Influence of leading edge imperfections on the aerodynamic characteristics of NACA 63 2 -215 laminar aerofoils at low Reynolds numbers

Abstract

This article deals with the effect of leading edge imperfections on the aerodynamic characteristics of a NACA 63₂-215 laminar aerofoil at low Reynolds numbers. Wind tunnel tests have been performed at different Reynolds numbers and angles of attack and global aerodynamic loads were measured. To perform these tests, a NACA 63₂-215 aerofoil was built up in two halves (corresponding to the upper side and to the lower side), the leading edge imperfection here considered being a slight displacement of half aerofoil with respect to the other. From experimental results, a quantitative measure of the influence of the leading edge displacement on the degradation of the aerofoil aerodynamic performances has been obtained. This allows the establishment of a criterion for an acceptance limit for this kind of imperfection.

Keywords

Leading edge low Reynolds number laminar aerofoil

Get full access to this article

View all access options for this article.

References

Carmichael BH. Low Reynolds number airfoil survey. Report, NASA CR-165803, Vol. 1, 1981, USA.

Nagamatsu

Cuche

. Low Reynolds number aerodynamics characteristics of low-drag NACA 63-208 airfoil. J Aircraft 1981; 18: 833–837.

Mueller

Batill

. Experimental studies of separation on a two-dimensional airfoil at low Reynolds number. AIAA J 1982; 20: 457–463.

Lissaman

PBS

. Low–Reynolds-number airfoils. Ann Rev Fluids Mech 1983; 15: 223–239.

Cebeci

. Essential ingredients of a method for low Reynolds number airfoils. AIAA J 1989; 27: 1680–1688.

Bloy

Roberts

. Aerodynamic characteristics of the NACA 63(2)-215 aerofoil for use in wind turbines. Wind Eng 1993; 17: 67–75.

Mueller

DeLaurier

. Aerodynamics of small vehicles. Ann Rev Fluids Mech 2003; 35: 98–111.

Torres

Mueller

. Low-aspect-ratio wing aerodynamics at low Reynolds number. AIAA J 2004; 42: 865–873.

Ayuso L, Sant R and Meseguer J. Aerodynamic study of airfoils with leading edge imperfections at low Reynolds number. In: 40th AIAA fluid dynamics conference, 2010, Chicago, IL, USA.

10.

Sant R, Ayuso L and Meseguer J. Aerodynamic study of airfoil geometric imperfections at low Reynolds number. In: 13th international conference on wind engineering, ICWE13, Amsterdam, The Netherlands, 2011.

11.

Jones

Bakhtian

Babinsky

. Low Reynolds number aerodynamics of leading-edge flaps. J Aircraft 2008; 45: 342–345.

12.

Abbott

Von Doenhoff

. Theory of wing sections, NY, USA: Dover Publications Inc, 1959.

13.

Allen HJ and Vincenti WG. Wall interference in a two-dimensional-flow wind tunnel, with consideration of compressibility. NACA Report no. 782, 1944, USA.

14.

Pope

Harper

. Low speed wind tunnel testing, New York, USA: Wiley, 1966.

15.

Marchman

. Aerodynamics testing at low Reynolds numbers. J Aircraft 1987; 24: 107–114.

16.

McGullough GB and Gault DE. Examples of three representative types of airfoil-section stall at low speed, NACA Report no. TN 2502, 1951, USA.

17.

Palme HO. Summary of stalling characteristics and maximum lift of wings at low speed, SAAB TN 15, Svenska Aeroplan Akbtiebolaget, Linköping, Sweden, 1953.