Experimental investigation of scavenging in two-stroke engines using continuous CO 2 sampling

Abstract

In internal combustion engines, the chemical composition of the trapped fuel-air-residual gas mixture controls the nature of combustion, which, in turn, determines the characteristics of the ensuing emissions and work production processes. Therefore, knowledge of the trapped mixture’s composition is critical for reliably predicting and controlling engine performance, emissions, and efficiency. A good index of the overall trapped mixture composition is the trapped equivalence ratio. Unfortunately, in two-stroke engines, it is unfeasible to accurately determine the trapped equivalence ratio using traditional intake flow measurements and exhaust emissions data. This limitation arises from the simultaneous occurrence of intake and exhaust processes in two-stroke engines, which causes: (1) exhaust emissions to be diluted by excess fresh air that was supplied for achieving effective gas exchange, that is trapping inefficiencies and (2) a significant fraction of combustion products to stay back in the cylinder as residual gas, that is scavenging inefficiencies. The current paper presents an experimental study carried out on a cross-scavenged, lean-burn, natural-gas, two-stroke engine to characterize its scavenging performance, thus paving the way for trapped equivalence ratio computation. CO₂ is used as a tracer for combustion products, and its concentration is tracked in the combustion chamber and exhaust manifold on a crank-angle-resolved basis using high-speed nondispersive infrared sensors. The changes in cylinder CO₂ concentration before and after gas exchange are used to determine the trapped residual fraction and various features of the exhaust CO₂“wave” are used to explain the temporal progression of the gas exchange process. The presented results show the effects of changes in engine operation (speed, load, and spark-timing) on the engine’s scavenging efficiency. Speed and load changes are found to have the most pronounced effects, which result from changes in port open duration and phasing of reflected waves in the exhaust.

Keywords

Two-stroke engines scavenging gas exchange engine emission control single cylinder engines

Get full access to this article

View all access options for this article.

References

Osborne

Stokes

Lake

, et al. Development of a two-stroke/four-stroke switching gasoline engine-the 2/4SIGHT concept. SAE paper 2005-01-1137, 2005.

Groff

. Automotive two-stroke-cycle engine development in the 1980-1990’s. SAE paper 2016-01-0177, 2016.

Pugnali

Chen

. Feasibility study of operating 2-stroke miller cycles on a 4-stroke platform through variable valve train. SAE paper 2015-01-1974, 2015.

Herold

Wahl

Regner

, et al. Thermodynamic benefits of opposed-piston two-stroke engines. SAE paper 2011-01-2216, 2011.

Wallace

Cave

. Experimental and analytical scavenging studies on a two-cycle opposed piston diesel engine. SAE paper 710175, 1971.

Heywood

. Internal combustion engine fundamentals. New York, NY: McGraw Hill, 1988.

Dang

Wallace

. Some single zone scavenging models for two-stroke engines. Int J Mech Sci 1992; 34(8): 595–604.

Heywood

Sher

. The two-stroke cycle engine. Warrendale, PA: Society of Automotive Engineers, 1999.

Bajwa

Patterson

Linker

, et al. A new single-zone multi-stage scavenging model for real-time emissions control in two-stroke engines. In: ASME ICEF, Chicago, IL, 20–13 October 2019. New York: ASME.

10.

Sammons

. A single-cycle test apparatus for studying “loop scavenging” in a two-stroke engine. Proc IMechE 1949; 161(1): 233–249.

11.

Boyer

Craig

Miller

. A photographic study of events in a 14-in. two-cycle gas engine cylinder. Trans ASME 1954; 76: 97–108.

12.

Hopkinson

. The charging of two-cycle internal–combustion engines. Journal of the American Society for Naval Engineers 1914; 26(3): 974–985.

13.

Ishihara

Nakashima

. Analysis of scavenging flow in cross-scavenged two-stroke engine. SAE paper 2007-32-0033, 2007.

14.

Ingvorsen

Meyer

Walther

, et al. Turbulent swirling flow in a dynamic model of a uniflow-scavenged two-stroke engine. Exp Fluids 2014; 55(6): 1–8.

15.

Ingvorsen

Meyer

Walther

, et al. Turbulent swirling flow in a model of a uniflow-scavenged two-stroke engine. Exp Fluids 2013; 54(3): 1–7.

16.

Dedeoglu

. Scavenging model solves problems in gas burning engine. SAE Trans 1971; 80: 1930–1941.

17.

Sher

. Investigating the gas exchange process of a two-stroke cycle engine with a flow visualization rig. Isr J Technol 1982; 20: 127–136.

18.

Bopp

Cousyn

Green

, et al. Experimental study of the scavenging and combustion processes in a two-stroke cycle research engine. SAE Trans 1992; 101: 245–260.

19.

Ekenberg

Johansson

. Scavenging flow velocity in small two-strokes at high engine speed. SAE paper 951789, 1995.

