Effects of surface wettability of silicon-incorporated diamond-like carbon films on barnacle larval settlement

Abstract

The colonization of barnacles on surfaces has detrimental effects on shipping, leisure vessels, heat exchangers, oceanographic sensors, and aquaculture systems. One strategy for avoiding barnacle colonization on surfaces is to utilize surface wettability. Silicone-incorporated diamond-like carbon (Si-DLC) has high hardness and a low friction coefficient, and an increase in the incorporation of Si leads to hydrophobicity. By contrast, oxygen plasma treatment produces hydrophilicity in Si-DLC films. The improved surface wettability of Si-DLC may reduce barnacle colonization. However, few studies have been conducted on barnacle larval settlement in relation to Si-DLC films.

The aim of this study is to evaluate barnacle larval settlement on Si-DLC films and on oxygen-plasma-treated Si-DLC films.

Si-DLC films were prepared by radio-frequency plasma-enhanced chemical vapor deposition and treated with oxygen plasma. The films were characterized using Raman spectroscopy and X-ray photoelectron spectroscopy. Contact angles of the films were measured to evaluate their hydrophobicity. Barnacle cyprid larva settlement was observed on the Si-DLC and oxygen-plasma-treated Si-DLC films.

The contact angle of the Si-DLC-0% film was $69.9 \pm 3 . 3^{\circ}$ and increased with Si incorporation. Following oxygen plasma treatment, the contact angle of the Si-DLC-0% films decreased to $10.9 \pm 4 . 4^{\circ}$ and gradually increased with Si incorporation. The barnacle cyprid larval settlement ratio for the non-coated stainless plate was 36.4%, whereas that of the DLC films was 15.0%, which decreased with Si incorporation. Following oxygen plasma treatment, the ratio of barnacle cyprid larval settlement in Si-DLC films was lower than for the Si-DLC films.

The Si-DLC film was effective in avoiding barnacle adhesion, whereas the oxygen-plasma-treated Si-DLC was even more effective. This study demonstrated the feasibility of Si-DLC for antifouling against barnacles.

Keywords

Barnacles oxygen plasma silicon-incorporated diamond-like carbon contact angle surface wettability

Get full access to this article

View all access options for this article.

References

J.A.

Calllow and

M.E.

Callow, Trends in the development of environmentally friendry fouling-resistant marine coatings, Nat. Commun. 2 (2011), 244. doi:10.1038/ncomms1251.

Dahlström,

Jonsson,

P.R.

Jonsson and

Elwing, Surface wettability as a determinant in the settlement of the barnacle Balanus improvises, J. Exp. Mar. Biol. Ecol. 305 (2004), 223. doi:10.1016/j.jembe.2003.12.013.

J.C.

Damasceno ,

S.S.

Camargo Jr. ,

F.L.

Freire Jr. and

Carius , Deposition of Si-DLC films with high hardness, low stress and high deposition rates, Surf. Coat. Technol. 133(134) (2000), 247. doi:10.1016/S0257-8972(00)00932-4.

Dearnaley and

J.H.

Arps, Biomedical applications of diamond-like carbon (DLC) coatings: A review, Surf Coat Technol 200 (2005), 2518. doi:10.1016/j.surfcoat.2005.07.077.

Garg,

Hurren and

Kaynak, Improvement of adhesion of conductive polypyrene coating on wool and polyester fabrics using atmospheric plasma treatment, Synth. Met. 157 (2007), 41. doi:10.1016/j.synthmet.2006.12.004.

Grischke,

Hieke,

Morgenweck and

Dimigen, Variation of the wettability of DLC-coatings by network modification using silicon and oxygen, Diam. Relat. Mater. 7 (1998), 454. doi:10.1016/S0925-9635(97)00237-9.

G.F.

Huang,

Lingping,

Weiqing,

Lihua,

Shaolu and

Deyi, The mechanical performance and anti-corrosion behavior of diamond-like carbon film, Diam Relat Mater. 12 (2003), 1406–1410. doi:10.1016/S0925-9635(03)00168-7.

Kamino, Mini-review: Arnacle adhesives and adhesion, Biofouling 6 (2013), 735. doi:10.1080/08927014.2013.800863.

K.Y.

Law, Definition for hydrophilicity, hydrophobicity and superhydrophobicity: Getting the basic right, J. Phys. Chem. Lett. 5 (2014), 686. doi:10.1021/jz402762h.

10.

K.Y.

Law and

Zhao, Surface Wetting: Characterization, Contact Angle, and Fundamentals, Springer, 2015.

11.

Liang,

Strickland,

Ye,

Wu,

Hu and

Rittchof, Biochemistry of barnacle adhesion: An updated review, Front. Mar. Sci. 6 (2019), 565. doi:10.3389/fmars.2019.00565.

12.

Meneve,

Dekempeneer and

Smeets, a-Si_1-xC_x: H films and their possibilities and limitations tribological applications, Diamond Films Technol. 4 (1994), 23.

13.

Momose,

Murosaki,

Nogata,

Onodera,

Azuma,

Shimomura and

Hirai, Verifications of the antifouling effect of the cross-linked PVA coating, Sessile Organisms 37 (2020) (1). doi:10.4282/sosj.37.1.

14.

Movahed,

A.K.

Nguyen,

P.L.

Coering,

S.A.

Skoog and

Narayan, Argon and oxygen plasma treatment increases hydrophilicity and reduces adhesion of silicon-incorporated diamond-like coatings, Biointerpahses 15 (2020), 041007. doi:10.1116/6.0000356.

15.

Papakonstantinou,

J.F.

Zhao,

Lemoine,

E.T.

McAdams and

J.A.

McLaughlin, The effects of Si incorporation on the electrochemical and nanomechanical properties of DLC thin films, Diam. Relat. Mater. 11 (2002), 1074. doi:10.1016/S0925-9635(01)00656-2.

16.

Pinori,

Berglin,

L.M.

Brive,

Hulander,

Dahlström and

Elwing, Multi-seasonal barnacle (Balanus improvises) protection achieved by trace amount of a macrocyclic lactone (icermectin) included in rosin-based coatings, Biofouling 27 (2011), 941. doi:10.1080/08927014.2011.616636.

17.

Rittschof,

R.B.

ForwardJr.,

Cannon,

J.M.

WelchJr.,

McClary,

E.R.

Holm,

A.S.

Clare,

Conova,

L.M.

McKelvey,

Bryan and

C.L.

van Dover, Cues and context: Larval responses to physical and chemical cues, Biofouling 12 (1998), 35.

18.

Roberts,

Rittschof,

Holm and

A.R.

Schmidt, Factors influencing initial larval settlement: Temporal, spatial and surface molecular components, J. Exp. Mar. Biol. Ecol. 150 (1991), 203. doi:10.1016/0022-0981(91)90068-8.

19.

C.G.

Satuito,

Shimizu and

Fusetani, Studies on the factors influencing larval settlement in Balanus amphitrite and Mytilus galloprovincialis, Hydrobiologia 358 (1997), 275. doi:10.1023/A:1003109625166.

20.

Tomasella,

Thomas,

Dubois and

Meunier, Structural and mechanical properties of a-C:H thin films grown by RF-PECVD, Diam. Relat. Mater. 13 (2004), 1618. doi:10.1016/j.diamond.2004.01.017.

21.

D.M.

Yebra,

Kiil and

K.D.

Johansen, Antifouling technology – past, present and future steps toward efficient and environmentally friendly antifouling coatings, Prog. Org. Coat. 50 (2004), 75. doi:10.1016/j.porgcoat.2003.06.001.