The paper presents the results of the experimental research on the combustion process inside the cylinder of a large piston radial aircraft engine with dual spark plug ignition. The tests were carried out on the ASz-62IR-16X radial engine equipped with a double, electronically controlled ignition system with two spark plugs in each cylinder. The constant engine speed tests allowed for comparing the combustion processes with ignition carried out with different ignition advance angle offset between both spark plugs. In the test, the ignition advance angle for one spark plug was changed while leaving the ignition advance angle for the other spark plug. The tests performed for two engine operating points were to change the angle of the front spark plug and the rear spark plug. The analyses were based on the recorded pressure signal from one of the engine cylinders. It has been shown that the ignition advance angle offset significantly affects the combustion process. The obtained results indicate the leading role of the rear spark plug in initiating the combustion process. When ignition is carried out with a steady rear spark plug advance angle, the combustion process practically does not change when the ignition advance angle of the front spark plug changes. However, changing the rear spark plug advance angle at a constant front spark plug ignition advance angle significantly changes the combustion process.
McClellandRP. Development of a dual ignition system for general aircraft. SAE technical paper 710382, 1971.
2.
CzarnigowskiJJaklińskiPKarpińskiP. Comparison of dual and single spark ignition in operation of a large piston aircraft engine. Int J Engine Res2021; 22(9): 2884–2899.
3.
RamtilakAJosephASivakumarGBhatSS. Digital twin spark ignition for improved fuel economy and emissions on four stroke engines. SAE technical paper 2005-26-008, 2005.
4.
KumarNSDinakarPPaiSBailkeriNShrinivasa RaoBR. Dual plug spark ignition engine – Developments and future prospects. In: Recent developments in mechanical engineering conference, Pappanamcode, Thiruvananthapuram, 5–6 March 2009. Thiruvananthapuram: Sree Chitra Thirunal College of Engineering.
5.
ChandraH. A critical study of the dual versus single plug systems in SI engines. SAE technical paper 940452, 1994.
6.
BilginA. Geometric features of the flame propagation process for an SI engine having dual-ignition system. Int J Energy Res2002; 26(11): 987–1000.
7.
AfkhamiBWangYMiersSANaberJD. Experimental determination of flame speed and flame stretch using an optically accessible, spark-ignition engine. Int J Engine Res2021; 22(3): 856–872.
8.
Abdel-RehimAA. Impact of spark plug number of ground electrodes on engine stability. Ain Shams Eng J2013; 4(2): 307–316.
9.
LeeYGBoehlerJT. Flame kernel development and its effects on engine performance with various spark plug electrode configurations. SAE technical paper 2005-01-1133, 2005.
10.
TilzAMeyerGKieslingCPirkerGSalbrechterSWimmerA. Design of a test rig for fundamental investigations of spark characteristics. Int J Engine Res2020; 21(8): 1412–1425.
11.
JiCShiCWangSYangJSuTWangD. Effect of dual-spark plug arrangements on ignition and combustion processes of a gasoline rotary engine with hydrogen direct-injection enrichment. Energy Convers Manag2019; 181: 372–381.
12.
HwangPWChenXCChengHC. Influences of ignition timing, spark plug and intake port locations on the combustion performance of a simulated rotary engine. J Mech2016; 32(5): 579–591.
13.
AltınİBilginA. A parametric study on the performance parameters of a twin-spark SI engine. Energy Convers Manag2009; 50(8): 1902–1907.
14.
ForteCBianchiGMCortiEFantoniSCostaM. CFD methodology for the evaluation of knock of a PFI Twin Spark engine. Energy Proc2014; 45: 859–868.
15.
ChenLPanJLiuCShuGWeiH. Effect of rapid combustion on engine performance and knocking characteristics under different spark strategy conditions. Energy2020; 192: 116706.
16.
AndersonEBrownABaranskiJHokeJLitkePSchauerF. Performance of low-octane fuels in a Rotax 914 engine with advanced knock mitigation strategies. In: 47th AIAA/ASME/SAE/ASEE joint propulsion conference & exhibit, San Diego, CA, 31 July–3 August 2011. Reston, VA: American Institute of Aeronautics and Astronautics.
