Force induced piezoelectric effect of polyvinylidene fluoride and polyvinylidene fluoride-co-trifluoroethylene nanofibrous scaffolds

Abstract

Polyvinylidene fluoride and its co-polymer with trifluoroethylene are promising biomaterials for supporting nerve regeneration processes because of their proven biocompatibility and piezoelectric properties that could stimulate cell ingrowth due to electrical activity upon mechanical deformation. This study reports the piezoelectric effect of electrospun polyvinylidene fluoride scaffolds in response to mechanical loading. An impact test machine was used to evaluate the generation of electrical voltage upon application of an impact load. Scaffolds were produced via electrospinning from polyvinylidene fluoride and polyvinylidene fluoride-co-trifluoroethylene with concentrations of 10–20 wt% dissolved in N,N-dimethylformamide (DMF) and acetone (6:4). The structural and thermal properties of scaffolds were analyzed using Fourier Transform Infrared Spectroscopy and Differential Scanning Calorimetry, respectively. The piezoelectric response of the scaffolds was induced using a custom-made manual impact press machine. Impact forces between 0.4 and 14 N were applied. Fourier Transform Infrared Spectroscopy and Differential Scanning Calorimetry results demonstrated the piezoelectric effect of the electrospun polyvinylidene fluoride and polyvinylidene fluoride-co-trifluoroethylene scaffolds. All the scaffolds exhibited a piezoelectric polar beta-phase formation. Their thermal enthalpies were higher than the value of the initial materials and exhibited a better tendency of crystallization. The electrospun scaffolds exhibited piezoelectric responses in form of voltage by applying impact load. Polyvinylidene fluoride-co-trifluoroethylene scaffolds showed higher values in the range of 6–30 V as compared to pure polyvinylidene fluoride. Here, the mechanically induced electrical impulses measured were between 2.5 and 8 V. Increasing the impact forces did not increase the piezoelectric effect. The results demonstrate the possibility of producing electrospun polyvinylidene fluoride and polyvinylidene fluoride-co-trifluoroethylene scaffolds as nerve guidance with piezoelectric response. Further experiments must be carried out to analyze the piezoelectricity at dynamic conditions.

Keywords

Polyvinylidene fluoride polyvinylidene fluoride-co-trifluoroethylene electrospinning fiber mats piezoelectric module impact press machine

Get full access to this article

View all access options for this article.

References

Yegiyants

Dayicioglu

Kardashian

et al . Traumatic peripheral nerve injury: a wartime review. J Craniofac Surg 2010; 21: 998–1001.

Grinsell

Keating

. Peripheral nerve reconstruction after injury: a review of clinical and experimental therapies. Biomed Res Int 2014; 2014: 698256.

Steiger

H-J

Millesi

Schmidhammer

. How to improve the results of peripheral nerve surgery. Vienna: Springer, 2007.

Sanapanich

Morrison

Messina

. Physiologic and morphologic aspects of nerve regeneration after end-to-end or end-to-side coaptation in a rat model of brachial plexus injury. J Hand Surg 2002; 27: 133–142.

Lin

Manzano

Gupta

. Nerve allografts and conduits in peripheral nerve repair. Hand Clin 2013; 29: 331–348.

Gonzalez-Perez

Cobianchi

Geuna

et al . Tubulization with chitosan guides for the repair of long gap peripheral nerve injury in the rat. Microsurgery 2015; 35: 300–308.

Sicari

Dearth

Badylak

. Tissue engineering and regenerative medicine approaches to enhance the functional response to skeletal muscle injury. Anat Rec 2014; 297: 51–64.

Guo

Lei

et al . Functionalized scaffolds to enhance tissue regeneration. Regen Biomater 2015; 2: 47–57.

Kawai

. The piezoelectricity of poly (vinylidene fluoride). Jpn J Appl Phys 1969; 8: 975.

10.

Al Halabi

Freund

Repanas

et al . Effect of different solvents on morphology and properties of piezoelectric PVDF scaffolds for nerve regeneration. Biomed Tech 2015; 60: S7.

11.

Artmann

Zhubanova

et al . Biological, physical and technical basics of cell engineering. Singapore: Springer, 2018.

12.

Batra

Alomari

Chilvery

et al . Piezoelectric power harvesting devices: an overview. Adv Sci Eng Med 2016; 8: 12.

13.

Zhang

Lin

et al . Nanocomposite membranes enhance bone regeneration through restoring physiological electric microenvironment. ACS Nano 2016; 10: 7279–7286.

14.

Liu

Hashim

Liu

et al . Progress in the production and modification of PVDF membranes. J Memb Sci 2011; 375: 1–27.

15.

Batra

Edwards

Guggilla

et al . Pyroelectric properties of PVDF: MWCNT nanocomposite film for uncooled infrared detectors and medical applications. Int Ferroelect 2014; 158: 98–107.

16.

Lee

Y-S

Arinzeh

et al . Enhanced noradrenergic axon regeneration into Schwann cell-filled PVDF-TrFE conduits after complete spinal cord transection. Biotech Bioeng 2017; 114: 444–456.

17.

Ribeiro

Sencadas

Correia

et al . Piezoelectric polymers as biomaterials for tissue engineering applications. Colloid Surfaces B 2015; 136: 46–55.

