Design of a reverse osmosis plant for leachate treatment aiming for safe disposal

Abstract

Leachate treatment is one of the major environmental issues faced by landfill owners. One promising method for reduction of pollutant discharge is reverse osmosis (RO). RO technology was tested at a pilot plant at Hedeskoga Landfill in southern Sweden. This landfill receives municipal solid waste (MSW) and industrial, commercial and institutional (IC&I) waste, and produces about 3000 m³/ha of leachate annually.

Annual variations in the volume of leachate produced, estimated from changes in leachate electrical conductivity, were relatively small and should therefore have a minor effect on the main performance parameter of an RO plant, i.e., the achievable volume reduction. The volume reduction (V_permeate/V_feed) of polluted water achieved in batch experiments with 200-1000 litres of raw leachate was more than 80% (4MPa) and the remaining 20% was left as retentate. However, raw leachate caused severe fouling problems in a continuous flow run and after 24 hours, the flux had decreased to about 20% of the initial value. By pre-treating the leachate in a storage pond combined with a wetland, the situation was significantly improved and the decrease in membrane flux was only 0.2% per hour during a 200 hour run. The retention in terms of total solids and chemical oxygen demand was 90%, and for ammonia, it was 82%, at a volume reduction of 50%.

The HELP-model was used for prediction of the water balance for the Hedeskoga landfill, with special focus on estimation of potential evapotranspiration. With different types of vegetation and a volume reduction of 75% in the RO plant, it was found possible to achieve safe disposal by irrigating 25% to 40% of the leachate-producing landfill area with pre-treated leachate.

Pre-treatment with wetlands and nature based systems reduce the need of detergents for cleaning of the membranes and water only can be used. Short pre-treatment by aeration is not sufficient to bring leachate to a condition sustainable for RO-treatment. In that case, it was found necessary with alkaline-acid-alkaline treatment to restore the permeability. The total treatment cost for a full scale treatment plant at Hedeskoga was estimated to be approximately 30 SEK/m³, of which 25 is capital and 5 is operational costs. This can be compared to the total treatment costs for municipal sewage in Sweden, which is 8 SEK/m³.

Keywords

MSW leachate pre-treatment reverse osmosis fouling scaling soil-plant system wmr 507-1

Get full access to this article

View all access options for this article.

References

Baumgarten, G. & Seyfried, C.F. (1996) Experiences and new developments in biological pre-treatment and physical post treatment of landfill leachate, Wat. Sci. Tech. 34 (7-8), pp. 445-453.

Doedens, H. & Theilen, U. (1992) ‘Effluent requirements and related leachate treatment processes in landfilling of waste’: Leachate, Ed: Christensen, Cossu & Stegmann , pp. 417-428, Elsevier Science Publishers Ltd.

Dudley, L.Y. & Darton, E.G. (1996) Membrane autopsy—a case study, Desalination 105 (1-2), pp. 135-141.

Eipper, H. & Maurer, C. (1999) Purification of Landfill Leachate with Membrane Filtration Based on Disc Tube DT, Proceedings Sardinia 99, Seventh International Landfill Symposium, Italy, Oct 1999, pp. 353.

Ettala, M. & Rossi, E. (1995) Leachate treatment with a new evaporation technology, Proceedings Sardinia 95, Fifth International Landfill Symposium, Italy, pp. 583-590

Falk, J., Gottshalk, L., Hellström, T., Hogland, W., Krasovskaia, I. & Niemczynowicz, J. (1983) Hydrologiska undersökningar i Värpinge (Hydrological studies in Värpinge, Sweden), Report 3076, Department of Water Resources Engineering, University of Lund pp. 120 (In Swedish).

Guaiumi, A. & Loschi, R. (1995) Leachate treatment through a combined process of evaporation and thermal oxidation, Proceedings Sardinia 95, Fifth International Landfill Symposium, Italy, pp 575-581.

Hjelmar, O. , Johannessen, L.M. , Knox, K. , Ehrig, H.J. , Flyvbjerg, J. , Winther, P. & Christensen, T.H. (1995) ‘Composition and management of leachate from landfills within the EU’, Proceedings Sardinia 95, Fifth International Landfill Symposium, Italy, pp. 243-262

Hogland, W. (2002) Remediation of an old landfill site - Soil analysis, leachate quality and gas production. In: Selected Papers of the First Baltic Symposium on Environmental Chemistry, Tartu, Estonia, 26-29 September 2001. ESPR - Sci&Pollut. Res. Special Issue 1, (2002): pp. 49-54.

