mass Transf2014; 53: 195–202.
13.
NasiriAShariaty-NiasarMRashidiA, et al. Effect of dispersion method on thermal conductivity and stability of nanofluid. Exp Therm Fluid Sci2011; 35(4): 717–723.
14.
EsfeMHSaedodinSMahmoodiM.Experimental studies on the convective heat transfer performance and thermo-physical properties of MgO–water nanofluid under turbulent flow. Exp Therm Fluid Sci2014; 52: 68–78.
15.
GoudarziKJamaliH.Heat transfer enhancement of Al2O3-EG nanofluid in a car radiator with wire coil inserts. Appl Therm Eng2017; 118: 510–517.
16.
KoleMDeyTK.Effect of aggregation on the viscosity of copper oxide–gear oil nanofluids. Int J Therm Sci2011; 50(9): 1741–1747.
17.
BalannaKKishorePS.Evaluation of heat transfer and friction factor on wavy fin automotive radiator. Int J Sci Res Dev2015; 3(8): 144–147.
18.
DuangthongsukWWongwisesS.Effect of thermophysical properties models on the predicting of the convective heat transfer coefficient for low concentration nanofluid. Int Commun Heat Mass Transf2008; 35(10): 1320–1326.
19.
PeyghambarzadehSMHashemabadiSHNarakiM, et al. Experimental study of overall heat transfer coefficient in the application of dilute nanofluids in the car radiator. Appl Therm Eng2013; 52(1): 8–16.
20.
SaeediAHAkbariMToghraieD.An experimental study on rheological behavior of a nanofluid containing oxide nanoparticle and proposing a new correlation. Physica E Low Dimens Syst Nanostruct2018; 99: 285–293.
21.
JunqiDJiangpingCZhijiuC, et al. Heat transfer and pressure drop correlations for the wavy fin and flat tube heat exchangers. Appl Therm Eng2007; 27(11–12): 2066–2073.
22.
SidikNACYazidMNAWMMamatR.A review on the application of nanofluids in vehicle engine cooling system. Int Commun Heat Mass Transf2015; 68: 85–90.
23.
HamiltonRLCrosserOK. Thermal conductivity of heterogeneous two-component systems. Ind Eng Chem Fundam1962; 1(3): 187–191.
24.
WenDDingY.Experimental investigation into convective heat transfer of nanofluids at the entrance region under laminar flow conditions. Int J Heat Mass Transf2004; 47(24): 5181–5188.
25.
ChouguleSSSahuSK.Comparative study of cooling performance of automobile radiator using Al2O3-water and carbon nanotube-water nanofluid. J Nanotechnol Eng Med2014; 5(1): 010901.
26.
PakBCChoYI.Hydrodynamic and heat transfer study of dispersed fluids with submicron metallic oxide particles. Exp Heat Transf Int J1998; 11(2): 151–170.
27.
MasoumiNSohrabiNBehzadmehrA.A new model for calculating the effective viscosity of nanofluids. J Phys D Appl Phys2009; 42(5): 055501.
28.
ChandrasekarMSureshSBoseAC.Experimental investigations and theoretical determination of thermal conductivity and viscosity of Al2O3/water nanofluid. Exp Therm Fluid Sci2010; 34(2): 210–216.
29.
LiuMSLinMCHuangIT, et al. Enhancement of thermal conductivity with CuO for nanofluids. Chem Eng Technol2006; 29(1): 72–77.
30.
EliasMMMahbubulIMSaidurR, et al. Experimental investigation on the thermo-physical properties of Al2O3 nanoparticles suspended in car radiator coolant. Int Commun Heat Mass Transf2014; 54: 48–53.
31.
KarwaR.Natural and forced convection solar air heaters for utilization of solar energy: state of art. In: AICTE-sponsored two-day national seminar on energy security for India: opportunities & challenges ESIOC: MREC in association with the institution of engineers, Jodhpur, India, 4–5 March 2011. India: Jodhpur Local Centre Jodhpur.
