Improving Heat Transfer Models of Air Gaps in Bench Top Tests of Thermal Protective Fabrics

Abstract

An improved model has been developed to simulate heat transfer in horizontal air spaces between thermal protective fabrics and test sensors in bench top tests, such as the thermal protective performance test. This model calculates the radiation and convection heat transfer from the test specimen to the test sensor. Radiation heat transfer is calculated by treating the bottom boundary of the enclosure as a series of isothermal rectangular pieces. Convection heat transfer is calculated using an empirical correlation and by assuming that convection only occurs over a portion of the cross-section of the enclosure. Predicted times required to exceed the Stoll second degree burn criterion were found to be within 3 % of those measured during actual bench top tests of steel shimstock using air gaps from 6.4 mm (1/4 in.) to 19.1 mm (3/4 in.).

Keywords

heat transfer materials measurement performance

Get full access to this article

View all access options for this article.

References

American Society for Testing and Materials, ASTM F 1930-00 Standard Test Method for Evaluation of Flame Resistant Clothing for Protection Against Flash Fire Simulations Using an Instrumented Thermal Manikin, West Conshohocken, Pennsylvania, USA (2000).

International Organization for Standardization, ISO 9151 Protective Clothing Against Heat and Flame - Determination of Heat Transmission on Exposure to Flame, Geneva, Switzerland (1995).

American Society for Testing and Materials, ASTM D 4108-87 Standard Test Method for Thermal Protective Performance of Materials and Clothing by Open-flame Method, West Conshohocken, Pennsylvania, USA (1987).

Stoll, A.M. , and Chianta, M.A. , Method and Rating System for Evaluation of Thermal Protection, Aerosp. Med. 40, 1232- 1238 (1969).

American Society for Testing and Materials, ASTM F 1939-99a Standard Test Method for Radiant Protective Performance of Flame Resistant Clothing Materials, West Conshohocken, Pennsylvania, USA (1999).

National Fire Protection Association, NFPA 1971: Standard on Protective Ensemble for Structural Fire Fighting, Quincy, Massachusetts, USA (2007).

Torvi, D.A. , and Dale, J.D. , Heat Transfer in Thin Fibrous Materials Under High Heat Flux, Fire Technol. 35, 210-231 (1999).

Torvi, D.A. , and Threlfall, T.G. , Heat Transfer Model of Flame Resistant Fabrics During Cooling After Exposure to Fire, Fire Technol. 42, 27-48 (2006).

Torvi, D.A. , Heat Transfer in Thin Fibrous Materials Under High Heat Flux Conditions, PhD Dissertation, University of Alberta, Edmonton, Alberta, Canada (1997).

10.

Lewis, B. , and von Elbe, G. , "Combustion, Flames and Explosions of Gases," 3rd Edn., Academic Press, Orlando, Florida, USA (1987).

11.

Zhu, F.L. , and Zhang, W.Y. , Evaluation of Thermal Performance of Flame-resistant Fabrics Considering Thermal Wave Influence in Human Skin Model, J. Fire Sci. 24, 465-485 (2006).

12.

Song, G. , Modeling Thermal Protection Outfits for Fire Exposures, PhD Dissertation, North Carolina State University, Raleigh, North Carolina , USA (2002).

13.

Chitrphiromsri, P. , Modeling of Thermal Performance of Firefighter Protective Clothing During the Intense Heat Exposure, PhD Dissertation, North Carolina State University, Raleigh, North Carolina , USA (2004).

14.

Torvi, D.A. , and Dale, J.D. , Effects of Variations in Thermal Properties on the Performance of Flame Resistant Fabrics for Flash Fires, Textile Res. J. 68, 787-796 (1998).

15.

Sawcyn, C.M.J. , Heat Transfer Model of Horizontal Air Gaps in Bench Top Testing of Thermal Protective Fabrics, MSc Thesis, University of Saskatchewan, Saskatoon, Saskatchewan , Canada (2003).

16.

Sawcyn, C.M.J. , and Torvi, D.A. , Flow Visualization in Air Spaces Between Protective Fabrics and Sensors in Protective Clothing Tests, in " Progress in Transport Phenomena, Proceedings of the 13 th International Symposium on Transport Phenomena," Elsevier, Paris, France, pp. 197-202 (2002).

17.

Jakob, M. , "Heat Transfer," Volume II, Wiley, New York, USA, p. 11 (1957).

18.

Hollands, K.G.T. , Raithby, G.D. , and Konicek, L. , Correlation Equation for Free Convection Heat Transfer in Horizontal Layers of Air and Water, Int. J. Heat Mass Transf. 18, 879- 884 (1975).