In the present work, the effects of Sn, Ca additions on thermal conductivity were investigated in as cast Mg–Sn–Ca alloys. The measured values of thermal conductivity of Mg–3Sn–xCa alloys obviously increased from 85.6 to 126.3 W m− 1 K− 1 with the increasing Ca from 0 to 1.5 wt-, and then decreased to 98.3 W m− 1 K− 1 with the 2.5 wt- Ca. In addition, the thermal conductivity of the Mg–Sn–Ca (Sn/Ca atomic ratio of 1) alloys decreased slightly from 154.2 to 132.1 W m− 1 K− 1 with the increasing Sn, Ca. Meanwhile, the microstructures of the selected alloys were discussed in detail, suggesting that the solute atoms that caused lattice distortion had greater effect on thermal conductivity compared with the second phases formed in as cast Mg–Sn–Ca alloys.
MordikeB. L. and EbertL.: ‘Magnesium: properties–application–potential’, Mater. Sci. Eng. A, 2001, A302, 37–45. doi: 10.1016/S0921-5093(00)01351-4
2.
LiuH. M., ChenY. G., TangY. B. and WeiS. H.: ‘The microstructure, tensile properties, and creep behavior of as-cast Mg-(1–10) wt Sn alloys’, J. Alloys Compd, 2007, 440, 122–126. doi: 10.1016/j.jallcom.2006.09.024
3.
WeiS. H., ChenY. G., TangY. B., LiuH. M. and XiaoS. F.: ‘Compressive creep behavior of as-cast and aging-treated Mg–5wt Sn alloys’, Mater. Sci. Eng. A, 2008, A492, 20–23. doi: 10.1016/j.msea.2008.05.006
4.
WeiS. H., ChenY. G., TangY. B. and XiaoS. F.: ‘Compressive creep behavior of Mg–Sn binary alloy’, Trans. Nonferrous Met. Soc. China, 2008, 18, s214–s217. doi: 10.1016/S1003-6326(10)60205-1
5.
ChengH. H., HuangD. S. and LinM. T.: ‘Heat dissipation design and analysis of high power LED array using the finite element method’, Microelectron. Reliab., 2012, 52, 905–911. doi: 10.1016/j.microrel.2011.05.009
6.
RudajevováA. and LukácP.: ‘Comparison of the thermal properties of AM20 and AS21 magnesium alloys’, Mater. Sci. Eng. A, 2005, A397, 16–21. doi: 10.1016/j.msea.2004.12.036
7.
RudajevováA., von. BuchF. and MordikeB. L.: ‘Thermal diffusivity and thermal conductivity of Mg–Sc alloys’, J. Alloys Compd, 1999, 292, 27–30. doi: 10.1016/S0925-8388(99)00444-2
8.
HortN., HuangY., LeilT. A., MaierP. and KainerK. U.: ‘Microstructural investigations of the Mg–Sn–xCa system’, Adv. Eng. Mater., 2006, 8, 359–364. doi: 10.1002/adem.200600014
9.
LeilT. A., HuangY., DieringaH., HortN., KainerK. U. and BursikJ.: ‘Effect of heat treatment on the microstructure and creep behavior of Mg–Sn–Ca alloys’, Mater. Sci. Forum, 2007, 546–549, 69–72. doi: 10.4028/www.scientific.net/MSF.546-549.69
10.
RaoK. P., PrasadY. V. R. K., HortN., HuangY. and KainerK. U.: ‘High temperature deformation behaviour of a new magnesium alloy’, Key Eng. Mater., 2007, 340-341, 89–94. doi: 10.4028/www.scientific.net/KEM.340-341.89
11.
NayyeriG. and MahmudiR.: ‘The microstructure and impression creep behavior of cast, Mg–5Sn–xCa alloys’, Mater. Sci. Eng. A, 2010, A527, 2087–2098. doi: 10.1016/j.msea.2009.11.053
12.
NayyeriG. and MahmudiR.: ‘Effects of Ca additions on the microstructural stability and mechanical properties of Mg–5Sn alloy’, Mater. Des., 2011, 32, 1571–1576. doi: 10.1016/j.matdes.2010.09.019
13.
SureshK., RaoK. P., PrasadY. V. R. K., HortN. and KainerK. U.: ‘Microstructure and mechanical properties of as-cast Mg–Sn–Ca alloys and effect of alloying elements’, Trans. Nonferrous Met. Soc. China, 2013, 23, 3604–3610. doi: 10.1016/S1003-6326(13)62907-6
14.
