Second law optimization of two-stage transcritical CO 2 refrigeration cycles in the cooling mode operation

Abstract

Second law optimization studies of two-stage transcritical CO₂ (TRCC) refrigeration cycles, incorporating options such as a new ejector-expansion with internal heat exchanger (IHE) and intercooler (IC), flash gas bypass, flash gas intercooling, compressor intercooling with IHE, are presented based on cycle simulation. To validate the simulations, the available numerical data in open literature are used. It is found that the coefficient of performance (COP) and second law efficiency of the new two-stage TRCC cycle are on average 16.5, 18.4, and 28.4 per cent higher than that of the two-stage TRCC with IHE and IC, the two-stage TRCC with flash gas bypass, and the two-stage TRCC with flash gas intercooling cycles, respectively. Hence, the new two-stage refrigeration cycle is a promising refrigeration cycle from the thermodynamic point of view. It is also concluded that for cases of the flash gas bypass and flash gas intercooling the optimum inter-stage pressure deviates significantly from the geometric mean pressure of the gas cooler and evaporator pressure. While for the new two-stage TRCC and the two-stage TRCC with IHE and IC, the optimum inter-stage pressure is approximately equal to geometric mean pressure. Finally, a regression analysis was employed in terms of evaporator and gas cooler exit temperatures to develop mathematical expressions for maximum COP, optimum discharge, and inter-stage pressures and entrainment ratio.

Keywords

two-stage cycle ejector-expansion internal heat exchanger intercooler coefficient of performance second law optimization

Get full access to this article

View all access options for this article.

References

Yang

J. L.

Y. T.

Liu

S. C.

Performance investigation of transcritical carbon dioxide two-stage compression cycle with expander

Energy 32 (2007): 237–245.

Agrawal

Bhattacharyya

Studies on a two-stage transcritical carbon dioxide heat pump cycle with flash intercooling

Appl. Therm. Eng. 27 (2007): 299–305.

Agrawal

Bhattacharyya

Sarkar

Optimization of two-stage transcritical carbon dioxide heat pump cycles

Int. J. Therm. Sci. 46 2 (2007): 180–187.

Yari

Sirousazar

Cycle improvements to ejector-expansion transcritical CO₂ two-stage refrigeration cycle

Int. J. Energy Res. 32 (2008): 677–687.

Kim

H. J.

Ahh

J. M.

Cho

S. O.

Cho

K. R.

Numerical simulation on scroll expander-compressor unit for CO₂ trans-critical cycles

Appl. Therm. Eng. 28 (2008): 1654–1661.

Ozgur

A. E.

The performance analysis of a two-stage transcritical CO₂ cooling cycle with various gas cooler pressures

Int. J. Energy Res. 32 14 (2008): 1309–1315.

Ozgur

A. E.

Bayrakci

H. C.

Second law analysis of two-stage compression transcritical CO₂ heat pump cycle

Int. J. Energy Res. 32 13 (2008): 1202–1209.

Klein

Alvarda

, Engineering equation solver (Middleton, WI: F-chart Software 2007).

Sarkar

Optimization of ejector-expansion transcritical CO₂ heat pump cycle

Energy 33 (2008): 1399–1406.

10.

Deng

J.-Q.

Jiang

P.-X.

Particular characteristics of transcritical CO₂ refrigeration cycle with an ejector

Appl. Therm. Eng. 27 (2007): 381–388.

11.

Liao

S. M.

Zhao

T. S.

Jakobsen

Correlation of optimal heat rejection pressures in transcritical carbon dioxide cycles

Appl. Therm. Eng. 20 9 (2000): 831–841.

12.

Ren

Chen

Applying mechanical subcooling to ejector refrigeration cycle for improving the coefficient of performance

Energy Convers. Manage. 48 4 (2007): 1193–1199.

13.

Cengel

Y. A.

Boiles

M. A.

, Thermodynamics: An engineering approach 6th edition (New York: McGraw-Hill Inc. 2007).

14.

Bejan

Tsatsaronis

Moran

, Thermal design and optimization (New York, NY: John Wiley and Sons Inc. 1996).

15.

Groll

Transcritical CO₂ refrigeration cycle with ejector-expansion device

Int. J. Refrig. 28 (2005): 766–773.

16.

Huang

B. J.

Chang

J. M.

Wang

C. P.

Petrenko

V. A.

A 1-D analysis of ejector performance

Int. J. Refrig. 22 (1999): 354–364.