Venturi investigations into cavitation in ethylene glycol/water mixtures

Abstract

The objective of the investigation was to study cavity formation with various concentrations of ethylene glycol/water (EG/W) in order to gain an insight into the previously observed anomalous thermal effects in these mixtures. The normal thermal effect is for the apparent cavitation coefficient to decrease with increase in fluid temperature whereas in EG/W mixtures it has been observed to increase. Cavities in a cavitating venturi tube were observed and photographed. The cavity pressure was measured, together with cavity temperatures at various distances along the cavity. The measured temperatures confirmed that the cavity temperature depression, which is responsible for the normal thermal effect, is present in EG/W mixtures and, if this were the only factor, these mixtures should exhibit the same thermal effect as other liquids. However, the cavity pressure measurements showed that a gas (undoubtedly air) was present in the cavity, the proportion of air increasing with the concentration of ethylene glycol (EG). This air is responsible for the reverse thermal effect with EG/W mixtures, a phenomenon previously observed at higher temperatures with water. It is thought that microbubbles of air observed circulating in the rig are responsible for the collected air in the cavity, the persistence of these bubbles increasing with increasing concentration of EG.

Keywords

venturi tube cavitation ethylene glycol/water mixtures

Get full access to this article

View all access options for this article.

References

Gummer

J. H.

Thew

M. T.

A critical review of cavitation in ethylene glycol/water cooling systems. In Proceedings of 3rd IMechE Conference on

Cavitation, Cambridge, UK, 1992, paper C453/008, pp. 293–302 (Mechanical Engineering Publications Limited, London).

Thew

M. T.

Hadji-Sheik

Cavitation of water—glycol mixtures in small centrifugal pumps. In Proceedings of the Fluid Mechanics Silver Jubilee Conference, National Engineering Laboratory (NEL), East Kilbride, Glasgow, 1979, paper 3.5.

Ruggeri

R. S.

Moore

R. D.

Gelder

T. F.

Incipient cavitation of ethylene glycol in a tunnel venturi. NASA Technical Note TN D 2722, 1964.

Glycols. Union Carbide Chemicals and Plastics Publication F-49193B-ICD, 1991.

Chalaby

A. A.

Thew

M. T.

Cavitation in a binary mixture of polar liquids (water—antifreeze) in a small centrifugal pump. In Proceedings of the Second International Conference on

Cavitation, Edinburgh, 1983, pp. 69–76 (Mechanical Engineering Publications, London).

Ruggeri

R. S.

Experimental studies on thermodynamic effects of developed cavitation. In Proceedings of the Symposium on

Cavitation, Pennsylvania State University, August-September 1970, NASA Publication SP-034, p. 377.

Gummer

J. H.

Thew

M. T.

Experimental study of cavitation bubble growth in ethylene glycol water mixtures. In Proceedings of the Second International Symposium on

Cavitation, Tokyo, Japan, April 1994, pp. 273–279 (Organizing Committee for ‘Cavitation 94’, Tokyo).

Bonnin

Billet

M. L.

Hammit

F. G.

Chaix

Survey of present knowledge on cavitation in liquids other than cold water. J. Hydraul. Res., 1981, 19 (4), 277–305.

Chivers

T. C.

Effect of air content on advanced cavitation. Engineer, 16 August 1968, 250–254.

10.

Parkin

B. R.

The initiation of gaseous microbubble growth in laminar separation bubbles. Trans. ASME, J. Fluids Engng, December 1981, 103, 543–550.

11.

Yamamoto

Tokunaga

Solubility of nitrogen and oxygen in 1,2-ethanediol + water at 298.15K and 101.33kPa. J. Chem. Engng Data, 1994, 39, 544–547.

12.

Kuthan

Endrst

Broz

Mass transfer in liquid films during absorption. Part II: Solubilities and diffusivities of H_e, N₂ and C₃H₈ in aqueous ethylene glycol solutions at 25°C. Chem. Engng Process, 1989, 25, 65–74.