Development and evaluation of a skeletal mechanism for EHN additized gasoline mixtures in large Eddy simulations of HCCI combustion

Abstract

Advanced Low Temperature Combustion modes, such as the Sandia proposed Additive-Mixing Fuel Injection (AMFI), can unlock significant potential to boost fuel conversion efficiency and ultimately improve the energy conversion of internal combustion engines. This is a novel improved combustion process that is enabled by supplying small (<5%) variable amounts of autoignition improver to the fuel to enhance the engine operation and control. Common, diesel-fuel ignition-quality enhancing additive, 2-ethylexyl nitrate (EHN), is doped into gasoline to enable Sandia LTGC + AMFI combustion. This manuscript focuses on the development of a reduced sub-mechanism for EHN chemical kinetics at engine relevant conditions that is implemented into a skeletal mechanism for chemical kinetic studies of gasoline surrogate fuels. The mechanism validation utilized zero-dimensional numerical simulations and comparison to shock tube ignition-delay data of pure and EHN-doped n-heptane. Additional validation is presented with Homogeneous Charge Compression-Ignition (HCCI) engine data of pure and EHN-doped research-grade E10 gasoline. Then, the mechanism was deployed in a 3-D computational fluid dynamics (CFD) using Large Eddy Simulations (LES) to model the HCCI engine experiments of 0.4% vol EHN additized E10 gasoline at several equivalence ratios. Simulations showed a very good performance of the mechanism, and the model accurately reproduced (a) the ignition point, (b) combustion phasing, (c) combustion duration, and (d) the peak of the heat release rates of the engine experiments. The results show that EHN promotes Low-Temperature Heat Release, ultimately driving the gasoline to autoignite at thermodynamic conditions where the fuel would not otherwise ignite. Overall, this work demonstrates a viable reduced chemical-kinetic mechanism for EHN and shows that it can be combined with a skeletal gasoline mechanism for CFD-LES analysis of well-mixed LTGC that matches well with experimental results. The CFD-LES analysis also shows the spatial distribution of EHN-fuel interactions that control the autoignition throughout the combustion chamber.

Keywords

2-Ethylexyl nitrate low-temperature gasoline combustion gasoline skeletal mechanism computational fluid dynamics large eddy simulations EHN additized gasoline mixtures HCCI combustion

Get full access to this article

View all access options for this article.

References

Dec

. Advanced compression-ignition engines—Understanding the in-cylinder processes. Proc Combust Inst 2009; 32(2): 2727–2742.

Yang

Dec

Dronniou

Cannella

. Boosted HCCI combustion using low-octane gasoline with fully premixed and partially stratified charges. SAE Int J Engines 2012; 5(3): 1075–1088.

Vedharaj

Vallinayagam

, et al. Combustion homogeneity and emission analysis during the transition from CI to HCCI for FACE I gasoline. SAE technical papers, 2017.

Singh

Dibble

. Knock, auto-ignition and pre-ignition tendency of fuels for advanced combustion engines (FACE) with ethanol blends and similar RON. Technical report 2020-01-0613, SAE technical paper, 2020.

Dec

Lopez Pintor

. Demonstrating the potential of LTGC-AMFI to deliver the promise of low-temperature combustion. In: Thermo and fluid dynamic processes in direct injection engines THIESEL, Valencia, Spain, 2020.

Lopez Pintor

Gentz

Dec

. Mixture stratification for CA50 control of LTGC engines with reactivity-enhanced and non-additized gasoline. Technical report 2021-01–0513, SAE technical paper, 2021.

Gadhvi

. Relationship between fuel properties and cetane response of cetane improver for non-aromatic and aromatic fuels used in a single cylinder heavy duty diesel engine. Pet Chem Ind Int 2019; 2(1): 1–5.

Oxley

Smith

Rogers

Aradi

Henly

. Fuel combustion additives: A study of their thermal stabilities and decomposition pathways. Energy Fuels 2000; 14(6): 1252–1264.

Higgins

Siebers

Aradi

. Comparison of 2-ethylhexyl nitrate and fuel composition induced changes in the diesel spray ignition process. Int J Engine Res 2001; 2(1): 47–67.

10.

Hanson

Kokjohn

Splitter

Reitz

. Fuel effects on reactivity controlled compression ignition (RCCI) combustion at low load. SAE Int J Engines 2011; 4(1): 394–411.

11.

Kaddatz

Andrie

Reitz

Kokjohn

. Light-duty reactivity controlled compression ignition combustion using a cetane improver. Technical report 2012-01-1110, SAE technical paper, 2012.

12.

Dempsey

Walker

Reitz

. Effect of cetane improvers on gasoline, ethanol, and methanol reactivity and the implications for RCCI combustion. SAE Int J Fuel Lubricants 2013; 6(1): 170–187.

13.

Hosseini

Neill

Guo

Chippior

Fairbridge

Mitchell

. Effects of different cetane number enhancement strategies on HCCI combustion and emissions. Int J Engine Res 2011; 12(2): 89–108.

14.

Dec

Dernotte

Cannella

. Effect of ignition improvers on the combustion performance of regular-grade E10 gasoline in an HCCI engine. SAE Int J Engines 2014; 7(2): 790–806.

15.

Dec

Dernotte

Cannella

. Boosted premixed-LTGC/HCCI combustion of EHN-doped gasoline for engine speeds up to 2400 rpm. SAE Int J Engines 2016; 9(4): 2166–2184.

16.

