Assessment of combustion in natural gas dual-fuelled compression ignition engines with dimethyl ether and rapeseed methyl ester pilot ignition

Abstract

Compression-ignition engines are known to be more efficient than similar-sized spark-ignition engines because of the higher compression ratios and leaner combustion. The emissions of soot and nitrogen oxides remain the main hurdle in the complete exploitation of these engines. Dual-fuelling is one means favoured for solving the emission problem, in which high-octane fuels are used as the main fuel which is ignited by a smaller pilot injection of diesel or another high-cetane fuel. These dual-fuel engines produce less particulate matter and nitrogen oxides than spark-ignition engines, while retaining the desired compression-ignition engine efficiency. In the present investigation, tests were conducted using a variety of renewable and non-renewable fuels for pilot injection. The pilot fuels employed were conventional diesel, rapeseed methyl ester (known as biodiesel), and dimethyl ether, while natural gas was used as the main fuel. Biogas, or landfill gas, would be the renewable alternative. Pressure versus crank angle traces were obtained, together with their first and second derivatives. These were analysed to determine the crank angle at which ignition began. Diagrams that show the rate of reaction were also plotted for the same purpose. Here, the start of ignition is determined by the trace suddenly changing slope and rising above zero. Using these methods, the ignition delay was determined for different operating conditions and comparisons drawn for different pilot fuels. The characteristic shapes of rate-of-reaction curves were analysed highlighting differences in the combustion processes occurring in single- and dual-fuel diesel engine operation. Emissions data for different operating conditions were also obtained and analysed, showing a tendency for lower emissions of smoke and oxides of nitrogen but increased carbon monoxide and unburnt hydrocarbons to be produced in dual-fuelling. Carbon dioxide was also reduced.

Keywords

dual-fuel engines rate of reaction biodiesel,rapeseed methyl ester pressure profiles

Get full access to this article

View all access options for this article.

References

Chen

Clarke

Patterson

Experimental study of the performance and emissions characteristics of a small diesel genset operating in dual-fuel mode with three different primary fuels. In New diesel engines and components and CI engine performance for use with alternative fuels, 2006, manuscript number 2006-01-0050 (SAE International, Warrendale, Pennsylvania, USA).

Crookes

R. J.

Bob-Manuel

K. D. H.

, ‘RME or DME: A preferred alternative fuel option for future diesel engine operation.’ Energ. Convers. Mgmt 48 (2007): 2971–2977

Bob-Manuel

K. D. H.

Crookes

R. J.

Olsen

, ‘Renewable fuelling of a diesel engine in single and dual fuel operation.’ In Proceedings of Technische Akademie Esslingen (TAE) 6^th International Colloquium on Fuels, Ostfildern, Germany, 10 and 11 January 2007 pp. 31–42.

Karim

G. A.

, ‘Combustion in gas fuelled compression: Ignition engines of the dual fuel type.’ J. Engng Gas Turbines Power 125 (July) (2003): 827–836

Hountalas

D. T.

Papagiannakis

R. G.

, ‘Combustion and exhaust emission characteristics of a dual fuel compression ignition engine operated with pilot diesel fuel and natural gas.’ Energ. Convers. Mgmt 45 (18—19) (2004): 2971–2987

Arcoumanis

Bae

Crookes

R. J.

Kinoshita

, ‘The potential of dimethyl ether (DME) as an alternative fuel for compression-ignition engines.’ Fuel 87 (2008): 1014–1030

Heywood

J. B.

, Internal combustion engine fundamentals, international edition (: 1988): 508-510 (McGraw-Hill, New York, USA).

Kiannejad

, Assessment of vegetable oil and emulsions for use as fuels in diesel engines PhD Thesis, Department of Engineering, Queen Mary and Westfield College, University of London 1993.

Malynn

Musawi

Odetunde

Rodrigues

, ‘Alternative automobile engine fuels for the UK market.’ MEng Thesis, Queen Mary and Westfield College, University of London 2006.

10.

Olsen

Crookes

R. J.

Bob-Manuel

K. D. H.

, ‘Experiments in dual fuelling a compression ignition engine by injecting dimethyl ether as a pilot fuel to ignite varying quantities of natural gas.’ In Asia Pacific automotive engineering conference technical papers, 2007, manuscript number 2007-01-3624 (SAE International, Warrendale, Pennsylvania, USA).

11.

BP Statistical Review of World Energy, June 2007 (British Petroleum).