To evaluate the potential health hazards of diesel engine emissions in underground coal mines, inhalation studies were performed using three species of animals. A wide range of toxicological responses was measured. Exhaust was provided by a 425 in.3 displacement four-cycle, water-cooled, naturally aspirated diesel engine (Caterpillar Model 3304) equipped with a water scrubber. Exposures were 7 h/day, 5 days/week, for periods up to 24 months. Micronized coal dust was generated using a Wright dust feeder. Four exposures were evaluated: (1) filtered ambient air, (2) 2 mg/m3 diesel particulate, (3) 2 mg/m3 respirable coal dust, and (4) 1 mg/m3 each of 2 and 3. Gaseous and vapor concentrations were similar in both exposures employing diesel exhaust. Male cynomolgus monkeys, Fischer-344 male and female rats, and female CD-1 mice were the experimental subjects. Monkeys were sacrificed at 24 months, rats at 3, 6, 12, and 24 months, and mice at 1, 3, and 6 months.
Gross morphology and histopathology demonstrated that both diesel and coal dust particles are deposited in the lungs and retained in alveolar tissue. Alveolar type II cell hyperplasia and pulmonary lipidosis occurred in rats, being most evident in rats exposed to diesel exhaust alone. There was, however, no evidence of emphysema or chronic bronchitis, and only minimal fibrosis was seen in association with the retained particulate. Both particulates affected the defense mechanisms of the lung. Exposure to coal dust activated responses associated with phagocytosis, whereas exposure to diesel exhaust depressed them. Severity of influenza challenge increased concomitantly with decreased interferon production in diesel-exposed mice. Exposure to diesel emissions did not result in genotoxic effects as measured by increases in sister chromatid exchange, chromosomal aberrations, micronucleus testing, and urine genotoxic assays. Pulmonary function studies in monkeys showed mild obstructive airway disease in coal dust, diesel exhaust, and the combined exposed animals. This effect was most pronounced in monkeys exposed to diesel exhaust. Evidence of restrictive lung disease was not seen in any group. Clearance of F3O4 particles appeared to be stimulated by exposure to diesel exhaust in the first 3 months, but long-term clearance of diesel particulate appeared to be inhibited. No evidence was found for increases in tumorogenicity (rats) or induction of xenobiotic metabolizing enzymes in the lung or liver (rats). Humoral and cellular immunities were not significantly affected by exposure (rats). No adverse seminal effects were observed in monkeys exposed for 2 years. There was no frank evidence of chronic toxicity as demonstrated by changes in mortality, body weight gains, organ-body weight ratios, or clinical parameters in rats or monkeys. Synergistic effects between diesel exhaust and coal dust were not demonstrated.
References
1.
1. Ames, R.G., Reger, R.B., and Wheeler, R.W. (1983). Injury experience in underground coal mines. Mining Eng.35, 310–12.
2.
2. Stefanko, R., Ramani, R.V., and Kenzy, G.W. (1977). Evaluation of Diesel Equipment Deployment in Underground Coal Mines, Vol. 1, Validation Experiments for Models of Diesel Exhaust Contamination of Mine Atmospheres. University Park, PA: Pennsylvania State University. NTIS Publication PB 288 716.
3.
3. Huisingh, J., Bradow, R., Jungers, R., Claxton, L., Zweidinger, R., Tejada, S., Bumgarner, J., Duffield, F., Waters, M., Simon, V., Hare, C., Rodriquez, C., and Snow, L. (1978). Application of bioassays to the characterization of diesel particulate emissions. In: Waters, M., Nesnow, S., Huisingh, J., Sandu, S., and Claxton, L. (ed.). Application of Short-Term Bioassays in the Fractionation and Analysis of Complex Environmental Mixtures, New York: Plenum Press, pp. 383–418.
4.
4. Karagianes, M.T., Palmer, R.F., and Busch, R.H. (1981). Effects of inhated diesel emissions and coal dust in rats. Am. Ind. Hyg. Assoc. J.42, 382–91.
5.
