Tracing the dynamic ecology of microbial biofilms on steel with prolonged submersion in surface water

Abstract

Amplicon sequencing is applied to monitor microbial species residing in the biofilm that formed on steel surface submerged in surface water along the Ghent Terneuzen canal, stretching 31 kms from Belgium to the Netherlands. Temporal and spatial differences in the biofilm microbiota were revealed by 16S rRNA composition analysis. The loss-of-mass from S235 steel coupons showed uniform corrosion rates ranging from 242 to 906 g/m² after 3 months. Notably, enhanced pitting corrosion was seen at one specific location near ‘Heide’ affecting the surface with depths up to 1210 µm after 6 months. We presume the excessive steel deterioration in micro-cavities is associated with microbial activity of iron-oxidising bacteria (IOB) and sulphur-reducing bacteria (SRB), such as Shewanella spp. and Gallionella spp., respectively, as redox-active species. Indications for microbially induced corrosion (MIC) are highlighted at sites with apt microbial composition, irrespective of physico-chemical water parameters. Coupons affected by high corrosion and assumed MIC did not stand out in terms of species richness and alpha diversity did not increase, suggesting partial take-over of the microbial community by IOB or SRB.

Keywords

Bacterial activity community analysis microbial ecology environmental monitoring steel bio-corrosion

Get full access to this article

View all access options for this article.

References

Strubbe

. Les ports maritimes Belges. Tielt: Lannoo, 1989.

Van Erp

. Impact analysis of Capesize vessels on Arcelor Mittal Ghent . Master, TU Delft, 2021.

Denteneer

Van Herpe

. Milieuproblematiek in de omgeving van het kanaal Gent - Terneuzen, Ministerie van de Vlaamse Gemeenschap, Departement Leefmilieu en infrastruktuur (AMINAL), Brussel, 1993

Boets

Lock

Goethals

PLM

. Using long-term monitoring to investigate the changes in species composition in the harbour of Ghent (Belgium). Hydrobiologia 2011; 663: 155–166.

Victoria

Sharma

Manivannan

. Metal corrosion induced by microbial activity – mechanism and control options. J Indian Chem Soc 2021; 98: 100083.

Lovley

. Microbially mediated metal corrosion. Nat Rev Microbiol 2023; 21: 705–718.

Tang

H-Y

Holmes

Ueki

, et al. Iron corrosion via direct metal-microbe electron transfer. mBio 2019; 10: e00303–e00319.

Tang

H-Y

Yang

Ueki

, et al. Stainless steel corrosion via direct iron-to-microbe electron transfer by Geobacter species. ISME J 2021; 15: 3084–3093.

De WindT

Boon

Siciliano

, et al. Cell density related H2 consumption in relation to anoxic Fe(0) corrosion and precipitation of corrosion products by Shewanella oneidensis MR-1. Environ Microbiol 2003; 5: 1192–1202.

10.

Lopes

Morin

Oliveira

, et al. The influence of nickel on the adhesion ability of Desulfovibrio desulfuricans. Colloids Surf B Biointerfaces 2005; 46: 127–133.

11.

Tran

TTT

Kannoorpatti

Padovan

, et al. A study of bacteria adhesion and microbial corrosion on different stainless steels in environment containing Desulfovibrio vulgaris. R Soc Open Sci 2021; 8: 201577.

12.

Enning

Garrelfs

. Corrosion of iron by sulfate-reducing bacteria: new views of an old problem. Appl Environ Microbiol 2014; 80: 1126–1136.

13.

Lee

Aziz

Tajarudin

. A recent development on iron-oxidising bacteria (IOB) applications in water and wastewater treatment. J Water Proc Eng 2022; 49: 103109.

14.

Kopczybski

. Accelerated low-water corrosion in harbours: MIC, ALWC and choice of cathodic protection. 46 ed. Cherbourg, France: Port Technology International, 2010.

15.

Knisz

Eckert

Gieg

, et al. Microbiologically influenced corrosion – more than just microorganisms. FEMS Microbiol Rev 2023; 47.

16.

Huang

L-Y

, et al. Responses of soil microbiome to steel corrosion. NPJ Biofilms Microbiomes 2021; 7: 6.

17.

Skovhus Lund

Eckert

Rodrigues

. Management and control of microbiologically influenced corrosion (MIC) in the oil and gas industry – overview and a North Sea case study. J Biotechnol 2017; 256: 31–45.

18.

Wunder

Aromokeye

Yin

, et al. Iron and sulfate reduction structure microbial communities in (sub-)Antarctic sediments. ISME J 2021; 15: 3587–3604.

19.

Jameson

. ALWC and MIC: looking for more from science. 35 ed. Aberdeen, Scotland: Port Technology International, 2011.