17.
ForteCBianchiGMCortiEFantoniS. Evaluation of the effects of a twin spark ignition system on combustion stability of a high performance PFI engine. Energy Proc2015; 81: 897–906.
18.
AltınİBilginA. Quasi-dimensional modeling of a fast-burn combustion dual-plug spark-ignition engine with complex combustion chamber geometries. Appl Therm Eng2015; 87: 678–687.
19.
BilginAAltınISezerI. Investigation of the effect of dual ignition on the exhaust emissions of an SI engine operating on different conditions by using quasi-dimensional thermodynamic cycle model. Strojarstvo2009; 51(5): 459–464.
20.
BozzaFGimelliASianoDTorellaEMastrangeloG. A quasi-dimensional three-zone model for performance and combustion noise evaluation of a twin-spark high-EGR engine. SAE technical paper 2004-01-0619, 2004.
21.
JainGKabraS. Experimental study on a dual spark plug ignition engine. Bachelor of Technology in Mechanical Engineering Dissertation, Indian Institute of Technology, Delhi, 1989.
22.
KociszewskiA. Numerical analysis of spark plugs number influence on selected parameters of combustion in piston engine. Silniki Spalinowe2008; 132: 50–55.
23.
YunHIdicheriaCNajtP. The effect of advanced ignition system on gasoline low temperature combustion. Int J Engine Res2021; 22(2): 417–429.
24.
YıldızMAlbayrak ÇeperB. Combustion development in a gasoline-fueled spark ignition–controlled auto-ignition engine operated at different spark timings and intake air temperatures. Int J Engine Res2021; 22(2): 351–363.
25.
MorovatiyanMShahsavanMShenMMackJH. Investigation of the effect of electrode surface roughness on spark ignition. In: Proceedings of the Internal combustion engine division fall technical conference, ASME, ICEF2018-9691, San Diego, CA, 4–7 November 2018.
26.
PrashanthJAntonyAJKhanSA. Experimental investigation on the performance of single spark ignition and twin spark ignition engine fuelled with ethanol-gasoline blends. J Adv Res Fluid Mech Thermal Sci2020; 65(1): 25–41.
27.
DuanXZhangSLiuY, et al. Numerical investigation the effects of the twin-spark plugs coupled with EGR on the combustion process and emissions characteristics in a lean burn natural gas SI engine. Energy2020; 206: 118181.
28.
GongCSunJLiuF. Numerical study of twin-spark plug arrangement effects on flame, combustion and emissions of a medium compression ratio direct-injection methanol engine. Fuel2020; 279: 118427.
29.
GongCSunJLiuF. Numerical research on combustion and emissions behaviors of a medium compression ratio direct-injection twin-spark plug synchronous ignition methanol engine under steady-state lean-burn conditions. Energy2021; 215: 119193.
30.
GongCSunJChenYLiuF. Numerical study of cold-start performances of a medium compression ratio direct-injection twin-spark plug synchronous ignition engine fueled with methanol. Fuel2021; 285: 119235.
31.
AlokPSahuD. CFD simulation of gasoline and methanol combustion in a twin spark IC engine. In: Proceedings of international conference on thermofluids, 2021. Singapore: Springer.
32.
PietrykowskiK. The CFD model of the combustion process in a radial engine. SAE technical paper 2014-01-2578, 2014.
33.
Altın BilginAÇeperBA. Parametric study on some combustion characteristics in a natural gas fueled dual plug SI engine. Energy2017; 139: 1237–1242.
34.
KangSKoDLeeSChoYChoiWKimC. An experimental study combustion and emission characteristics of HCNG with dual spark plug in a constant volume chamber. SAE technical paper 2011-28-0019, 2011.
35.
DengBLiQChenY, et al. The effect of air/fuel ratio on the CO and NOx emissions for a twin-spark motorcycle gasoline engine under wide range of operating conditions. Energy2019; 169: 1202–1213.
36.
