Seven-level grid-connected packed U-cells inverter using photovoltaic generators system

Abstract

In this article, one of the most recent multilevel converter topologies named packed U-cells is developed for three-phase grid-connected inverter mode using photovoltaic input voltage sources. This topology makes a very important research subject in what concerns the adaptation of multilevel inverters with photovoltaic systems. According to the literature, it is well applicable with the string type and suitable for high-voltage applications because the number of switches is less than conventional topology and maximum blocking voltage is U_dc and 2U_dc; however, it is not applicable for multistring type and unsuitable for the central type because it is based on isolated DC source. The packed U-cells topology is highly optimized from the point of view of the number of passive and active components. The output voltages of our converter are composed by seven levels obtained by the auxiliary buses voltages regulation. In order to obtain the DC input voltages of 120 V for the inverter, photovoltaic generators are connected to a boost converters. The maximum power point tracking method based on the Perturb and Observe was used to improve and optimize the performance of the photovoltaic system control in the simulation part. The grid-connected PUC7 inverter operates with a unit power factor and injects active power into the grid. The control is configured to make the current waveform in phase with the AC voltage waveform. Reference angle variations have been made to operate with different power factors to test the performance of the applied control and the influence of these variations on the auxiliary buses voltages regulation. The simulations were done under Matlab/Simulink platform and have been experimentally verified using dSpace 1104 controller board and three-phase packed U-cells inverter composed by nine half-bridge insulated-gate bipolar transistor modules.

Keywords

Grid connection packed U-cells inverter photovoltaic generators phase locked loop seven-level voltage control

Get full access to this article

View all access options for this article.

References

Nabae

Takahashi

Akagi

. A new neutral-point-clamped PWM inverter. IEEE T Ind Appl 1981; IA-17: 518–523.

Kim

Youngroc

Song

, et al. Design and control of a grid-connected three-phase 3-level NPC inverter for building integrated photovoltaic systems. IEEE Comput Soc 2012; 1: 1–7.

, et al. A simplified PWM strategy for neutral point clamped (NPC) three-level converter with unbalanced DC-links. IEEE T Power Electron 2016; 31: 3227–3238.

Meynard

Foch

. Multi-level conversion: high voltage choppers and voltage-source inverters. In: 23rd annual IEEE power electronics specialists conference, Toledo, 29 June–3 July 1992, pp. 397–403. New York: IEEE.

In-Dong

Eui-Cheol

Heung-Geun

, et al. A generalized Undeland snubber for flying capacitor multilevel inverter and converter. IEEE T Ind Electr 2004; 51: 1290–1296.

Jing

Keith

. C: extended operation of flying capacitor multilevel inverters. IEEE T Power Electron 2006; 21: 140–147.

Roshan-Kumar

Sudharshan

Gopakumar

, et al. A seventeen-level inverter formed by cascading flying capacitor and floating capacitor H-bridges. IEEE T Power Electron 2015; 30: 3471–3478.

Peng

Lai

McKeever

, et al. A multilevel voltage-source inverter with separate DC sources for static VAr generation. IEEE T Ind Appl 1996; 32: 1130–1138.

Odeh

. Sinusoidal pulse-width modulated three-phase multi-level inverter topology. Electr Power Component Syst 2015; 43: 1–9.

10.

Marino

Fabio

Pierluigi

, et al. Maximum power point tracking algorithm for grid tied photovoltaic cascaded H-bridge inverter. Electr Power Component Syst 2015; 43: 951–963.

11.

Saroj

Tanmoy

. Phase shifted carrier based synchronized sinusoidal PWM techniques for cascaded H-bridge multi level inverter. IEEE Trans Power Electr 2018; 33: 513–524.

12.

Siddique

Mekhilef

Shah

, et al. A new single-phase cascaded multilevel inverter topology with reduced number of switches and voltage stress. Int Trans Electr Energ Syst 2019; 30: e12191.

13.

Schweizer

Kolar

. Design and implementation of a hybrid efficient three-level T-type converter for low-voltage applications. IEEE T Power Electron 2013; 28(2): 899–907.

14.

Mustafa İNC. Performance analysis of T-type inverter based on improved hysteresis current controller. Balkan J Electr Comput Eng 2019; 7(2): 149–155.

15.

Ounejjar

Al-Haddad

. A novel high energetic efficiency multilevel topology with reduced impact on supply network. In: 34th annual conference of IEEE industrial electronics, Orlando, FL, 10–13 November 2008, pp.489–494. New York: IEEE.

16.

Ounejjar

Al-Haddad

Luc-André

, et al. Theoretical study and experimental validation. IEEE T Ind Electron 2011; 58: 1294–1306.

17.

Ounejjar

Al-Haddad

Louis

. A novel six-band hysteresis control for the packed U cells seven-level converter: experimental validation. IEEE T Ind Electron 2012; 59: 3808–3816.

18.

Ounejjar

Al-Haddad

Hani

. An advanced photovoltaic system based on the fifteen-level PUC inverter. In: 24th international symposium on industrial electronics (ISIE), Buzios, 3–5 June 2015, pp.1056–1061. New York: IEEE.

19.

Mohamed

Sertac

Khalid Ahmed

, et al. Finite-control-set model predictive control for grid-connected packed-u-cells multilevel inverter. IEEE T Ind Electr 2016; 63: 7286–7295.

20.

Mohamed

Malek

Majdi

, et al. An original observer design for reduced sensor control of packed U cells based renewable energy system. Int J Hydrogen Energ 2017; 42: 17910–17916.

21.

Hani

Mohammad

Al-Haddad

. Modified seven-level pack U-cell inverter for photovoltaic applications. IEEE J Emerg Select Topic Power Electron 2018; 6: 1508–1516.

22.

Jeyraj

Nasrudin

. Multilevel inverter for grid-connected PV system employing digital PI controller. IEEE T Ind Electron 2009; 56: 149–158.

23.

Gabriele

Claudio

Darko

, et al. A new multilevel conversion structure for grid-connected PV applications. IEEE T Ind Electron 2009; 56: 4416–4426.

24.

Javier

Domingo

Francesc

, et al. Energy-balance control of PV cascaded multilevel grid-connected inverters under level-shifted and phase-shifted PWMs. IEEE T Ind Electron 2013; 60: 98–111.

25.

Konstantinos

Antonio

. Dynamic analysis of PLL-synchronized power inverter interface for grid-connected PV systems. In: 2018 annual American control conference (ACC), Milwaukee, WI, 27–29 June 2018, pp.2127–2132. New York: IEEE.

26.

Jabavathi

Sait

Ehsan

. Development of a lab module for multi-interface solar photovoltaic inverter for three-phase loads. Int J Electr Eng Educ 2019; 14: 113513838.

27.

Raj

MMP

Sundaram

SSM

. Cascaded H-bridge five-level inverter for grid-connected photovoltaic system using proportional–integral controller. Meas Control 2016; 49(1): 33–41.

28.

Babaie

Sharifzadeh

Mehrasa

, et al. PV panels maximum power point tracking based on ANN in three-phase packed E-Cell inverter. In: 2020 IEEE international conference on industrial technology (ICIT), Buenos Aires, 26–28 February 2020. New York: IEEE.

29.

Mohd Ali

Krishnaswamy

. An assessment of recent multilevel inverter topologies with reduced power electronics components for renewable applications. Renew Sust Energ Rev 2018; 82: 3379–3399.