Two-phase fuel distribution measurements in a gasoline direct injection engine with an air-assisted injector using advanced optical diagnostics

Abstract

The fuel distribution and mixture formation processes within an internal combustion (IC) engine can greatly affect its ignition, combustion, pollutant formation, and fuel consumption. For more than two decades the laser-induced fluorescence (LIF) technique has been successfully applied to the study of mixture formation and distribution. However, in a gasoline direct injection (GDI) engine the fuel may exist in either the liquid or vapour phase, and it is therefore advantageous to be able to observe both phases simultaneously.

One means of achieving this is the laser-induced exciplex fluorescence (LIEF) technique. This paper details its application to a single-cylinder GDI engine equipped with an air-assisted fuel injection system and full optical access. Naphthalene and N, N-dimethlylaniline (DMA) tracers were used to track the fuel and were excited using the expanded beam from an XeCl excimer laser at 308 nm. An image doubler and optical filtering system was used to collect the images that were recorded from the front of the cylinder. Early and late injection timings were investigated, and the spray characteristics and mixture formation from the two strategies were found to differ considerably.

In order to investigate the effect of absorption on the fluorescence signal, the beam was introduced into the cylinder from three directions. Crank angle resolved results, from the start of injection to the end of the compression stroke, are presented, with an image for each illumination direction and injection timing.

Keywords

exciplex laser fluorescence gasoline direct injection

Get full access to this article

View all access options for this article.

References

Hishinuma

Urushihara

Kakuho

Itoh

Development of a technique for quantifying in-cylinder A/F ratio distribution using LIF image processing. JSAE Rev., 1996, 17, 355–359.

Krämer

Einecke

Schulz

Simultaneous mapping of the distribution of different fuel volatility classes using tracer-LIF and NIR-tomography in an IC engine. SAE paper 982467, 1998.

Melton

L. A.

Separated fluorescence emissions for diesel fuel droplets and vapour. Appl. Optics, 1983, 22, 2224–2226.

Diwakar

Fansler

D. T.

French

D. T.

Ghandhi

J. B.

Dasch

C. J.

Heffelfinger

D. M.

Liquid and vapour fuel distributions from an air-assist injector - an experimental and computational study. SAE paper 920422, 1992.

Shimizu

Matumoto

Furuno

Murayama

Kojima

Measurement of air-fuel mixture distribution in a gasoline engine using LIEF technique. SAE paper 922356, 1992.

Kim

J. U.

Golding

Exciplex fluorescence visualisation systems for pre-combustion diagnostics of an automotive gasoline engine. SAE paper 960826, 1996.

Münch

K. U.

Krämer

Leipertz

Investigation of fuel evaporation inside the intake of a SI engine using laser-induced exciplex-fluorescence with a new seed. SAE paper 961930, 1996.

Fröba

A. P.

Rabenstein

Münch

K. U.

Leipertz

Mixture of triethylamine (TEA) and benzene as a new seeding material for the quantitative two-dimensional laser-induced exciplex fluorescence imaging of vapour and liquid fuel inside SI engines. Combust. and Flame, 1998, 112, 199–209.

Ipp

Wagner

Krämer

Wensing

Leipertz

Spray formation of high pressure swirl gasoline injectors investigated by two-dimensional mie and LIEF techniques. SAE paper 1999–01-0498, 1999.

10.

Cathcart

Tubb

Application of air assisted direct fuel injection to pressure charged gasoline engines. SAE paper 2002–01-0705, 2002.

11.

Houston

Cathcart

Combustion and emission characteristics of orbitals combustion process applied to multi-cylinder automotive direct injection 4-stroke engines. SAE paper 98–01-53, 1998.