YontarAADoğuY. Effects of equivalence ratio and CNG addition on engine performance and emissions in a dual sequential ignition engine. Int J Engine Res2020; 21(6): 1067–1082.
37.
RamegoudaRJosephAA. Effect of compression ratio on performance and emission characteristics of dual spark plug ignition engine fueled with n-butanol as additive fuel. Int J Renew Energy Dev2021; 10(1): 37–45.
38.
RavikumarRAntonyAJ. Influence of spark timing on performance and emission characteristics of engine with dual spark plug in single cylinder using gasoline and n-butanol as fuel. Int J Sci Eng Sci2020; 4(12): 11–14.
39.
BailkeriNKrishna PrasadSShrinivasa RaoBR. Performance study on twin plug spark ignition engine at different ignition timings. Int J Sci Res2013; 2(8): 231–236.
40.
ShiCJiCWangSYangJMaZXuP. Assessment of spark-energy allocation and ignition environment on lean combustion in a twin-plug Wankel engine. Energy Convers Manag2020; 209: 112597.
41.
ChenYLiuADengB, et al. The influences of ignition modes on the performances for a motorcycle single cylinder gasoline engine at lean burn operation: looking inside interaction between flame front and turbulence. Energy2019; 179: 528–541.
42.
RajuMS. Heat transfer and performance characteristics of a dual-ignition Wankel engine. SAE technical paper 920303, 1992.
43.
SinghAKRehmanA. The effect of dual spark plug on engine performance parameter in two stroke gasoline engine. Int J Appl Res Stud2013; 2(7): 2278–9480.
44.
MaFZhaoCZhangS. Study on dual-spark ignition rapid combustion characteristic of opposed-piston two-stroke GDI engine. Energy Proc2014; 61: 722–725.
45.
MaFYangWXuJ, et al. Experimental investigation of combustion characteristics on opposed piston two-stroke gasoline direct injection engine. Energies2021; 14(8): 2105.
46.
LiYZhangXWangYSunJFanX. Experimental study on premixed combustion characteristics of methane-air under dual spark plug ignition strategy in a closed spherical chamber. Fuel2022; 314: 123093.
47.
CzarnigowskiJJaklińskiPWendekerM. Fuelling of aircraft radial piston engines by ES95 and 100LL gasoline. Fuel2010; 89(11): 3568–3578.
48.
CzarnigowskiJAJaklińskiPKarpińskiP. Effects of ignition control on combustion process non-repeatability in an aircraft radial piston engine. SAE technical paper 2020-01-2044, 2020.
49.
CzarnigowskiJWendekerMJaklińskiP, et al. Testing non-uniformity of the combustion process in a radial aircraft engine. SAE technical paper 2007-01-2074, 2007.
50.
CzarnigowskiJ. Analysis of cycle-to-cycle variation and non-uniformity of energy production: tests on individual cylinders of a radial piston engine. Appl Therm Eng2011; 31(10): 1816–1824.
51.
GęcaMWendekerMLitakG. Combustion variability and uniqueness in cylinders of a large power radial engine. J Vibroengineering2012; 14(2): 582–590.
52.
XudongSHongguangLRuowenWMengX. Modeling and simulation of aviation engine ignition spark frequency disorder. Open Electr Electron Eng J2015; 9(1): 193–199.
53.
Wytwórnia Sprzętu Komunikacyjnego Pzl Kalisz SA. Technical description of the ASz-62IR aircraft engine series 16 (polish: Opis techniczny silnika lotniczego ASz-62IR serii 16). Warsaw: Transport Equipment Manufacturing Plant (Wytwórnia Sprzà̀tu Komunikacyjnego), State Aviation Works (Polskie Zakłady Lotnicze), 1976.
54.
PietrykowskiKWendekerMCzarnigowskiJJaklińskiPNazarewiczAGęcaM. Analysis of radial engine induction - CFD simulation (polish: Analiza napełniania silnika gwiazdowego - badania symulacyjne). In: PTNSS CONGRESS SC2-151. Bielsko-Biała: Polskie Towarzystwo Naukowe Silników Spalinowych, 2007, pp.258–270.