20.

Klindworth

Pruesse

Schweer

, et al. Evaluation of general 16S ribosomal RNA gene PCR primers for classical and next-generation sequencing-based diversity studies. Nucleic Acids Res 2012; 41: e1–e1.

21.

Schloss

Westcott

Ryabin

, et al. Introducing mothur: open-source, platform-independent, community-supported software for describing and comparing microbial communities. Appl Environ Microbiol 2009; 75: 7537–7541.

22.

Mcmurdie

Holmes

. Waste not, want not: why rarefying microbiome data is inadmissible. PLOS Comput Biol 2014; 10: e1003531.

23.

Mcmurdie

Holmes

. Phyloseq: an R package for reproducible interactive analysis and graphics of microbiome census data. PLoS ONE 2013; 8: e61217.

24.

Dixon

. VEGAN, a package of R functions for community ecology. J Vegetat Sci 2003; 14: 927–930.

25.

Wickham

. ggplot2: Elegant graphics for data analysis. New York: Springer-Verlag, 2016.

26.

Cristiani

Perboni

. 15 – Corrosion monitoring in microbial environments. In: Yang

(ed.) Techniques for corrosion monitoring. 2nd ed. Cambridge: Woodhead Publishing, 2021.

27.

Pal

Lavanya

. Microbial influenced corrosion: understanding bioadhesion and biofilm formation. J Bio- Tribo-Corros 2022; 8: 76.

28.

Beech

Sunner

. Biocorrosion: towards understanding interactions between biofilms and metals. Curr Opin Biotechnol 2004; 15: 181–186.

29.

Zhang

Zhou

, et al. Flow accelerated corrosion and erosion−corrosion behavior of marine carbon steel in natural seawater. NPJ Mater Degradat 2021; 5: 56.

30.

Song

Jiang

Chen

, et al. Effects of chloride ions on corrosion of ductile iron and carbon steel in soil environments. Sci Rep 2017; 7: 6865.

31.

Kamimura

Hara

Miyuki

, et al. Composition and protective ability of rust layer formed on weathering steel exposed to various environments. Corros Sci 2006; 48: 2799–2812.

32.

Melchers

. Long-term immersion corrosion of steels in seawaters with elevated nutrient concentration. Corros Sci 2014; 81: 110–116.

33.

Miller

Lawson

Sadek

, et al. Uniform and pitting corrosion of carbon steel by Shewanella oneidensis MR-1 under nitrate-reducing conditions. Appl Environ Microbiol 2018; 84: e00790–18.

34.

Zhang

Xia

, et al. Elevated nitrate enriches microbial functional genes for potential bioremediation of complexly contaminated sediments. ISME J 2014; 8: 1932–1944.

35.

Erratt

Creed

Trick

. Comparative effects of ammonium, nitrate and urea on growth and photosynthetic efficiency of three bloom-forming cyanobacteria. Freshwater Biol 2018; 63: 626–638.

36.

Lütters-Czekalla

. Lithoautotrophic growth of the iron bacterium Gallionella ferruginea with thiosulfate or sulfide as energy source. Arch Microbiol 1990; 154: 417–421.

37.

De Vet

WWJM

Dinkla

IJT

, et al. Biological iron oxidation by Gallionella spp. in drinking water production under fully aerated conditions. Water Res 2011; 45: 5389–5398.

38.

Zhao

Wang

Liu

, et al. Biofilm: a strategy for the dominance of comammox Nitrospira. J Clean Product 2022; 363: 132361.

39.

Brink

Straten

Rensburg

AJV

. Shewanella (Pseudomonas) putrefaciens bacteremia. Clin Infect Dis 1995; 20: 1327–1332.

40.

Philips

Van Den Driessche

de Paepe

, et al. A novel Shewanella isolate enhances corrosion by using metallic iron as the electron donor with fumarate as the electron acceptor. Appl Environ Microbiol 2018; 84.

41.

, et al. Mechanism of microbiologically influenced corrosion of X65 steel in seawater containing sulfate-reducing bacteria and iron-oxidizing bacteria. J Mater Res Technol 2019; 8: 4066–4078.

42.

Smith

Bardiau

Brennan

, et al. Accelerated low water corrosion: the microbial sulfur cycle in microcosm. NPJ Mater Degradation 2019; 3: 37.

Supplementary Material

Please find the following supplemental material available below.

For Open Access articles published under a Creative Commons License, all supplemental material carries the same license as the article it is associated with.

For non-Open Access articles published, all supplemental material carries a non-exclusive license, and permission requests for re-use of supplemental material or any part of supplemental material shall be sent directly to the copyright owner as specified in the copyright notice associated with the article.

0.00 MB

0.20 MB