Owing to their simplicity and their ability to represent the engine behaviour sufficiently well, cycle mean value models have been used for investigations of the transient response of marine diesel engines as well as the development of engine control schemes. In the present paper, two cycle mean value approaches of different complexities applied to the modelling of a large two-stroke marine diesel engine are described. The first modelling approach is less detailed since only two differential equations are used to represent the engine crankshaft and turbocharger shaft dynamics, whereas the other engine operating parameters are calculated after the solution of a non-linear algebraic system. In the second approach, more comprehensive modelling is obtained by using four additional differential equations, so that the dynamics of engine scavenging and exhaust receivers are captured. Using both modelling approaches, cases of the engine transient operation are simulated and the derived results are presented. Then, by comparing the simulation results with previously published data, the advantages and drawbacks of each approach are discussed.
FankhauserS.HeimK.‘The Sulzer RT-Flex: launching the era of common rail on low speed engines.’ In Proceedings of the 23rd CIMAC World Congress onCombustion engine technology, Hamburg, Germany, 7–10 May 2001, vol. 4, pp. 1398–1411
2.
EgebergC.-E.KnudsenT. S.SørensenP.‘The electronically controlled ME/ME-C series will lead the two-stroke diesel engine concept into the future.’ In Proceedings of the 24th CIMAC World Congress onCombustion engine technology, Kyoto, Japan, 7–11 June 2004, paper 82 (CIMAC, Frankfurt).
3.
SugiharaM.EdoK.TanidaT.‘Environmental friendly two-stroke marine diesel engine, ‘MITSUBISHI UEC eco-engine’.’ In Book of Abstracts of the Seventh International Symposium onMarine engineering (ISME), Tokyo, Japan, 24–28 October 2005.
4.
GuzzellaL.OnderC. H.Introduction to modeling and control of IC engine systems, 2007 (Springer, Berlin).
5.
ErikssonL.‘Modeling and control of turbocharged SI and DI engines.’Oil Gas Sci. Technol. – Rev. IFP62 (4) (2007): 523–538
6.
BensonR. S.‘Quasi-steady models.’ In The thermo-dynamics and gas dynamics of internal combustion engines (Eds HorlockJ. H.WinterboneD. E.), vol. II, 1986, ch.17, pp. 947–1015 (Clarendon Press, Oxford).
7.
WoodwardJ. B.LatorreR. G.‘Modeling of diesel engine transient behavior in marine propulsion analysis.’SNAME Trans.92 (1984): 33–49
8.
HendricsE.‘Mean value modeling of large turbocharged two-stroke diesel engines.’ SAE technical paper 890564, 1989.
9.
TheotokatosG.‘A modelling approach for the overall ship propulsion plant simulation.’ In Proceedings of the Sixth WSEAS International Conference onSystem science and simulation in engineering (ICOSSSE ‘07), Venice, Italy, 21–23 November 2007.
10.
ZhuJ.‘Modeling and simulating of container ship's main diesel engine.’ In Proceedings of the International MultiConference of Engineers and Computer Scientists (IMECS 2008), Hong Kong, People's Republic of China, 19–21 March 2008, vol. II pp. 1980–1983 (Newswood Limited, Hong Kong).
11.
StronachA. F.SmithJ. R.‘Development of a simulation model of turbocharged diesel engine prime-movers for power system studies.’J. Electl Power Energy Systems10 (2) (1988): 123–129
12.
Klein WoudJ.BootP.ter RietB. J.‘A diesel engine model for the dynamic simulation of propulsion systems.’Schip Werf Zee (1993): 1–93, 4–12
13.
ChesseP.ChaletD.TauziaX.HetetJ. F.InozuB.‘Real-time performance simulation of marine diesel engines for the training of navy crews.’Mar. Technol.41 (3) (2004): 95–101
14.
GrimmeliusH.MesbahiE.SchultenP.StapersmaD.‘The use of diesel engine simulation models in ship propulsion plant design and operation.’ In Proceedings of the 25th CIMAC World Congress onCombustion engine technology, Vienna, Austria, 21–24 May 2007, paper 227 (CIMAC, Frankfurt).
15.
RakopoulosC. D.MichosC. N.GiakoumisE. G.‘A computational study of compressor surge during transient operation of turbocharged diesel engines.’Int. J. Alternative Propulsion1 (2–3) (2007): 250–274
16.
XirosN. I.KyrtatosN. P.‘A nonlinear state-space model of diesel propulsion plant operation using neural nets.’ In Proceedings of the IFAC Conference onControl applications in marine systems (CAMS 2001), Glasgow, UK, 18–20 July 2001, pp. 131–136 (IFAC, Laxenburg)
17.
XirosN.Robust control of diesel ship propulsion, 2002 (Springer, Berlin).
18.
LanW.-C.KatagiT.HashimotoT.‘Quasi steady simulation of diesel engine transient performance and design of mechatronic governor.’Bull. MESJ24 (1) (1996): 1–13
19.
StefanopoulouA.SmithR.‘Maneuverability and smoke emission constraints in marine diesel propulsion.’Control Engng Practice8 (2000): 1023–1031
20.
LivanosG.PapalamprouG.KyrtatosN. P.ChristouA.‘Electronic engine control for ice operation of tankers.’ In Proceedings of the 25th CIMAC World Congress onCombustion engine technology, Vienna, Austria, 21–24 May 2007, paper 44 (CIMAC, Frankfurt).
21.
MeierE.‘A simple method of calculation and matching turbochargers.’ Publication CH-T 120 163 E, Brown Boveri & Company Ltd, Baden, Switzerland, 1981.
22.
HeywoodJ. B.Internal combustion engines fundamentals, 1988 (McGraw-Hill, New York).
23.
WatsonN.JanotaM. S.Turbocharging the internal combustion engine, 1982 (Macmillan, Basingstoke, Hampshire).
24.
KyrtatosN. P.TheodossopoulosP.TheotokatosG.XirosN.‘Simulation of the overall ship propulsion plant for performance prediction and control.’ In Proceedings of the Conference onAdvanced marine machinery systems with low pollution and high efficiency (MarPower ‘99), Newcastle upon Tyne, UK, 25–26 March 1999, pp. 103–114 (The Institute of Marine Engineers, London)
25.
KyrtatosN. P.TheotokatosG.XirosN.MarekK.DugeR.‘Transient operation of large-bore two-stroke marine diesel engine powerplants: measurements and simulations.’ In Proceedings of the 23rd CIMAC World Congress onCombustion engine technology, Hamburg, Germany, 7–10 May 2001.
26.
KyrtatosN. P.TheotokatosG.XirosN. I.‘A virtual experiment tool for marine diesel engine powerplant analysis.’ In Proceedings of the Tenth International Congress of the International Maritime Association of the Mediterranean (IMAM 2002), Rethymnon, Crete, Greece, 13–17 May 2002.
27.
MAN B&W K90MC mark 6 project guide: Two-stroke engines, 5th edition, November 2000 (MAN Diesel SE, Augsburg, Germany).
