A range of wool knit fabrics designed to be used in garments worn next to or near the skin was examined to establish if differences in responses to water vapor and to water were detectable. The three-block experimental design involved six fabrics (non-dyed), and fabric responses on the dynamic sweating hotplate and on the gravimetric absorbency testing system (GATS) were determined. Some differences among the fabrics were detectable (e.g. %RH at the initial rise and at equilibrium, %RH rate of rise, temperature differences in the initial phase and at equilibrium, specific maximum absorbent capacity, flow rate) but many were not. For this set of wool knit fabrics, mass and thickness were typically linked to the temperature variables from the dynamic sweating hotplate, and bulk density linked to a few variables from the GATS.
Havenith, G., MoistureAccumulation in Sleeping Bags at Sub-Zero Temperatures — Effect of Semipermeable and Impermeable Covers, Textile Res. J.72(4), 281—284 (2002).
2.
Rossi, R.E., Gross, R., and May, H., WaterVapor Transfer and Condensation Effects in Multilayer Textile Combinations, Textile Res. J.74(1), 1—6 (2004).
3.
Zhuang, Q., Harlock, S.C., and Brook, D.B., TransferWicking Mechanisms of Knitted Fabrics Used as Undergarments for Outdoor Activities, Textile Res. J.72(8), 727—734 (2002).
4.
Fan, J., and Cheng, X.-Y., Heat and Moisture Transfer with Sorption and Phase Change through Clothing Assemblies Part I: Experimental Investigation, Textile Res. J.75(2), 99—105 (2005 ).
5.
Fan, J., and Cheng, X.-Y., Heat and Moisture Transfer with Sorption and Phase Change through Clothing Assemblies Part II: Theoretical Modelling, Simulation, and Comparison with Experimental Results, Textile Res. J. 75(3), 187—196 (2005).
6.
Fukazawa, T. , Kawamura, H., and Tamura, T., WaterVapour Transfer through Microporous Membranes and Polyester Textiles at Combinations of Temperature and Pressure That Simulate Elevated Altitudes, J. Textile Inst.91 (Part1)(3), 434—447 (2000).
7.
Li, Y., Zhu, Q., and Yeung, K.W., Influence of Thickness and Porosity on Coupled Heat and Liquid Moisture Transfer in Porous Textiles, Textile Res. J.72(5), 435—446 (2002).
8.
Long, H.-R., Water TransferProperties of Two-Layer Weft Knitted Fabric, Intl J. ClothingSci. Technol.11(4), 198—205 (1999).
9.
Prahsarn, C. , Barker, R.L., and Gupta, B.S., MoistureVapor Transport Behavior of Polyester Knit Fabrics, Textile Res. J.75(4), 346—351 ( 2005).
10.
Li, Y., Holcombe, B.V., and Apcar, F., MoistureBuffering Behavior of Hygroscopic Fabric During Wear, Textile Res. J.62(11), 619—627 (1992).
11.
Prahsarn, C., “ Factors Influencing Liquid and Moisture Transport in Knit Fabrics, Fiber and Polymer Science,” Unpublished doctoral thesis, North Carolina State University, Raleigh, 2001.
12.
Holmes, D.A. , PerformanceCharacteristics of Waterproof Breathable Fabrics, J. Indust. Textiles29(4), 306—316 ( 2000).
13.
Hu, J., Li, Y., Yeung, K.-W., Wong, A.S.W., and Xu, W., MoistureManagement Tester: A Method to Characterize Fabric Liquid Moisture Management Properties, Textile Res. J.75(1), 57—62 (2005).
14.
Kim, J.O., and Spivak, S.M., Dynamic Moisture Vapor Transfer through Textiles, Textile Res. J.64(2), 112—121 ( 1994).
15.
Bakkevig, M.K. , and Nielsen, R., The Impact of Activity Level on Sweat Accumulation and Thermal Comfort Using Different Underwear, Ergonomics38(5), 926—939 ( 1995).
16.
Holmer, I., Heat Exchange and ThermalInsulation Compared in Woolen and Nylon Garments During Wear Trials, Textile Res. J.55(9), 511—518 (1985).
17.
Fukazawa, T. , Kawamura, H., Tochihara, Y., and Tamura, T., Experiment and Analysis of Combined Heat and Water Vapor Transfer through Clothes with Condensation, Textile Res. J.73(9), 774—780 (2003).
18.
Chen, P.-L., “ Heat and Moisture Transfer Properties of MultiLayer Fabrics Assemblies, Fiber and Polymer Science,” Unpublished doctoral thesis, North Carolina State University, Raleigh, 1994.
19.
Yoo, S., and Barker, R.L., MoistureManagement Properties of Heat Resistant Workwear Fabrics — Effects of Hydrophilic and Hydroscopic Fiber Blends, Textile Res. J.74(11), 995—1000 (2004).
20.
American Society for Testing and Materials , “ASTM D 1776-04 Standard Practice for Conditioning and Testing Textiles,” American Society for Testing and Materials, West Conshohocken, PA, 2004.
21.
Microsoft Corporation, “ Microsoft(R) Visual Basic 6.0 in Microsoft(R) Excel 2000,” Microsoft Corporation, Redmond, WA, 2000.
Harraway, J., “ Introductory Statistical Methods”, University of Otago Press, Dunedin, NZ, 1993.
24.
Brown, M.B. , and Forsythe, A.B., The Small Sample Behaviour of Some Statistics Which Test the Equality of Several Means, Technometrics16(1), 129—132 (1974).
25.
Tamhane, A.C. , A Comparison of Procedures for Multiple Comparisons of Means with Unequal Variances, J. Am. Stat. Assoc.74, 471—480 (1979).
26.
British Standards Institution, “ BS EN ISO 9073-6:2003 Textiles — Test Methods for Nonwovens — Part 6: Absorption,” British Standards Institution , London, UK, 2003.
