Plastic greenhouses, widely adopted due to low cost and flexibility, often rely on natural ventilation, which can cause heat accumulation and the buildup of airborne pathogens and harmful gases. This study evaluated the influence of installation height of air purifiers and circulation fans on indoor air quality (IAQ) in a plastic greenhouse using CFD simulations. Device heights and operating conditions were varied, and IAQ was assessed through age of air. The CFD model was validated against measured indoor temperature data, yielding a mean absolute percentage error of 3.9%. A sensitivity analysis confirmed robustness, as variations in outdoor air temperature (±1°C), ground temperature (±1°C) and solar radiation (±10%) caused prediction variations of about ±1.6%, ±1.5% and ±1.0%, respectively. During daytime, placing air purifiers at 2.6 m and circulation fans at 4.0 m minimized the age of air and suppressed thermal stratification, while at nighttime favourable IAQ was maintained even without fan operation. Compared with less effective setups, the recommended configuration reduced the age of air by approximately 21%. These results suggest an energy-efficient strategy in which both devices are operated during the day and only the purifiers at night, providing practical guidance for low-cost IAQ management in plastic greenhouses.
ShinHDJeeHJShimCK. First report of powdery mildew caused by Podosphaera fusca on Lactuca sativa in Korea. Plant Pathol2006; 55: 14.
3.
CoppingLGMennJJ. Biopesticides: a review of their action, applications and efficacy. Pest Manag Sci2000; 56: 651–676.
4.
GrünwaldNJFlierWG. The biology of phytophthora infestans at its center of origin. Annu Rev Phytopathol2005; 43: 171–190.
5.
ChristopherEB. The study of the effects of airborne fungal spores in allergic and pathogenic infections in Akoko environment, Ondo state, Nigeria. World J Biol Pharm Health Sci2020; 3: 30–42.
6.
SaltveitME. Effect of ethylene on quality of fresh fruits and vegetables. Postharvest Biol Technol1999; 15: 279–292.
7.
KhanNAKhanMIRFerranteAPoorP. Editorial: ethylene: a key regulatory molecule in plants. Front Plant Sci2017; 8: 1782.
8.
MoreiraAda SilvaMV. Pesticide application as a risk factor/behaviour for workers’ health: a systematic review. Environ2023; 10: 60.
9.
RayhanaRXiaoGLiuZ. Internet of things empowered smart greenhouse farming. IEEE J Radio Freq Identif2020; 4: 195–211.
10.
JeaunitaTCJSarasvathiVHarshaMSBhavaniBMKavyashreeT. An automated greenhouse system using agricultural Internet of Things for better crop yield. In: Smart Cities Symposium 2018, Bahrain, 22–23 April 2018, pp.1–6. https://doi.org/10.1049/cp.2018.1388.
11.
KilEJParkJLeeHKimJChoiHSLeeKYKimCSLeeS. Lamium amplexicaule (Lamiaceae): a weed reservoir for tomato yellow leaf curl virus (TYLCV) in Korea. Arch Virol2014; 159: 1305–1311.
MarianiLFerranteA. Agronomic management for enhancing plant tolerance to abiotic stresses drought, salinity, hypoxia, and lodging. Hortic2017; 3: 52.
14.
SaseS. Air movement and climate uniformity in ventilated greenhouses. Acta Hortic2006; 719: 313–324.
15.
LakhiarIAGaoJSyedTNChandioFAButtarNA. Modern plant cultivation technologies in agriculture under controlled environment: a review on aeroponics. J Plant Interact2018; 13: 338–352.
16.
ZhangYKaciraM. Air distribution and its uniformity. In: Smart plant factory: the next generation indoor vertical farms. Singapore: Springer, 2018, pp.153–166.
17.
ArgentoSGarciaGTreccarichiS. Sustainable and low-input techniques in Mediterranean greenhouse vegetable production. Hortic2024; 10: 97.
18.
WangZBaoALiJHeJWangKWangXSunX. Study on the effect of non-uniform ventilation on energy and plant growth in a greenhouse. Hortic2025; 11: 66.
19.
ZhangYKaciraM. Analysis of climate uniformity in indoor plant factory system with computational fluid dynamics (CFD). Biosyst Eng2022; 220: 73–86.
20.
BaekMSKwonSYLimJH. Improvement of the crop growth rate in plant factory by promoting air flow inside the cultivation. Int J Smart Home2016; 10: 63–74. https://gvpress.com/journals/IJSH/vol10_no2/7.pdf.
21.
KangLYvan HooffT. Numerical evaluation and optimization of air distribution system in a small vertical farm with lateral air supply. Dev Built Environ2024; 17: 100304.
22.
LimTGKimYH. Analysis of airflow pattern in plant factory with different inlet and outlet locations using computational fluid dynamics. J Biosyst Eng2014; 39: 310–317.
23.
ZhangYKaciraMAnL. A CFD study on improving air flow uniformity in indoor plant factory system. Biosyst Eng2016; 147: 193–205.
24.
YuHYuHZhangBChenMLiuYSuiY. Quantitative perturbation analysis of plant factory LED heat dissipation on crop microclimate. Hortic2023; 9: 60.
25.
LeeSWSeoIHAnSWNaHY. Improvement of environmental uniformity in a seedling plant factory with porous panels using computational fluid dynamics. Hortic2023; 9: 1027.
26.
OrgazFFernándezMDBonachelaSGallardoMFereresE. Evapotranspiration of horticultural crops in an unheated plastic greenhouse. Agric Water Manag2005; 72: 81–96.
27.
FernándezMDBonachelaSOrgazFThompsonRLópezJCGranadosMRGallardoMFereresE. Measurement and estimation of plastic greenhouse reference evapotranspiration in a Mediterranean climate. Irrig Sci2010; 28: 497–509.
28.
SandbergMSjöbergM. The use of moments for assessing air quality in ventilated rooms. Build Environ1983; 18: 181–197.
29.
DestaTZvan BuggenhoutSvan BrechtAMeyersJAertsJMBaelmansMBerckmansD. Modelling mass transfer phenomena and quantification of ventilation performance in a full scale installation. Build Environ2005; 40: 1583–1590.
30.
LiLHeYChenWJiYFungJCHLauAKH. An integrated experimental and CFD analysis of ceiling-fan-integrated air conditioning system: indoor air quality and air velocity. Build Environ2024; 258: 111633.
31.
LiXLiDYangXYangJ. Total air age: an extension of the air age concept. Build Environ2003; 38: 1263–1269.
32.
KwonKSLeeIBHanHTShinCYHwangHSHongSWBitogJPSeoIHHanCP. Analysing ventilation efficiency in a test chamber using age-of-air concept and CFD technology. Biosyst Eng2011; 110: 421–433.
33.
NohJHLeeJNohKCKimYWYookSJ. Effects of hospital ward curtains on ventilation in a four-bed hospital ward. Aerosol Air Qual Res2018; 18: 2643–2653.
34.
LeeJNohJHNohKCKimYWYookSJ. Effect of a system air conditioner on local air quality in a four-bed ward. Aerosol Air Qual Res2021; 21: 200533.
35.
FangHLiKWuGChengRZhangYYangQ. A CFD analysis on improving lettuce canopy airflow distribution in a plant factory considering the crop resistance and LEDs heat dissipation. Biosyst Eng2020; 200: 1–12.
