Low-emission combustion of a pre-chamber-type compression ignition natural gas engine

Abstract

A pre-chamber-type compression ignition natural gas engine was constructed and its performance and NO emissions were investigated. The pre- and main chambers made of ceramics were connected by a throat valve that opened during the compression stroke. An homogenous fuel air charge mixed with exhaust gas recirculation (EGR) gases was introduced into the main chamber, while a smaller amount of fuel was supplied into the pre-chamber during the intake stroke. The mixture in the pre-chamber was auto-ignited when the compressed hot gases in the main chamber were introduced into the pre-chamber through the throat valve during the compression stroke. The engine was operated without knock under various load conditions by adjusting the throat valve opening timing appropriately. The influences of the throat valve opening timing, compression ratio, and pre-chamber volume ratio on torque and NO emissions were investigated. Test results showed that: (a) at conditions when the thermal efficiencies were high, the patterns of the rate of heat release were similar to each other and independent of the compression ratio and pre-chamber volume ratio; (b) the optimum throat valve opening timing was strongly dependent on compression ratio and pre-chamber volume ratio; and (c) at conditions when the rate of heat release displayed two peaks - first low peak corresponding to the initial combustion in the pre-chamber and second high peak corresponding to combustion in the main chamber - low NO emissions below 20 ppm featuring homogeneous charge compression ignition (HCCI) combustion were achieved.

Keywords

gas engine pre-chamber throat valve heat-insulated engine HCCI combustion

Get full access to this article

View all access options for this article.

References

Sasaki

Sekiyama

Nakashima

A new combustion system of a heat-insulated natural gas engine. Int. J. Engine Res. 2002, 3(4), 197–206.

Nakashima

Kishishita

Sekiyama

Kawamura

Development of a heat insulated natural gas engine for hybrid vehicle. JSAE paper 9933600, 1999.

Sasaki

Nakashima

A new combustion system of a heat insulated natural gas engine with a pre-chamber for hybrid vehicle. In Proceedings of the 7th International Conference and Exhibition on Natural Gas Vehicles 2000, pp. 155–164.

Kawamura

Higashino

Sekiyama

Combustion and combustion chamber for a low heat rejection engine. SAE paper 960506, 1996.

Heywood

J. B.

Internal combustion engine fundamentals, 1988, p. 515 (McGraw-Hill, New York).

Kawabata

Nakagawa

Shoji

Operating characteristics of natural gas fueled homogeneous charge compression ignition engine. JSAE paper 9932953, 1999.

Christensen

Johnansson

Einewall

Homogeneous charge compression ignition (HCCI) using isooctane, ethanol and natural gas - a comparison with spark ignition operation. SAE paper 972874, 1997.