Ickes

Bohac

Assanis

. Effect of 2-ethylhexyl nitrate cetane improver on NO_x emissions from premixed low-temperature diesel combustion. Energy Fuels 2009; 23(10): 4943–4948.

17.

Pritchard

. Thermal decomposition of isooctyl nitrate. Combust Flame 1989; 75(3–4): 415–416.

18.

Hartmann

Tian

Hofrath

, et al. Experiments and modeling of ignition delay times, flame structure and intermediate species of ehn-doped stoichiometric n-heptane/air combustion. Proc Combust Inst 2009; 32(1): 197–204.

19.

Andrae

JCG

. Semidetailed kinetic model for gasoline surrogate fuel interactions with the ignition enhancer 2-ethylhexyl nitrate. Energy Fuels 2015; 29(6): 3944–3952.

20.

Goldsborough

Johnson

Banyon

Pitz

McNenly

. Experimental and modeling study of fuel interactions with an alkyl nitrate cetane enhancer, 2-ethyl-hexyl nitrate. Proc Combust Inst 2015; 35(1): 571–579.

21.

Adhikary

. Low load operation in a light-duty diesel engine using high octane fuels and additives. PhD Thesis, The University of Wisconsin-Madison, 2014.

22.

Lopez Pintor

Dec

. Development and validation of an EHN mechanism for fundamental and applied chemistry studies. Technical report 2022-01-0455, SAE technical paper, 2022.

23.

Cheng

Saggese

Kang

, et al. Autoignition and preliminary heat release of gasoline surrogates and their blends with ethanol at engine-relevant conditions: Experiments and comprehensive kinetic modeling. Combust Flame 2021; 228: 57–77.

24.

Guleria

Lopez-Pintor

Dec

Assanis

. A comparative study of gasoline skeletal mechanisms under partial fuel stratification conditions using large eddy simulations. Int J Engine Res 2022; 23: 1658–1677.

25.

Desantes

García-Oliver

Novella

, et al. Application of a coupled Eulerian spray approach and a flamelet-based combustion model to single hole primary reference fuel sprays. In: 21st annual conference on liquid atomization and spray systems (ILASS), Zhenjiang, China, 2020.

26.

Lopez Pintor

Dec

Gerald Raymond

. Phi-sensitivity for LTGC engines: Understanding the fundamentals and tailoring fuel blends to maximize this property. Technical report 2019-01-0961, SAE technical paper, 2019.

27.

Lopez-Pintor

Dec

. Experimental evaluation of a gasoline-like fuel blend with high renewable content to simultaneously increase φ-sensitivity, Ron, and octane sensitivity. Energy Fuels 2021; 35(20): 16482–16493.

28.

Priyadarshini

Sofianopoulos

Mamalis

Lawler

Lopez-Pintor

Dec

. Understanding partial fuel stratification for low temperature gasoline combustion using large eddy simulations. Int J Engine Res 2021; 22: 1872–1887.

29.

Cuoci

Avedisian

Brunson

, et al. Simulating combustion of a seven-component surrogate for a gasoline/ethanol blend including soot formation and comparison with experiments. Fuel 2021; 288: 119451.

30.

Law

. A directed relation graph method for mechanism reduction. Proc Combust Inst 2005; 30(1): 1333–1341.

31.

Niemeyer

Sung

Raju

. Skeletal mechanism generation for surrogate fuels using directed relation graph with error propagation and sensitivity analysis. Combust Flame 2010; 157(9): 1760–1770.

32.

Gentz

Dec

Lopez Pintor

Dernotte

. Combustion-timing control of low-temperature gasoline combustion (LTGC) engines by using double direct-injections to control kinetic rates. Technical report 2019-01-1156, SAE technical paper, 2019.

33.

Lopez Pintor

Dec

Gentz

. Experimental evaluation of a custom gasoline-like blend designed to simultaneously improve ϕ-sensitivity, RON and octane sensitivity. SAE technical paper 2(2020-01-1136), 2020, pp.2196–2216.

34.

Eng

. Characterization of pressure waves in HCCI combustion. Technical report 2002-01-2859, SAE technical paper, 2002.

35.

Woschni

. A universally applicable equation for the instantaneous heat transfer coefficient in the internal combustion engine. Technical report 670931, SAE technical paper, 1967.

36.

Westbrook

Sjöberg

Cernansky

. A new chemical kinetic method of determining RON and MON values for single component and multicomponent mixtures of engine fuels. Combust Flame 2018; 195: 50–62.

37.

Richards

Senecal

Pomraning

. Converge 2.4. Madison, WI: Convergent Science, 2020.

38.

Dronniou

Dec

. Investigating the development of thermal stratification from the near-wall regions to the bulk-gas in an HCCI engine with planar imaging thermometry. SAE Int J Engines 2012; 5(3): 1046–1074.

39.

Pomraning

. Development of large eddy simulation turbulence models. PhD Thesis, University of Wisconsin, Madison, 2000.

40.

Senecal

Pomraning

Richards

, et al. Multi-dimensional modeling of direct-injection diesel spray liquid length and flame liftoff length using CFD and parallel detailed chemistry. SAE Tech Pap 2003; 112(3): 1331–1351.

41.

Babajimopoulos

Assanis

Flowers

Aceves

Hessel

. A fully coupled computational fluid dynamics and multi-zone model with detailed chemical kinetics for the simulation of premixed charge compression ignition engines. Int J Engine Res 2005; 6(5): 497–512.

42.

Dec

Hwang

Sjöberg

. An investigation of thermal stratification in HCCI engines using chemiluminescence imaging. SAE Trans 2006; 759–776.