18.

Tofail

SAM

Bauer

. Electrically active materials for medical devices. Singapore: World Scientific, 2016.

19.

Ramakrishna

. An introduction to electrospinning and nanofibers. Singapore: World Scientific, 2005.

20.

Glasmacher

Gryshkov

Halabi

FAL

et al . (eds). Layer by layer: designing scaffolds for cardiovascular tissues. London: Springer, 2014.

21.

Szentivanyi

Chakradeo

Zernetsch

et al . Electrospun cellular microenvironments: understanding controlled release and scaffold structure. Adv Drug Deliv Rev 2011; 63: 209–220.

22.

Wendorff

Agarwal

Greiner

. Electrospinning: materials, processing, and applications. Hoboken, NJ: John Wiley & Sons, 2012.

23.

Erturk

Inman

. Piezoelectric energy harvesting. Hoboken, NJ: John Wiley & Sons, 2011.

24.

Fialka

Benes

. Comparison of methods for the measurement of piezoelectric coefficients. IEEE T Instrum Meas 2013; 62: 1047–1057.

25.

Guo

Cao

Shen

. Measurements of piezoelectric coefficient d33 of lead zirconate titanate thin films using a mini force hammer. J Vib Acoust 2013; 135: 11003.

26.

Chen

Panda

(eds). Commercialization of piezoelectric single crystals for medical imaging applications. New York: IEEE, 2005.

27.

Zhou

Gottlieb

et al . PMN-PT single crystal, high-frequency ultrasonic needle transducers for pulsed-wave Doppler application. IEEE T Ultrason Ferr 2007; 54: 668–675.

28.

Zhao

Yuan

et al . Preparation and properties of electrospun poly (vinylidene fluoride) membranes. J Appl Poly Sci 2005; 97: 466–474.

29.

Mao

Gnade

Quevedo-Lopez

. Ferroelectric properties and polarization switching kinetic of poly (vinylidene fluoride-trifluoroethylene) copolymer. London: IntechOpen, 2011.

30.

Chou

. Polymorphism, piezoelectricity and sound absorption of electrospun PVDF membranes with and without carbon nanotubes. Compos Sci Technol 2016; 127: 127–133.

31.

Xue

Jing

et al . Fabrication of electrospun PVDF nanofibers with higher content of polar β phase and smaller diameter by adding a small amount of dioctadecyl dimethyl ammonium chloride. Chinese J Polym Sci 2017; 35: 992–1000.

32.

Laroche

Marois

Guidoin

et al . Polyvinylidene fluoride (PVDF) as a biomaterial: from polymeric raw material to monofilament vascular suture. J Biomed Mater Res A 1995; 29: 1525–1536.

33.

Zheng

et al . Polymorphism control of poly(vinylidene fluoride) through electrospinning. Macromol Rapid Comm 2008; 28; 2159–2162.

34.

Costa

LMM

Bretas

RES

Gregorio

Effect of solution concentration on the electrospray/electrospinning transition and on the crystalline phase of PVDF. Mater Sci Appl 2010; 1: 247.

35.

Cozza

Monticelli

Marsano

et al . On the electrospinning of PVDF: influence of the experimental conditions on the nanofiber properties. Polymer Int 2013; 62: 41–48.

36.

Sencadas

Lanceros-Méndez

Mano

. Characterization of poled and non-poled β-PVDF films using thermal analysis techniques. Thermochim Acta 2004; 424: 201–207.

37.

Guo

H-F

Z-S

Dong

S-W

et al . Piezoelectric PU/PVDF electrospun scaffolds for wound healing applications. Colloid Surface B 2012; 96: 29–36.

38.

Baniasadi

Moreno

et al . Effect of thermomechanical post-processing on chain orientation and crystallinity of electrospun P (VDF-TrFE) nanofibers. Polymer 2017; 118: 223–235.

39.

Gopi

Balakrishnan

Pius

et al . Chitin nanowhisker (ChNW)-functionalized electrospun PVDF membrane for enhanced removal of Indigo carmine. Carbohyd Polym 2017; 165: 115–122.

40.

Beringer

Shih

et al . An electrospun PVDF-TrFe fiber sensor platform for biological applications. Sensor Actuat A 2015; 222: 293–300.

41.

Chen

H-J

Han

Liu

et al . Investigation of PVDF-TrFE composite with nanofillers for sensitivity improvement. Sensor Actuat A 2016; 245: 135–139.

42.

Chang

W-Y

Hsu

C-H

. Electromechanical characteristics of Polyvinylidene Fluoride for flexible electronics. T Can Soc Mech Eng 2013; 37: 325–333.

43.

González

Sorichetti

Santiago

. Reducing the capacitance of piezoelectric film sensors. Rev Sci Instrum 2016; 87: 45003.

44.

Whitaker

. The electronics handbook. 2. ed. Boca Raton, FL: Taylor & Francis, 2005.

45.

Schrüfer

Reindl

Zagar

. Elektrische Messtechnik: Messung elektrischer und nichtelektrischer Größen. Munich: Carl Hanser Verlag, 2014.

46.

Zhang

Guan

et al . Wearable piezoelectric device assembled by one-step continuous electrospinning. J Mater Chem C 2016; 4: 6988–6995.