5. Lewtas, J. (1982). Mutagenic activity of diesel emissions. In: Lewtas, J. (ed.). Toxicological Effects of Emissions from Diesel Engines. New York: Elsevier. pp. 243–64.
6.
6. National Research Council (1981). Health effects of exposure to diesel exhaust. Washington, D.C.: National Academy of Sciences.
7.
7. Mcclellan, R.O., Brooks, A.L., Cuddihy, R.G., Jones, R.K., Mauderly, J.L., and Wolff, R.K. (1982). In: Lewtas. J. (ed.). Toxicological Effects of Emissions from Diesel Engines. New York, NY: Elsevier, pp. 99–120.
8.
8. Ames, R.G., Attfield, M.D., Hankinson, J.L., Hearl, F.J., and Reger, R.B. (1982). Acute respiratory effects of exposure to diesel emissions in coal miners. Am. Rev. Respir. Dis.125, 39–42.
9.
9. Reger, R., Hancock, J., Hankinson, J., Hearl, F., and Merchant, J. (1982). Coal miners exposed to diesel exhaust emissions. In: Walton, W.H. (ed.). Inhaled Particles. Vol. V, Oxford: Pergamon Press, pp. 799–815.
10.
10. Raffle, P.A.B. (1957). The health of the worker. Br. J. Ind. Med.14, 73–80.
11.
11. Waxweiler, R., Wagoner, J., and Archer, W. (1973). Mortality of potash workers. J. Occup. Med.15, 486–489.
12.
12. Leupker, R., and Smith. M. (1978). Mortality in unionized truck drivers. J. Occup. Med.20, 677–682.
13.
13. Hannunkari, I.E., Jarvinen, E., and Partanen, T. (1978). Work conditions and health of locomotive engineers. II. Questionnaire study, mortality and disability. Scand. J. Work Environ. Health4(3), 15–28.
14.
14. Kaplan, I. (1959). Relationship of noxious gases to carcinoma of the lung in railroad workers. JAMA171, 2039–43.
15.
15. Howe, G.R., Frazer, D., Lindsay, J., Presnal, B., and Yu, S.Z. (1983). Cancer mortality (1965–77) in relation to diesel fume in a cohort of retired railroad workers. JNCI70(6), 1015–19.
16.
16. Heinrich, U., Muhle, H., Takenaka, S., Ernst, H., Fuhst, R., Mohr, U., Pott, F., and Stober, W. (1986). Chronic effects on the respiratory tract of hamsters, mice, and rats after long-term inhalation of high concentrations of filtered and unfiltered diesel engine emissions. J. App. Toxicol.6(6), 383–95.
17.
17. Mauderly, J.L., Jones, R.K., Griffith, W.C., Henderson, R.F., and Mcclellan, R.O. (1987). Diesel exhaust is a pulmonary carcinogen in rats exposed chronically by inhalation. Fundament. Appl. Toxicol.9, 208–21.
18.
18. Brightwell, J., Fouillet, X., Cassano-Zoppi, A.L., Gatz, R., and Duchosal, F. (1986). Neoplastic and functional changes in rodents after chronic inhalation of engine exhaust emissions. In: Ishinishi, N., Koizumi, A., McClellan, R.O., and Stober, W. (eds.). Carcinogenic and Mutagenic Effects of Diesel Engine Exhaust, Proceedings of the Symposium on Toxicological Effects of Emissions from Diesel Engines held in Tsukuba City, Japan, July 26–28, 1986. New York: Elsevier, pp. 471–87.
19.
19. Ishinishi, N., Kuwabara, N., Nagase, S., Suzuki, T., Ishiwata, S., and Kohno, T. (1986). Long-term inhalation studies on effects of exhaust from heavy and light duty diesel engines on F344 rats. In: Ishinishi, N., Koizumi, A., McClellan, R.O., and Stober, W. (eds.). Carcinogenic and Mutagenic Effects of Diesel Engine Exhaust, Proceedings of the Symposium on Toxicological Effects of Emissions from Diesel Engines held in Tsukuba City, Japan, July 26–28, 1986. New York: Elsevier, pp. 329–48.
