Effects of the addition of ethanol and cetane number improver on the combustion and emission characteristics of a compression ignition engine

Abstract

Combustion and emission characteristics of a direct-injection diesel engine fuelled with diesel—ethanol blends were investigated. The results show that the ignition delay and the premixed combustion duration increase, while the diffusive combustion duration and the total combustion duration decrease with increase in the oxygen mass fraction in the blends. The addition of 0.2 per cent volume fraction of cetane number improver (isoamyl nitrite) could mean that the ignition delay and the premixed combustion duration of the fuel blends with 10vol% ethanol fraction recover to those of diesel fuel. Meanwhile, with the increase in the ethanol fraction in the fuel blends, the centre of the heat release curve moves closer to the top dead centre. The brake specific fuel consumption increases, while the diesel equivalent brake specific fuel consumption decreases with increase in the ethanol fraction. The exhaust smoke concentration increases and exhaust nitrogen oxide (NO _x ) concentration decreases on prolonging the fuel delivery advance angle for both diesel fuel and the blended fuels. For a specific fuel injection advance angle, the exhaust smoke concentration shows a large decrease and the exhaust NO _x concentration a small decrease on ethanol addition.

Keywords

combustion emission diesel ethanol oxygenated fuel blends

Get full access to this article

View all access options for this article.

References

Fleisch

McCarthy

Basu

A new clean diesel technology: Demonstration of ULEV emissions on a Navistar diesel engine fueled with dimethyl ether. SAE Trans., 1995, 104(4), 42–53.

Kapus

Ofner

Development of fuel injection equipment and combustion system for DI diesels operated on dimethyl ether. SAE Trans., 1995, 104(4), 54–69.

Sorenson

S. C.

Mikkelsen

S. E.

Performance and emissions of a 0.273 liter direct injection diesel engine fueled with neat dimethyl ether. SAE Trans., 1995, 104(4), 80–90.

Huang

Z. H.

Wang

H. W.

Chen

H. Y.

Study on combustion characteristics of a compression ignition engine fueled with dimethyl ether. Proc. Instn Mech. Engrs Part D: J. Automobile Engineering, 1999, 213(6), 647–652.

Kajitani

Chen

Konno

Engine performance and exhaust characteristics of direct- injection diesel engine operated with DME. SAE Trans., 1997, 106(4), 1568–1577.

Huang

Miao

Zhou

Jiang

Combustion characteristics and hydrocarbon emissions of a spark ignition engine fuelled with gasoline-oxygenate blends. Proc. Instn Mech. Engrs Part D: J. Automobile Engineering, 2000, 214(3), 341–346.

Huang

Z. H.

H. B.

Jiang

D. M.

Zeng

Liu

Zhang

J. Q.

Wan

X. B.

Combustion behaviors of a compression-ignition engine fuelled with diesel/methanol blends under various fuel delivery advance angles. Bioresource Technol., 2004, 95(3), 331–341.

Huang

Z. H.

H. B.

Jiang

D. M.

Zeng

Liu

Zhang

J. Q.

Wan

X. B.

Engine performance and emissions of a compression ignition engine operating on the diesel-methanol blends. Proc. Instn Mech. Engrs Part D: J. Automobile Engineering, 2004, 217(4), 435–447.

Huang

Z. H.

Jiang

D. M.

Zeng

Liu

Yang

Z. L.

Combustion characteristics and heat release analysis of a DI compression ignition engine fueled with diesel-dimethyl carbonate blends. Proc. Instn Mech. Engrs Part D: J. Automobile Engineering, 2003, 217(7), 595–606.

10.

Murayama

Zheng

Chikahisa

Simultaneous reduction of smoke and NOx from a DI diesel engine with EGR and dimethyl carbonate. SAE Paper 952518, 1995.

11.

Ajav

E. A.

Singh

Bhattacharya

T. K.

Experimental study of some performance parameters of a constant speed stationary diesel engine using ethanol-diesel blend as fuel. Biomass Bioe- nergy, 1999, 17, 357–365.

12.

Huang

Z. H.

H. B.

Jiang

D. M.

Zeng

Liu

Zhang

J. Q.

Wang

X. B.

Engine performance and emissions of a compression ignition engine operating on the diesel-methanol blends. Proc. Instn Mech. Engrs Part D: J. Automobile Engineering, 2004, 218(4), 435–447.

13.

Miyamoto

Ogawa

Obata

Improvements of diesel combustion and emissions by addition of oxygenated agents to diesel fuels: Influence of properties of diesel fuels and kinds of oxygenated agents. JSAE Rev., 1998, 19(2), 154–156.

14.

Akasaka

Sakurai

Effect of oxygenated fuel on exhaust emission from DI diesel engines. Trans. JSME. Ser. B, 1996, 63(609), 1833–1839.

15.

McCormick

R. L.

Ross

J. D.

Graboski

M. S.

Effect of several oxygenates on regulated emissions from heay-duty diesel engines. Environmental Sci. Technol., 1997, 31, 1144–1150.

16.

Satge de Caro

Mouloungui

Vaitilingom

Berge

J. Ch.

Interest of combining an additive with diesel-ethanol blends for use in diesel engines. Fuel, 2001, 80, 565–574.

17.

B. Q.

Shuai

S. J.

Wang

J. X.

The effect of ethanol blended diesel fuels on emissions from a diesel engine. Atmos. Environ., 2003, 37, 4965–4971.

18.

Can

Celikten

Usta

Effects of ethanol addition on performance and emissions of a turbocharged indirect injection diesel engine running at different injection pressures. Energy Conversion Managmt., 2004, 45, 2429–2440.