Heat exchangers provide means to maintain the temperature of a system at its desired level. In this paper, numerical simulations of a heat exchanger with staggered arrangement of elliptical-shaped tubes have been performed to analyze its performance. Keeping the Reynolds number of dry and humid cooling air between 5000 and 20,000, the impact of relative humidity on the forced convection and the average Nusselt number is analyzed for a typical radiator cross-section. Numerical results indicate an increasing trend of the Nusselt number (up to 4.5%) with relative humidity. This variation becomes more pronounced when the capacity of air to absorb water increases with the same relative humidity but at higher temperatures.
CaoWI LAYookS-J, et al.Simulation of the dynamics of colloidal mixture of water with various nanoparticles at different levels of partial slip: ternary-hybrid nanofluid. Int Commun Heat Mass Transfer2022; 135: 0735–1933. DOI: 10.1016/j.icheatmasstransfer.2022.106069.
2.
IsaacASe-JinYMuhammadT, et al.Dynamics of ternary-hybrid nanofluid subject to magnetic flux density and heat source or sink on a convectively heated surface. J Surf Inter Mater2021; 28: 101654. DOI: 10.1016/j.surfin.2021.101654.
3.
El GharbiNKheiriAEl GanaouiM, et al.Numerical optimization of heat exchangers with circular and non-circular shapes. Case Stud Therm Eng2015; 6: 194–203.
4.
MerkerGHankeH. Heat transfer and pressure drop on the shell-side of tube-banks having oval-shaped tubes. Int J Heat Mass Transfer1986; 29(12): 1903–1909.
5.
HammockGL. Cross-flow staggered-tube heat exchanger analysis for high enthalpy flows. USA: Master’s Thesis, University of Tennessee, 2011.
6.
Uguru-OkorieDIkpotokinIOsuekeC, et al.Experimental comparison of staggered and in-line tube-bank thermal performance. Int J Mech Eng Technol2018; 9: 1061–1070.
7.
AkbariMLavasaniAMNaseriA. Experimental investigation of the heat transfer for non-circular tubes in a turbulent air cross flow. Experimental Heat Transfer2020; 34: 1–18.
8.
ZhangJGuptaABakerJ. Effect of relative humidity on the prediction of natural convection heat transfer coefficients. Heat Transfer Eng2007; 28(4): 335–342.
9.
StillMVenzkeHDurstF, et al.Influence of humidity on the convective heat transfer from small cylinders. Experiments in Fluids1998; 24: 141–150.
10.
MurtyMCMannaPChakrabortyD. Conjugate heat transfer analysis in high speed flows. Proc Inst Mech Eng G J Aerosp Eng2013; 227(10): 1672–1681. DOI: 10.1177/0954410012464920.
11.
BeiraoSLourencoMSantosF, et al.Thermal conductivity of humid air. Int J Thermophys2012; 33: 1686–1703.
12.
RabijitDAnupamDBalajiS. CFD study of slot jet impingement heat transfer with nanofluids. Proc Inst Mech Eng C: J Mech Eng Sci2016; 230: 206–220.
13.
TsilingirisP. Thermophysical and transport properties of humid air at temperature range between 0 and 100◦C. Energ Convers Manage2008; 49(5): 1098–1110.
14.
SuyiHShizhouP. Convection and heat transfer of elliptical tubes. Heat Mass Transfer1995; 30(6): 411–415.
15.
CastigliaDBalabaniSPapadakisG, et al.An experimental and numerical study of the flow past elliptic cylinder arrays. Proc Inst Mech Eng Part C: J Mech Eng Sci2001; 215(11): 1287–1301.
16.
ZukauskasA. Heat transfer from tubes in crossflow. Adv Heat Transfer, Elsevier1972; 0065–2717: 93–160.
17.
ZukauskasAUlinskasR. Heat transfer in tube banks in crossflow. Springer Berlin Heidelberg, 1988.
18.
ZhaoXGrönstedtT. Conceptual design of a two-pass cross-flow aeroengine intercooler. Proc Inst Mech Eng Part G J Aerospace Eng2015; 229(11): 2006–2023. DOI: 10.1177/0954410014563587.
Ansys Fluent User Guide. Chapter 7.7.4. ANSYS Inc, 2013.
21.
HuZSunDW. Predicting local surface heat transfer coefficients by different turbulent k-models to simulate heat and moisture transfer during air-blast chilling. Int J Refrigeration2001; 24: 702–717.
22.
YakhotVSmithLM. The renormalization group, the - expansion and derivation of turbulence models. J Scientif Comput1992; 7(1): 35–61.
23.
BarthTJespersenD. The design and application of upwind schemes on unstructured meshes. Proceedings of the AIAA 27th Aerospace Sciences Meeting, Reno 9-12 January 1989, DOI: 10.2514/6.1989-366.
24.
FrankP I TLBDewittDPLavineAS. Fundamentals of heat and mass transfer, Chap. 6.47. 6th ed.John Wiley Sons, 2006, p. 370.
25.
IsaacANehadSAbderrahimW, et al.Ratio of momentum diffusivity to thermal diffusivity: introduction, meta-analysis, and scrutinization. New York: Chapman and Hall/CRC, 2022.
26.
BourisDKonstantinidisEBalabaniS, et al.Design of a novel, intensified heat exchanger for reduced fouling rates. Int J Heat Mass Transfer2005; 48: 3817–3832.