20.
20. Iwai, K., Udagawa, T., Yamagishi, M., and Yamada, H. (1986). Long-term inhalation studies of diesel exhaust on F344 SPF rats. Incidence of lung cancer and lymphoma. In: Ishinishi, N., Koizumi, A., McClellan, R.O., and Stober, W. (eds.). Carcinogenic and Mutagenic Effects of Diesel Engine Exhaust, Proceedings of the Symposium on Toxicological Effects of Emissions from Diesel Engines held in Tsukuba City, Japan, July 26–28, 1986. New York: Elsevier, pp. 349–60.
21.
21. Wheeler, R.W., Hearl, F.J., and McCAWLEY, M. (1981). An industrial hygiene characterization of exposure to diesel emissions in an underground coal mine. Environ. Int.5, 485–88.
22.
22. ASTM (1979). 1979 Annual Book of Astm Standards, Part 26, Gaseous Fuels: Coal and Coke; Atmospheric Analysis, R.P. Lukens et al. (eds.) Philadelphia: American Society for Testing and Materials.
23.
23. Choudary, G., and Posner, J.C. (1983). Characterization of diesel fuel In NIOSH diesel exhaust/coal dust study. NIOSH Internal Report, 1–10.
24.
24. Palassis, J. (1983). Crystalline silica and silicon analyses from the NIOSH/EPA coal/diesel study using x-ray fluorescence spectrometry and x-ray powder diffraction. NIOSH Internal Report, 1–10.
25.
25. Lunsford, R.A., Okenfuss, J.R., and Shulman, S.A. (1983). Characterization of selected vapor phase organic emissions. NIOSH Internal Report, 1–34.
26.
26. Breuer, G.M., and Smith, J.P. (1983). Characterization and analysis of polycyctic aromatic hydrocarbons. NIOSH Internal Report, 1–45.
27.
27. Millson, M.M., and Hull, R.D. (1983). Trace metal analyses of coal and diesel airborne particulate. NIOSH Internal Report, 1–41.
28.
28. Pepelko, W.E., and Peirano, W.B. (1983). Health effects of exposure to diesel engine emissions. A summary of animal studies conducted by the U.S. Environmental Protection Agency's Health Effects Research Laboratories at Cincinnati, Ohio. J. Am. Coll. Toxicol2, 253–306.
29.
29. Ames, B.N., McCANN, J., and Yamasaki, E. (1975). Methods for detecting carcinogenic and mutagens with the Salmonella/mammalian microsome mutagenicity test. Mutat. Res.31, 347–64.
30.
30. Perry, P., and Wolff, S. (1974). New Giemsa method for the differential staining of sister chromatids. Nature251, 156–8.
31.
31. Mentnech, M.S., Lewis, D.M., Olenchock, S.A., Mull, J.C., Koller, W.A., and Lewis. T.R. (1984). Effects of coal dust and diesel exhaust on immune competence in rats. J. Toxicol. Environ. Health13, 31–41.
32.
32. Hahon, N., Booth, J.A., and Wheeler, R. (1982). Activity of diesel engine emission particulates on the interferon system. Environ. Res.28, 443–55.
33.
33. Campbell, K.I., George, E.L., and Washington, I.S., Jr. (1980). Enhanced susceptibility to infection in mice after exposure to dilute exhaust from light duty diesel engines. In: Health Effects of Diesel Engine Emissions: Proceedings of an International Symposium. Cincinnati: U.S. Environmental Protection Agency, pp. 772–80.
34.
34. Castranova, V., Bowman, L., Reasor, M.J., Lewis, T., Tucker, J., and Miles, P.R. (1985). The response of rat alveolar macrophages to chronic inhalation of coal dust and/or diesel exhaust. Environ. Res.36, 405–19.
35.
35. Hahon, N., Booth, J.A., and Sepulveda, M. (1983). Effects of lignite, fly ash particulates and soluble components on the interferon system. Environ. Res.32, 329–43.
36.
