Moisture Gain of Spray-Applied Insulations and Its Effect on Effective Thermal Conductivity-Part I

Abstract

The presence of free water in fibrous insulating materials can have a very det rimental effect on their thermal and physical properties. Fiberglass and cellu lose insulations were spray-applied to horizontal aluminum plates and exposed to air at relative humidities of 30, 50, and 70% and temperature differences of 20 and 27 C°. The moisture gain was determined by periodically weighing the samples, and the effect of the moisture on the heat flow and temperature distri bution was measured by heat flow sensors and thermocouples. Drying was also investigated by reducing the relative humidity to 10% once steady state had been reached. The rate of moisture gain and the total moisture gain increased with increasing relative humidity and temperature difference, and, after an initial increase, the apparent thermal conductivity would attain a quasi-steady state value that was directly proportional to the moisture gain.

Keywords

Moisture gain Effective thermal conductivity Spray-applied insulations Fiber glass Cellulose Condensation.

Get full access to this article

View all access options for this article.

References

Jespersen, H.B. , J. of the Institute of Heating and Ventilation Engineermg, Vol. 21, No. 216, pp. 157-174 (1953).

Joy, F. A. , Symposium on Thermal Conductivity Measurements and Applications of Thermal Insulations, ASTM-STP 217, American Society for Testing and Materials, pp. 65-80 (1957).

Langlais, C. , Hyrien, M. , and Klarsfelt, S. , "Influence of Moisture on Heat Transfer through Fibrous-Insulation Materials," Thermal Insulation Materials and Systems for Energy Conservation in the 80's, ASTM-STP 789, pp. 563-581 (1983).

Thomas, W.C. , Bal, G.P. , and Onega, R.J. , "Heat and Mass Transfer in Glass Fiber Roof Insulating Material," Thermal Insulation Matenals and Systems for Energy Conservation in the 80's, ASTM-STP 789 , pp. 582-601 (1983).

Powell, F.J. and Robinson, H.E. , "The Effect of Moisture on the Heat Transfer Performance of Insulated Flat-Roof Constructions," Building Science Series 37, U.S. National Bureau of Standards, Gaithersburg, Md. ( 1971).

Philip, J.R. and DeVries, D.A. , "Moisture Movement in Porous Materials under Temperature Gradients," Trans. of Am. Geophys. Union, 38 (2), pp. 222-231 (1957).

Harmathy, T.Z. , "Simultaneous Moisture and Heat Transfer in Porous Systems with Particular Reference to Drying," Ind. & Eng. Chem. Fundamentals, 8 (1), pp. 92-103 (1969).

Luikov, A.V. , Heat and Mass Transfer in Capillary Porous Bodies, Pergamon Press, Oxford ( 1966).

Luikov, A.V. , "Systems of Differential Equations of Heat and Mass Transfer in Capillary Porous Bodies," Int. J. Heat and Mass Transfer, 18, pp. 10-14 (1975).

10.

Huang, C.L.D. , "Multi-Phase Moisture Transfer in Porous Media Subjected to Temperature Gradient," Int. J. Heat and Mass Transfer, 22, pp. 1295-1307 (1979 ).

11.

Eckert, E.G. and Faghri, M. , "A General Analysis of Moisture Migration Caused by Temperature Differences in an Unsaturated Porous Medium," Int. J Heat and Mass Transfer, 23, pp. 1613-1623 (1980).