Successful Application of Ground-Penetrating Radar for Quality Assurance-Quality Control of New Pavements

Abstract

The successful application of ground-penetrating radar (GPR) as a quality assurance–quality control tool to measure the layer thicknesses of newly built pavement systems is described. A study was conducted on a newly built test section of Route 288 located near Richmond, Virginia. The test section is a three-lane, 370-m-long flexible pavement system composed of a granular base layer and three different hot-mix asphalt (HMA) lifts. GPR surveys were conducted on each lift of the HMA layers after they were constructed. To estimate the layer thicknesses, GPR data were analyzed by using simplified equations in the time domain. The accuracies of the GPR system results were checked by comparing the thicknesses predicted with the GPR to the thicknesses measured directly from a large number of cores taken from the different HMA lifts. This comparison revealed a mean thickness error of 2.9% for HMA layers ranging in thickness from 100 mm (4 in.) to 250 mm (10 in.). This error is similar to the one obtained from the direct measurement of core thickness.

Get full access to this article

View all access options for this article.

References

Lahouar

, Al-Qadi

I. L.

, Loulizi

, Clark

T. M.

, and Lee

D. T.

. Approach to Determining In-Situ Dielectric Constant of Pavements: Development and Implementation at Interstate 81 in Virginia. In Transportation Research Record: Journal of the Transportation Research Board, No. 1806, TRB, National Research Council, Washington, D.C., 2002, pp. 81–87.

Maser

K. R.

Measurement of As-Built Conditions Using Ground Penetrating Radar. In Structural Materials Technology: An NDT Conference ( Hartbrower

P. E.

and Stolarski

P. J.

, eds.), San Diego, Calif., Feb. 1996, pp. 61–67.

Rmeili

, and Scullion

. Detecting Stripping in Asphalt Concrete Layers Using Ground Penetrating Radar. In Transportation Research Record 1568, TRB, National Research Council, Washington, D.C., 1997, pp. 165–174.

Al-Qadi

I. L.

Using Microwave Measurements to Detect Moisture in Hot-Mix Asphalt. Journal of Testing and Evaluation, Vol. 20, No. 1, 1992, pp. 45–50.

Al-Qadi

I. L.

, and Loulizi

. Using GPR to Evaluate the Effectiveness of Moisture Barriers in Pavements. In Structural Faults and Repair 99, 8th International Conference ( Forde

M. C.

, ed.), Engineering Technics Press, Edinburgh, United Kingdom, June 1999.

Loulizi

, Al-Qadi

I. L.

, Bhutta

S. A.

, and Flintsch

G. W.

. Evaluation of Geosynthetics Used as Separators. In Transportation Research Record: Journal of the Transportation Research Board, No. 1687, TRB, National Research Council, Washington, D.C., 1999, pp. 104–111.

Sheftick

D. E.

, and Bartoski

T. A.

. Study of Void Detection Methods and Slab Stabilization Procedures. Research Project 86-102. Bureau of Construction and Materials, Pennsylvania Department of Transportation, 1997.

Halabe

U. B.

, Chen

H. L.

, Bhandarkar

, and Sami

. Detection of Sub-Surface Anomalies in Concrete Bridge Decks Using Ground Penetrating Radar. ACI Materials Journal, Vol. 94, No. 5, Sept.–Oct. 1997, pp. 396–408.

APAC-Virginia, Inc. Route288.com (VA 288). Jan. 2001. http://www.route288.com. Accessed July 17, 2002.