36. Boyd, R.L., Fisher, M.J. and Jaeger, M.J. (1980) Noninvasive lung function tests in rats with progressive papain induced emphysema. Respir. Physiol.40, 181–90.
37.
37. Moorman, W.J., Hornung, R.W., and Wagner, W.D. (1977). Ventilatory functions in germ free and conventional rats exposed to coal dust. Proc. Soc. Exp. Biol. Med.155, 424–28.
38.
38. Weibel, E.R. (1969). Stereological Methods, Vol. 1, Practical Methods for Biological Morphometry. New York: Academic Press.
39.
39. Gross, K.B. (1981). Pulmonary function testing of animals chronically exposed to diluted diesel exhaust for fifteen months. J. Appl. Toxicol.1, 116–23.
40.
40. Vinegar, A., Carson, A.I., and Pepelko, W.E. (1980). Pulmonary function changes in Chinese hamsters exposed six months to diesel exhaust. Environ. Int.5, 369–71.
41.
41. Moorman, W.J., Clark, J.C., Pepelko, W.E., and Maddox J. (1985). Pulmonary function responses in cats following long-term exposure to diesel exhaust. J. Appl. Toxicol.5(5), 301–05.
42.
42. Moorman, W.J., Lewis, T.R., and Wagner W.D. (1975). Maximum expiratory flow-volume studies on monkeys exposed to bituminous coal dust. J. Appl. Physiol.39, 444–8.
43.
43. Barnhart, M.I., Salley, S.O., Chen, S.-T., and Puro, H. (1982). Morphometric ultrastructural analysis of alveolar lungs of guinea pigs chronically exposed by inhalation to diesel exhaust. In: Lewtas, J. (ed.). Toxicological Effects of Emissions from Diesel Engines. New York: Elsevier, pp. 183–200.
44.
44. Plopper, C.G., Hyde, D.M., and Weir, A.J. (1983). Centriacinar alterations in lungs of cats chronically exposed to diesel exhaust. Lab. Invest.49, 391–9.
45.
45. Pepelko, W.E., Mattox, J., Moorman, W.J., and Clark, J.C. (1981). Pulmonary function evaluation of cats after one year of exposure to diesel exhaust. Environ. Int.5, 373–6.
46.
46. Bergman, I. (1966). Determination of coal in formalin-fixed pneumoconiotic lungs. New method of tissue digestion using glacial acetic acid. Anal. Chem.38, 441–4.
47.
47. Vostal, J.J., Schreck, R.M., Lee, P.S., Chan, T.L., and Soderholm, S.C. (1982). Deposition and clearance of diesel particles from the lung. In: Lewtas, J. (ed.) Toxicological Effects of Emissions from Diesel Engines.New York: Elsevier, North Holland. pp. 143–59.
48.
48. Lewis, G.P., and Coughlin, L. (1973). Lung “soot” accumulation in man. Atmos. Environ.7, 1249–55.
49.
49. Chan, T.L., Lee, P.S., and Hering, W.E. (1984). Pulmonary retention of inhaled diesel particles after prolonged exposures to diesel exhaust. Fundament. Appl. Toxicol.4, 624–31.
50.
50. Griffis, L.C., Wolff, R.K., Henderson, R.F., Griffis, W.C., Moker, B.V., and McCLELLAN, R.O. (1983). Clearances of diesel soot particles from rat lung after a subchronic diesel exhaust exposure. Fundament. Appl. Toxicol.3, 99–103.
51.
51. Myrvik, Q.N., Leake, E.S., and Fariss, B. (1961). Lysozyme content of alveolar and peritoneal macrophages from the rabbit. J. Immunol.86, 133–6.
52.
52. Castranova, V., Bowman, L., and Miles, P.R. (1979). Transmembrane potential and ionic content of rat alveolar macrophages. J. Cell. Physiol.101, 471–80.
53.
53. Castranova, V., Bowman, L., Reasor, M.J. and Miles, P.R. (1980). Effects of metal ions on selected oxidative metabolic processes in rat alveolar macrophages. Toxicol. Appl. Pharmacol.53, 14–9.
