Long-Term Oven-Aging Effects on Fatigue and Initial Stiffness of Asphalt Concrete

Abstract

An investigation of the effects of long-term oven aging (LTOA) on initial stiffness and fatigue of asphalt concrete was made using two typical California asphalts, known to have different aging characteristics, in mixes with one aggregate. Asphalt content, air-voids content, and days of LTOA were varied independently. Stiffness and fatigue were evaluated using the controlled-strain flexural beam test developed by the Strategic Highway Research Program Project A-003A. The results indicated that both mixes exhibited an increase in initial stiffness with LTOA periods of up to six days. The sensitivity of beam fatigue life to LTOA depended on the asphalt. Beams containing Valley asphalt had virtually no change in fatigue life due to LTOA, whereas beams with Coastal asphalt showed some sensitivity to LTOA. For both asphalts, the average reduction in fatigue life from 6 days of LTOA was less than that caused by a 3 percent increase in air-void content or a 1 percent decrease in asphalt content. Simulations of thick and thin pavement structures were performed to reconcile the effects of LTOA, asphalt content, and air-void content on mix fatigue life and stiffness by evaluating their combined effects on predicted pavement fatigue life. The simulations indicated that aging, as induced by LTOA, increased fatigue life for all cases except one.

Get full access to this article

View all access options for this article.

References

Tayebali

, Deacon

, Coplantz

, Finn

, and Monismith

. Fatigue Response of Asphalt-Aggregate Mixes. Report SHRP-A-404, Strategic Highway Research Program, National Research Council, Washington, D.C., 1994.

Bell

, Wieder

, and Fellin

. Laboratory Aging of Asphalt-Aggregate Mixtures: Field Validation. SHRP-A-390, Strategic Highway Research Program Report, National Research Council, Washington, D.C., 1994.

Harvey

, Deacon

, Tsai

B.-W.

, and Monismith

. Fatigue Performance of Asphalt Concrete Mixes and its Relationship to Asphalt Concrete Pavement Performance in California. Report for the California Department of Transportation, Institute of Transportation Studies, University of California, Berkeley, Jan., 1996.

Vallerga

, Finn

, and Hicks

. Effect of Asphalt Aging on the Fatigue Properties of Asphalt Concrete. Proc., 3rd International Conference on Asphalt Pavements, Ann Arbor, Mich., 1972, pp. 595–617.

Bell

, and Sosnovske

. Aging: Binder Validation. Report SHRP-A-384, Strategic Highway Research Program, National Research Council, Washington, D.C., 1994.

Tayebali

, Deacon

, Coplantz

, Harvey

, and Monismith

. Mixture and Mode of Loading Effects on Fatigue Response of Asphalt-Aggregate Mixtures. Asphalt Paving Technology 1994, Journal of the Association of Asphalt Paving Technologists, Vol. 63, pp. 118–151.

Standard Specifications. California Department of Transportation, Sacramento, Calif., 1994.

Harvey

, Mills

, Scheffy

, Sousa

, and Monismith

. An Evaluation of Several Asphalt Concrete Specimen Air-Void Content Measurement Techniques. Journal of Testing and Evaluation, Vol. 22, No. 5, Sept., 1994, pp. 424–430.

Harvey

, and Tsai

B.-W.

. Effects of Asphalt Content and Air-Void Content on Mix Fatigue and Stiffness. In Transportation Research Record 1543. TRB, National Research Council, Washington, D.C., 1996, pp. 38–45.

10.

Benson

Comparison of End-Result and Method Specifications for Managing Quality. In Transportation Research Record 1491, TRB, National Research Council, Washington, D.C., 1995, pp. 3–10.