This study evaluated the impact of cryoprotection temperature on the structural and biomechanical properties of gamma-irradiated human tendon allografts. Tendons were irradiated at 15 kGy or 25 kGy under three temperature conditions: −70°C, 0°C, or room temperature (RT). Structural integrity was assessed histologically and biochemically, while biomechanical properties were measured via tensile testing. Tendons irradiated at RT exhibited severe collagen disorganization and cellular loss, whereas those cryoprotected at −70°C retained aligned collagen structure with minimal disruption. Biomechanically, the −70°C groups showed significantly higher maximum stress than RT groups at both irradiation doses. Increasing irradiation dose exacerbated structural and mechanical degradation, but these effects were substantially mitigated by cryoprotection at −70°C. Thus, low-temperature protection during gamma irradiation is crucial for preserving the integrity of tendon allografts.
IfranNNMokYRKrishnaL. Tear rates of the ipsilateral ACL graft and the contralateral native ACL are similar following ACL reconstruction. J Knee Surg2022; 35(3): 308–311. https://doi.org/10.1055/s-0040-1713861
2.
PaesslerHHMastrokalosDS. Anterior cruciate ligament reconstruction using semitendinosus and gracilis tendons, bone patellar tendon, or quadriceps tendon-graft with press-fit fixation without hardware. A new and innovative procedure. Orthop Clin N Am2003; 34(1): 49–64. https://doi.org/10.1016/s0030-5898(02)00070-6
3.
CerulliGPlacellaGSebastianiE, et al.ACL reconstruction: choosing the graft. Joints2013; 1(1): 18–24.
4.
ElenesEYHunterSA. Soft-tissue allografts terminally sterilized with an electron beam are biomechanically equivalent to aseptic, nonsterilized tendons. J Bone Joint Surg Am2014; 96(16): 1321–1326. https://doi.org/10.2106/JBJS.L.00841
5.
American Association of Tissue Banks. Standards for Tissue Banking. 10th ed. American Association of Tissue Banks, 2002.
6.
VangsnessCTJGarciaIAMillsCR, et al.Allograft transplantation in the knee: tissue regulation, procurement, processing, and sterilization. Am J Sports Med2003; 31(3): 474–481. https://doi.org/10.1177/03635465030310032701
7.
AkkusOBelaneyRMDasP. Free radical scavenging alleviates the biomechanical impairment of gamma radiation sterilized bone tissue. J Orthop Res2005; 23(4): 838–845. https://doi.org/10.1016/j.orthres.2005.01.007
8.
IAEA. IAEA guidelines for industrial radiation sterilization of disposable medical products (cobalt-60 gamma irradiation)1990.
9.
IAEA. International standards on tissue banking—first meeting of the IAEA technical advisory committee. In: Committee ITA (ed). The IAEA Program in Radiation and Tissue Banking. IAEA, 2002, pp. 44.
10.
FulfordP. Sterilisation of canine anterior cruciate allografts by gamma irradiation in argon. Mechanical and neurohistological properties retained one year after transplantation. J Bone Joint Surg Br1997; 79(5): 705–706. https://doi.org/10.1302/0301-620x.79b5.8196
11.
RihnJAIrrgangJJChhabraA, et al.Does irradiation affect the clinical outcome of patellar tendon allograft ACL reconstruction?Knee Surg Sports Traumatol Arthrosc2006; 14(9): 885–896. https://doi.org/10.1007/s00167-006-0036-7
12.
CampbellDGLiPStephensonAJ, et al.Sterilization of HIV by gamma irradiation. A bone allograft model. Int Orthop1994; 18(3): 172–176. https://doi.org/10.1007/BF00192474
13.
ChenTBaiXBaiL, et al.Diagnosis and treatment of anterior cruciate ligament injuries: consensus of Chinese experts part II: graft selection and clinical outcome evaluation. J Orthop Transl2024; 48: 163–175. https://doi.org/10.1016/j.jot.2024.07.002
14.
ChandlerKMSchickSHargreavesM, et al.Impact of irradiation on load-to-failure in bone-patellar tendon-bone allografts: a systematic review and meta-analysis. J Orthop2023; 46: 18–23. https://doi.org/10.1016/j.jor.2023.10.014
15.
AguilaCMDelcroixGJKaimrajhDN, et al.Effects of gamma irradiation on the biomechanical properties of peroneus tendons. Open Access J Sports Med2016; 7: 123–127. https://doi.org/10.2147/OAJSM.S109156
16.
GutGMarowskaJJastrzebskaA, et al.Structural mechanical properties of radiation-sterilized human bone-tendon-bone grafts preserved by different methods. Cell Tissue Bank2016; 17(2): 277–287. https://doi.org/10.1007/s10561-015-9538-1
17.
WanYLiuDWangX, et al.Temperature-based protection of biochemical and biomechanical characteristics during 25 kGy 60Co irradiation for allograft tendons. BMC Muscoskelet Disord2025; 26(1): 741. https://doi.org/10.1186/s12891-025-09016-w
18.