20.

Cairns

Sheppard

CGW

. Cyclically resolved simultaneous flame and flow imaging in a SI engine. SAE Trans 2000; 109: 2017–2035.

21.

Fansler

French

Drake

. Individual-cycle measurements of exhaust-hydrocarbon mass from a direct-injection two-stroke engine. SAE Transactions 1998; 107: 946–966. http://www.jstor.org/stable/44736584 (accessed 28 August 2021).

22.

Jante

. Scavenging and other problems of two-stroke cycle spark-ignition engines. SAE Trans 1968; 77: 1803–1824.

23.

Blair

. Studying scavenge flow in a two-stroke cycle engine. In: SAE off-highway and Powerplant Congress and Exposition, SAE Technical Paper, 750752, 1975.

24.

Rizk

. Experimental studies of the mixing processes and flow configurations in two-cycle engine scavenging. Proc IMechE 1958; 172: 417–437.

25.

Tobis

Meyer

Yang

, et al. Scavenging of a firing two-stroke spark-ignition engine. SAE Trans 1994; 103: 535–546.

26.

Asanuma

Yanagihara

. Gas sampling valve for measuring scavenging efficiency in high - speed two - stroke engines. SAE Trans 1962; 70: 420–433.

27.

Kannappan

. A new method for evaluating the scavenging performance of two-stroke diesel engines. SAE paper 640370, 1964.

28.

Nelson

. Determination of two-cycle gasoline engine scavenging efficiency by a gas sampling technique. MS Thesis, University of Wisconsin, Madison1957.

29.

Foudray

Ghandhi

. Scavenging measurements in a direct-injection two-stroke engine. SAE Trans 2003; 112: 2195–2204.

30.

Collings

Regitz

, et al. Experimental investigation of a control method for SI-HCCI-SI transition in a multi-cylinder gasoline engine. SAE Int J Engines 2010; 3: 928–937.

31.

Puzinauskas

Olsen

Willson

. Mass integration of fast-response NO measurements from a two-stroke large-bore natural gas engine. Int J Engine Res 2003; 4(3): 233–248.

32.

Ioannou

Papalambrou

Kyrtatos

, et al. Crank-angle resolved NOx measurements from a specific engine cylinder of a large marine two-stroke engine. J Mar Eng Technol 2014; 13(2): 12–20.

33.

Zhang

Ojapah

Cairns

, et al. 2-stroke CAI combustion operation in a GDI engine with poppet valves. SAE paper 2012-01-1118, 2012.

34.

Zhang

Zhao

. Measurement of short-circuiting and its effect on the controlled autoignition or homogeneous charge compression ignition combustion in a two-stroke poppet valve engine. Proc IMechE, Part D: J Automobile Engineering 2012; 226(8): 1110–1118.

35.

Bajwa

. Improved gas exchange characterization of two-stroke engines to develop robust emissions control systems. PhD Dissertation, Texas A&M University, College Station, 2020.

36.

Heywood

Sher

. The two-stroke cycle engine. Philadelphia, PA: Taylor and Francis, 1999.

37.

Hashimoto

Tottori

Terata

. Scavenging performance measurements of high speed two-stroke engines. SAE Trans 1985; 94: 1069–1076.

38.

Blair

. Design and simulation of two-stroke engines. Warrendale, PA: Society of Automotive Engineers, 1996.

39.

Huber

. Measuring the trapping efficiency of internal combustion engines through continuous exhaust gas analysis. SAE paper 710144, 1971. pp.507–519.

40.

Nuti

Martorano

. Short-circuit ratio evaluation in the scavenging of two-stroke SI engines. SAE paper 850177, 1985.

41.

Bajwa

Mashayekh

Patterson

, et al. Interactions among 3D, 1D and 0D models for natural gas fueled two-stroke SI engines. In: THIESEL, Valencia, Spain, 11–14 September 2018. Universitat Politecnica De Valencia.

42.

Bajwa

Linker

Patterson

, et al. A study of cyclic combustion variations at lean SI engine operation using high-speed in-cylinder CO₂ measurements. In: THIESEL, Valencia, Spain, 8-11 September 2020. Virtual: Universitat Politecnica De Valencia.

43.

Bajwa

Patterson

Jacobs

. Using gas dynamic models to improve exhaust system design for large-bore two-stroke engines. Int J Engine Res 2021; 22: 2622–2638.

44.

Malicke

Patterson

Ashraph

. Applying advanced computer modeling to improve emissions and combustion efficiency in large bore 2 cycle engines. In: Gas machinery conference, Nashville, 3 October 2011. Nashville, Tennessee (USA): Gas Machinery Research Council (GMRC)

45.

Caton

. The thermodynamic characteristics of high efficiency, internal-combustion engines. Energy Convers Manag 2012; 58: 84–93.