54.
54. Miles, P.R., Castranova, V., and Lee, P. (1978). Reactive forms of oxygen and chemiluminescense in phagocytizing rabbit alveolar macrophages. Am. J. Physiol.235, C103–C108.
55.
55. Hartree, G.F. (1972). Determination of protein: A modification of the Lowry method that gives a linear photometric response. Anal. Biochem.48, 422–7.
56.
56. Turnbull, J.M., and Neil, M.W. (1969). The osmotic stability of lysosomes from adult and foetal guinea pig liver tissue. Biochem. J.111, 503–7.
57.
57. Lockard, V.G., and Kennedy, R.E. (1976). Alterations in rabbit alveolar macrophages as a result of traumatic shock. Lab. Invest.35, 501–6.
58.
58. Adams, Z., and Timar, M. (1978). Studies on the effects of quartz, bentonite, and coal dust mixture on macrophages in vitro. Br. J. Exp. Pathol.59, 411–5.
59.
59. Strom, K.A. (1981). Alveolar macrophage and polymorphonuclear leukocyte response in rats exposed by chronic inhalation to diluted diesel exhaust. Toxicologist1, 262.
60.
60. Chen, S., Weller, M.A., and Barnhart, M.I. (1980). Effects of diesel engine exhaust on pulmonary alveolar macrophages. Scanning Electron Microsc.3, 327–38.
61.
61. Weller, M.A., Chen, S., and Barnhart, M.I. (1981). Acid phosphatase in alveolar macrophages exposed in vivo to diesel engine exhaust. Micron12, 89–90.
62.
62. Weller, M.A., Chen S., and Barnhart, M.I. (1979). Acid phosphatase in alveolar macrophages exposed in vivo to diesel engine exhaust. G.M. contract publication CR 80–5/BI, International symposium on health effects of diesel engine emissions.
63.
63. Hill, J.O., Gray, R.H., Denee, P.B., and Newton, G.J. (1982). Comparative damage to alveolar macrophages after phagocytosis of respirable particles. Environ. Res.27, 95–109.
64.
64. Zavos, P.M. (1982). Bovine penetration test: An assay for nonspermic and oligateratoasthenospermic (OTA-syndrome) patients. Infertility5, 43–9.
65.
65. Zemjamis, R. (1970). Diagnostic and Therapeutic Techniques in Animal Reproduction. Baltimore: Williams & Williams.
66.
66. Gillette, J.R., Davis, D.C., and Sasame, H.A. (1972). Cytochrome P450 and its role in drug metabolism. Annu. Rev. Pharmacol.12, 57–84.
67.
67. Pelkonen, O., and Vahakangas, K. (1980). Carcinogenesis at the molecular level. Part II. Metabolic activation and inactivation of chemical carcinogens. J. Toxicol. Environ. Health.6, 989–99.
68.
68. Rabovsky, J., Petersen, M.R., Lewis, T.R., Marion, K.J., and Groseclose, R.D. (1984). Chronic inhalation of diesel exhaust and coal dust: Effect of age and exposure on selected enzyme activities associated with microsomal cytochrome P-450 in rat lung and liver. J. Toxicol. Environ. Health14, 655–66.
69.
69. Pepelko, W.E. (1982). EPA studies on the toxicological effects of inhaled diesel engine emissions. In: Lewtas, J. (ed.). Toxicological Effects of Emissions from Diesel Engines. New York: Elsevier, pp. 121–42.
70.
70. Elliott, F.M. (1964). The pulmonary artery system in normal and diseased lungs-structure in relation to pattern of branching. Ph.D. Thesis, University of London.
71.
71. Myerick, B., Hislop, A., and Reid, L. (1978). Pulmonary arteries of the normal rat—thick-walled oblique muscle segment. J. Anat.125, 209–21.
72.
***Address reprint requests to: William J. Moorman National Institute for Occupational Safety and Health 4676 Columbia Parkway, C-23 Cincinnati, OH 45226