RudajevováA., StanekM. and LukácP.: ‘Determination of thermal diffusivity and thermal conductivity of Mg–Al alloys’, Mater. Sci. Eng. A, 2003, A341, 152–157. doi: 10.1016/S0921-5093(02)00233-2
15.
RudajevováA., KudelaS., StanekM. and LukácP.: ‘Thermal properties of Mg–Li and Mg–Li–Al alloys’, Mater. Sci. Technol., 2003, 19, 1097–1100. doi: 10.1179/026708303225004648
16.
YingT., ZhengM. Y., LiZ. T. and QiaoX. G.: ‘Thermal conductivity of as-cast and as-extruded binary Mg–Al alloys’, J. Alloys Compd, 2014, 608, 19–24. doi: 10.1016/j.jallcom.2014.04.107
17.
YingT., ZhengM. Y., LiZ. T., QiaoX. G. and XuS. W.: ‘Thermal conductivity of as-cast and as-extruded binary Mg–Zn alloys’, J. Alloys Compd, 2015, 621, 250–255. doi: 10.1016/j.jallcom.2014.09.199
18.
YuanJ. W., ZhangK., LiT., LiX. G., LiY. J., MaM. L., LuoP., LuoG. Q. and HaoY. G.: ‘Anisotropy of thermal conductivity and mechanical properties in Mg–5Zn–1Mn alloy’, Mater. Des., 2012, 40, 257–261. doi: 10.1016/j.matdes.2012.03.046
19.
PanH., PanF., YangR., PengJ., TangA., HuangQ., SongK. and GaoZ.: ‘Thermal and electrical conductivity of Mg–Zn–Al alloys’, Mater. Sci. Technol., 2014, 30, 988–994. doi: 10.1179/1743284713Y.0000000401
20.
PanH., PanF., WangX., PengJ., SheJ., ZhaoC., HuangQ., SongK. and GaoZ.: ‘High conductivity and high strength Mg–Zn–Cu alloy’, Mater. Sci. Technol., 2014, 30, 759–764. doi: 10.1179/1743284713Y.0000000400
21.
WangC. M., ChenY. G., XiaoS. F., DingW. C. and LiuX.: ‘Thermal conductivity and mechanical properties of as-cast Mg–3Zn–(0.5∼3.5)Sn alloys’, Rare Met. Mater. Eng., 2013, 42, 2019–2222. doi: 10.1016/S1875-5372(14)60018-7
22.
PanH. C., PanF. S., YangR. M., PengJ., ZhaoC. Y. and SheJ.: ‘Thermal and electrical conductivity of binary magnesium alloys’, J. Mater. Sci., 2014, 49, 3107–3124. doi: 10.1007/s10853-013-8012-3
23.
WangC. M., CuiZ. M., LiuH. M., XiaoS. F. and ChenY. G.: ‘Electrical and thermal conductivity in Mg–5Sn alloy at different aging status’, Mater. Des., 2015, 84, 48–52.
24.
KozlovA., OhnoM., ArroyaveR., LiuZ. K. and Schmid-FetzerR.: ‘Phase equilibria, thermodynamics and solidification microstructures of Mg–Sn–Ca alloys (part 1): experimental investigation and thermodynamic modeling of the ternary Mg–Sn–Ca system’, Intermetallics, 2008, 16, 299–315. doi: 10.1016/j.intermet.2007.10.010
25.
KozlovA., OhnoM., AbuleilT., HortN., KainerK. U. and Schmid-FetzerR.: ‘Phase equilibria, thermodynamics and solidification microstructures of Mg-Sn-Ca alloys (part 2): prediction of phase formation in Mg-rich Mg–Sn–Ca cast alloys’, Intermetallics, 2008, 16, 316–321. doi: 10.1016/j.intermet.2007.10.011
26.
TrittT. M.: ‘Thermal conductivity: theory, properties, and applications’, 2004, New York, Plenum Publishers.
27.
TouloukianY. S., PowellR. W., HoC. Y. and KlemensP. G.: ‘Thermophysical properties of matter, vol. 1’ ‘Thermal conductivity metallic elements and alloys’, 1970, New York, Plenum Press.
28.
KlemensP. and WilliamsR.: ‘Thermal conductivity of metals and alloys’, Int. Mater. Rev., 1986, 31, 197–215. doi: 10.1179/095066086790324294
29.
ChenZ. H.: ‘Magnesium alloys’, 2004, Beijing, Chemical Industry Press.