10.

Hogland, W. & Kriipsalu, M. (2003) Excavation of cover material from old landfills. International Symposium in Waste Management & Recycling, 9-11 September 2003, School of Engineering, University of Dundee, UK. pp. 10. (in press).

11.

Hogland, W. , Marques, M. & Nimmermark, S. (2003) Landfill mining and waste characterisation - A strategy for remediation of contaminated areas, Journal of Env. Pollution (in press).

12.

Kettern, J. , Steegmans, R. & Maurer, C. (1995) Optimization and cost reduction in biological-chemical-oxidative landfill treatment, Proceedings Sardinia 95, Fifth International Landfill Symposium, Italy, pp. 559-566.

13.

Knox, K. & Gronow, L. (1995) A pilot scale study of denitrification and contaminant flushing during prolonged leachate recirculation, Proceedings Sardinia 95, Fifth International Landfill Symposium, Italy, pp. 419-436.

14.

Linde, K. (1995) Treatment of landfill leachate with membrane technology, Lic. Thesis, Dept. of Chemical Engineering I, Lund, University, Sweden.

15.

Linde, K. , Jönsson, A-S. & Wimmerstedt, R. (1995) Treatment of three types of landfill leachate, Desalination 101, pp. 21-30.

16.

Marquardt, K. (1989) Anwendung von Membranverfahren zur Sickerwasserbehandlung. Ber. Wasserguetewirtsch. Gesundheitsingenieurwes, 86, pp. 189-230.

17.

Mårtensson, J. & Richardt, F. (1997) Nutidsarkeologisk undersökning å Hedeskoga Avfallsanläggning, Ystad Kommun, Skåne, (Present Times Archeological Study at Hedeskoga Landfill), Lund University, Lund, Sweden, Department of Archaeology; Lund University, Lund Institute of Technology, Lund, Sweden, Department of Water Resources Engineering, Division of Waste Management and Recovery (in Swedish).

18.

Nilsson, P. (2000) Personal communication, VA-Teknik & Vattenvård, Box 8 SE-277 03, Brösarp, Sweden.

19.

Nimmermark, S. , Hogland, W. , Larsson, L. & Bladh, H. (1998) Utgrävningar vid deponierna Måsalycke och Gladsaxe - Landfill mining och nutidsarkeologi (Excavation at Måsalycke and Gladsaxe Landfills - Landfill Modern Archaelogy). Report No 107. Department of Technology, University of Kalmar, Sweden, 88 pp.

20.

Persson, G. (1995) Willow Stand Evapotranspiration Simulated for Swedish Soils, Agricultural Water Management 28, pp. 271.

21.

Peters, T. (1999) Past and Future of Membrane Filtration for the Purification of Landfill Leachate Proceedings Sardinia 99, Seventh International Landfill Symposium, Italy, Oct 1999, pp. 335-344.

22.

Rudolph, K.-U. & Köppke, K.-E. (1989) Behandlung von Sickerwasser aus Abfalldeponien, Müll und Abfall. 21, pp. 6.

23.

RVF 2002, Förslag till ramprogram för lakvattenrening, Rapport nr 4 2002, The Swedish Association of Waste Management Service AB.

24.

SIS, Swedish Standards Institute, Box 3295, 103 66 Stockholm, Sweden.

25.

Scrudato, R.J , Pagano, J.J. , Lane, M.A. & Hansen, D.L. (1993) Leachate recirculation in normally placed and stabilised refuse, Sardinia 93, Fourth International Landfill Symposium, Italy, Oct 1993.

26.

Schroeder, P.R. , Dozier, T.S. , Zappi, P.A. , McEnroe, B.M. , Sjostrom, J.W. & Peyton, R.L. (1994) The Hydrologic Evaluation of Landfill Performance (HELP) Model: Engineering Documentation for Version 3, EPA/600/R-94/168b, September 1994, U.S. Environmental Protection Agency Office of Research and Development, Washington, DC.

27.

York, R.J. , Thiel, R.S. & Beaudry, E.G. (1999) Full-Scale Experience of Direct Osmosis Concentration Applied to Leachate Management, Proceedings Sardinia 99, Seventh International Landfill Symposium, Italy, Oct 1999, pp. 359.