Effect of NO x gases on corrosion of stainless stell in hot nitric acid solutions

Abstract

The effect of NO_x purging on the corrosion behaviour of stainless steel in hot 8M nitric acid has been investigated. Gravimetric corrosion rate measurements and electrochemical potential and polarisation data made on nitric acid grade (NAG) 18/10L stainless steel are related to the concentration of nitrous acid produced by NO_x purging, which in turn is related to the solution redox potential measured using clean Pt. Purging with NO_x is shown to reduce the redox potential of nitric acid solution, but in the absence of other dissolved species acts as an oxidising agent to stainless steel and increases the corrosion rate. T he effect of NO_x purging saturates at relatively low flow rate owing to the fact that the solution becomes saturated with nitrous acid. However, in 8M nitric acid containing 3 g L^-1 Fe and 0·7 g L^-1 Ru at 100°C, NO_x purging has no effect on the corrosion rate of NAG 18/10L. This is considered to indicate that Fe and Ru at these concentrations polarise stainless steel to the same corrosion potential as NO_x is capable of achieving.

Get full access to this article

View all access options for this article.

References

Truman

J. E.

: J. Appl. Chem., 1954, 4, 273–283.

Cihal

: in ‘Materials science monographs’, (ed. Laird

), Vol. 18, 67; 1984, Amsterdam, Elsevier.

Wilson

P. D.

(ed.): ‘The nuclear fuel cycle — from ore to waste’, 122; 1996, New York, NY, Oxford Science.

Miner

F. J.

et al.: Trans. Faraday Soc., 1970, 66, 2192–2198.

Nagai

, TAKEUCHI

, TAKEDA

, YAMAMOTO

, TSUKUI

, and OKAMOTO

: J. Nucl. Sci. Technol., 1998, 35, (7), 502–507.

Yamamoto

, TSUKI

, OKAMOTO

, NAGAI

, TAKEUCHI

, TAKEDA

, and TANAKA

: J. Nucl. Sci. Technol., 1998, 35, 353–356.

Suzuki

, TSUKAUE

, YOSHIDA

, and HIROSE

: Proc. RECOD'91, Sendai, Japan, April 1991, Atomic Energy Society of Japan, 564–569.

E BALBAUD, G. SANCHEZ, P. FAUVET, G. SANTARINI, and G. PICARD: Corros. Sci., 2000, 42, (10), 1685–1707.

Armstrong

R. D.

, CLELAND

G. E.

, and WHILLOCK

G. O. H.

: J. Appl. Electrochem., 1998, 28, 1205–1211.

10.

McCINTOSH

A. B.

and Evans

T. E.

: Proc. 2nd Int. Conf. on ‘peaceful uses of atomic energy’, Geneva, Switzerland, September 1958, United Nations, 206–225.

11.

Balbaud

, SANCHEZ

, SANTARINI

, and PICARD

: Eur. J. Inorg. Chem., 2000, 665–674.

12.

Dunnett

and WHILLOCK

G. O. H.

: submitted to Corrosion.

13.

Thomas

L. C.

and CHAMBERLIN

G. J.

: Volorimetric chemical analytical methods’, 9th edn, 281; 1980, Salisbury, The Tintometer.

14.

Pourbaix

: ‘Atlas of electrochemical equilibria in aqueous solutions’, 493; 1974, Houston, TX, NACE.

15.

Razygraev

V. P.

, LEBEDEVA

M. V.

, KABAKCHI

S. A.

, YU

PONOMAREVA

R. S.

BALOVNEVA , and LOBANOVA

L. P.

: J. App. Chem., 1988, 61, 67–73.

16.

Vetter

K. J.

: ‘Electrochemical kinetics — theoretical and experimental aspects’, 490; 1967, New York, NY, Academic Press.

17.

‘Computer calculated potential pH diagrams to 300°C’, Vol. 2; 1983, Palo Alto, CA, Electric Power Research Institute.

18.

Clegg

S. L.

and BRIMBLECOMBE

J. Phys. Chem., 1990, 94, 5369–5380.

19.

Ives

J. G.

and JANZ

G. J.

: ‘Reference electrodes — theory and practice’, 161; 1961, New York, NY, Academic Press.

20.

Evans

U. R.

: ‘An introduction to metallic corrosion’, 3rd edn, 70–72; 1981, London, Edward Arnold.

21.

Cleland

G. E.

: ‘Effect of dissolved species on the corrosion of stainless steel in nitric acid’, PhD thesis, chapter 5; 1998, University of Newcastle upon Tyne.