ZhangHXuMZhaoY, et al.Can the sterilization protocol be improved to enhance the healing of allograft tendons? An in vivo study in rabbit tendons. Clin Orthop Relat Res2024; 482(6): 1074–1086. https://doi.org/10.1097/CORR.0000000000003017
OswaldIRickertMBrüggemannGP, et al.The influence of cryopreservation and quick-freezing on the mechanical properties of tendons. J Biomech2017; 64: 226–230. https://doi.org/10.1016/j.jbiomech.2017.08.018
21.
ZhangHRXuMYZhangL, et al.Effects of chemical sterilization and gamma irradiation on the biochemical and biomechanical properties of human tendon allografts in vitro study. Orthop Surg2022; 14(10): 2657–2668. https://doi.org/10.1111/os.13465
22.
GeXDingJWangM, et al.A novel alginate localization molding technique for cross-sectional area measurement of human tendon to access biomechanical properties. Cell Tissue Bank2021; 22(1): 11–24. https://doi.org/10.1007/s10561-020-09858-9
23.
SuarezLSRichmondJC. Overview of procurement, processing, and sterilization of soft tissue allografts for sports medicine. Sports Med Arthrosc Rev2007; 15(3): 106–113. https://doi.org/10.1097/JSA.0b013e3180dca1fe
SzczesnySEFetchkoKLDodgeGR, et al.Evidence that interfibrillar load transfer in tendon is supported by small diameter fibrils and not extrafibrillar tissue components. J Orthop Res2017; 35(10): 2127–2134. https://doi.org/10.1002/jor.23517
BatoolSRothBJXiaY. Depth-dependent strain model (1D) for anisotropic fibrils in articular cartilage. Materials2024; 17(1): 238. https://doi.org/10.3390/ma17010238
28.
JoukarACreecyAKarnikS, et al.Correlation analysis of cartilage wear with biochemical composition, viscoelastic properties and friction. J Mech Behav Biomed Mater2023; 142: 105827. https://doi.org/10.1016/j.jmbbm.2023.105827
29.
FuJNWangXYangM, et al.Scaffold-based tissue engineering strategies for osteochondral repair. Front Bioeng Biotechnol2022; 9: 812383. https://doi.org/10.3389/fbioe.2021.812383
PremnathVHarrisWHJastyM, et al.Gamma sterilization of UHMWPE articular implants: an analysis of the oxidation problem. Ultra high molecular weight poly ethylene. Biomaterials1996; 17(18): 1741–1753. https://doi.org/10.1016/0142-9612(95)00349-5
32.
HallsN. The microbiology of irradiation sterilization. Med Device Technol1992; 3: 37–45.
KempnerESHaiglerHT. The influence of low temperature on the radiation sensitivity of enzymes. J Biol Chem1982; 257: 13297–13299.
35.
AlexanderPHamiltonL. Irradiation of proteins in the solid state III. Influences of oxygen and absorbed water on changes produced in bovine serum albumin. Radiat Res1961; 15: 193–201.
36.
HuangQInghamERooneyP, et al.Production of a sterilised decellularised tendon allograft for clinical use. Cell Tissue Bank2013; 14(4): 645–654. https://doi.org/10.1007/s10561-013-9366-0
37.
RasmussenTJFederSMButlerDL, et al.The effects of 4 mrad of gamma irradiation on the initial mechanical properties of bone-patellar tendon-bone grafts. Arthroscopy1994; 10(2): 188–197. https://doi.org/10.1016/s0749-8063(05)80092-1
38.
SchwartzHEMatavaMJProchFS, et al.The effect of gamma irradiation on anterior cruciate ligament allograft biomechanical and biochemical properties in the caprine model at time zero and at 6 months after surgery. Am J Sports Med2006; 34(11): 1747–1755. https://doi.org/10.1177/0363546506288851
39.
GentlemanELayANDickersonDA, et al.Mechanical characterization of collagen fibers and scaffolds for tissue engineering. Biomaterials2003; 24(21): 3805–3813. https://doi.org/10.1016/s0142-9612(03)00206-0
40.
OryanAMoshiriAParizi MeimandiA, et al.A long-term in vivo investigation on the effects of xenogenous based, electrospun, collagen implants on the healing of experimentally-induced large tendon defects. J Musculoskelet Neuronal Interact2013; 13(3): 353–367.
41.
MonteiroJCGomesMLTomiossoTC, et al.More resistant tendons obtained from the association of Heteropterys aphrodisiaca and endurance training. BMC Compl Alternative Med2011; 11: 51. https://doi.org/10.1186/1472-6882-11-51
42.
CiteroniMRCiardulliMCRussoV, et al.In vitro innovation of tendon tissue engineering strategies. Int J Mol Sci2020; 21(18): 6726. https://doi.org/10.3390/ijms21186726
SorushanovaADelgadoLMWuZ, et al.The collagen suprafamily: from biosynthesis to advanced biomaterial development. Adv Mater2019; 31(1): e1801651. https://doi.org/10.1002/adma.201801651
45.
Kesava ReddyGEnwemekaCS. A simplified method for the analysis of hydroxyproline in biological tissues. Clin Biochem1996; 29(3): 225–229. https://doi.org/10.1016/0009-9120(96)00003-6
