A Method for Estimating the Noise Level of Unstable Combustion Based on the Flame Describing Function

Abstract

Practical combustion is often coupled by the system acoustics and under some conditions the process may become unstable giving rise to oscillations of finite amplitude and to discrete tone noise radiation. The objective of this investigation is to model the nonlinear features of unstable combustion to predict limit cycle amplitudes and thus get an estimation of the radiated noise level under such regimes of operation. The present study is based on an analysis derived in a companion paper (Noiray et al. (2008)) which contains a complete nonlinear description of the thermo-acoustic coupling encountered in an unconfined reaction zone layout. Theoretical predictions are successfully compared with a set of measurements. It is shown that nonlinear phenomena such as frequency shifts, triggering or hysteresis may be suitably predicted by an analytical model based on the flame describing function (FDF). The objective of the present paper is to make use of this method to investigate nonlinear acoustic-combustion dynamics in a confined geometry comprising an upstream manifold, an injector and a flame tube. The flame is identified as the main nonlinear element in the system and its response to perturbations is characterized in terms of a describing function which assumes that the gain and phase depend on the amplitude level of the input. A frequency domain analysis is then carried out by solving the dispersion relation for a range of amplitudes. This yields growth rates and eigenfrequencies, which depend on the amplitude level of perturbations impinging on the flame. The growth rates and eigenfrequencies are determined for a wide range of upstream manifold lengths while keeping equivalence ratio and mass flow rate constant. For certain values of this parameter one finds a positive growth rate for vanishingly small amplitude levels indicating that the system is linearly unstable. The growth rate then changes as the amplitude is increased and eventually vanishes for a finite amplitude indicating the existence of a limit cycle. For other values of the length, the growth rate is initially negative, becomes positive for a finite amplitude and drops to zero for a higher level. This indicates that the system is linearly stable but nonlinearly unstable. Using calculated growth rates it is effectively possible to predict amplitudes of acoustic pressure oscillations in the system when it operates on a limit cycle and thus determine the noise level generated under such conditions.

Get full access to this article

View all access options for this article.

References

Birbaud

A. L.

Durox

, and Candel

(2006, Aug.). Upstream flow dynamics of a laminar premixed conical flame submitted to acoustic modulations. Combust. Flame 146(3), 541–552.

Chu

(1953). On the generation of pressure waves at a plane flame front. Proc. Combust. Inst. 4, 603–612.

Crocco

(1951). Aspects of Combustion Instability in Liquid Propellant Rocket Motors. J. Am. Rocket Soc. 21, 163–178.

Culick

F. E. C.

(1994, Jan). Some recent results for nonlinear acoustics in combustion-chambers. AIAA Journal 32(1), 146–169.

Culick

F. E. C.

(2006). Unsteady motions in combustion chambers for propulsion systems. AGARDograph, NATO/RTO-AG-AVT-039.

Dowling

A. P.

(1997). Nonlinear self-excited oscillations of ducted flame. J. Fluid Mech. 346, 271–290.

Dowling

A. P.

(1999). A kinematic model of ducted flame. J. Fluid Mech. 394, 51–72.

Dowling

A. P.

and Stow

S. R.

(2003, Sept.). Acoustic Analysis of Gas Turbine Combustors. J. Propul. Power 19(5), 751–764.

Eckstein

Freitag

Hirsch

, and Sattelmayer

(2006, Apr.). Experimental study on the role of entropy waves in low-frequency oscillations in a RQL combustor. Journal of Engineering for Gas Turbines and Power, ASME Trans. 128, 264–270.

10.

Lieuwen

(2002). Experimental Investigation of limit-cycle oscillations in an unstable gas turbine combustor. J. Propul. Power 18(1), 61–67.

11.

Lieuwen

and Zinn

(1998). The role of equivalence ratio fluctuations in driving combustion instabilities in low NOx, gas turbines. Proc. Combust. Instit., 27, 1809–1816.

12.

Martin

Benoit

Sommerer

Nicoud

, and Poinsot

(2006). Large-Eddy Simulation and Acoustic Analysis of a Swirled Staged Turbulent Combustor. AIAA Journal 44(4), 741–750.

13.

Nicoud

Benoit

Sensiau

, and Poinsot

(2007). Acoustic Modes in Combustors with Complex Impedances and Multidimensionnal Active Flames. AIAA Journal 45(2), 426–411.

14.

Noiray

Durox

Schuller

, and Candel

(2006). Self-Induced Instabilities of Premixed Flames in a Multiple Injection Configuration. Combust. Flame 145(3), 435–446.

15.

Noiray

Durox

Schuller

, and Candel

(2008). A unified framework for nonlinear combustion instability analysis based on the flame describing function. To appear in publication in Journal of Fluid Mechanics. doi: 10.1017/S0022112008003613

16.

Paschereit

C. O.

Schuermans

Polifke

, and Mattson

(2002). Measurement of transfer matrices and source terms of premixed flames. Journal of Engineering for Gas Turbines and Power, ASME Trans. 124, 239–247.

17.

Poinsot

and Veynante

(2001). Theoretical and Numerical Combustion. Philadelphia: Edwards.

18.

Poinsot

Yip

Veynante

Trouve

Samaniengo

J. M.

, and Candel

(1992, Jul.). Active control - an investigation method for combustion instabilities. Journal de physique III 2(7), 1331–1357.

19.

Rayleigh

(1896). The Theory of Sound. London: MacMillan, 2nd edition, Vol. 2, pp 224–234.

20.

Sattelmayer

(2003). Influence of the combustor aerodynamics on combustion instabilities from equivalence ratio fluctuations. Journal of Engineering for Gas Turbines and Power, ASME Trans. 125, 11–19.

21.

Schuller

Durox

, and Candel

(2003). A unified model for the prediction of laminar flame transfer functions : comparisons between conical and V-flame dynamics. Combust. Flame 134, 21–34.

22.

Truffin

and Poinsot

(2005). Comparison and extension of methods for acoustic identification of burners. Combust. Flame 142(4), 388–400.

23.

Wicker

J. M.

Greene

W. D.

Kim

, and Yang

(1996, Nov.). Triggering of Longitudinal Combustion Instabilities in Rocket Motors: Nonlinear Combustion Response. J. Prop. Power 12(6), 1148–1158.

24.

Zinn

B. T.

and Lores

M. E.

(1972). Application of galerkin method in solution of nonlinear axial combustion instability problems in liquid rockets. Combust. Sci. Technol. 4(6), 269.