Some aspects concerning the combination of downsizing with turbocharging,variable compression ratio,and variable intake valve lift

Abstract

The inefficient running of the spark ignition engine at part loads due to the load control method but, mostly, their major weighting in the vehicle's operation time justifies the interest in the technical solutions, which act in this particular operating range. These drawbacks encountered at low part loads are even more amplified when considering larger engines. For instance, it is well known that, at the same engine load, a larger engine is more throttled than a smaller engine; therefore the concerns are the higher pumping work, the lower real compression ratio, and the overall mechanical efficiency, which is also lower. One solution is a reduction in the displacement without affecting the power output. This is what is now commonly known as the downsizing technique.

The combination of downsizing and uploading an engine has been known for a long time. However, the conversion, in an acceptable way, of this potential to actual practice is very challenging. On the one hand, the degree of the downsizing is related to the boost pressure. In order to cope with the knocking phenomenon, the downsized high-pressure turbocharged gasoline engine requires a lower volumetric compression ratio that limits the efficiency on part loads. Therefore, the degree of the downsizing has been limited and, thus, the possible fuel consumption reduction has not yet been fully achieved. On the other hand, other problems are encountered when considering a downsized turbocharged gasoline engine: insufficient low-end torque, poor starting performance, and turbo lag.

In order to solve these problems an effective combination of the downsized turbocharged gasoline engine with additional technologies is needed. Thus, the paper will present a so-called adaptive thermal engine, which has at the same time a variable compression ratio and a variable intake valve lift. It will then be demonstrated that it is highly suitable for turbocharging, thus resulting in a high downsizing factor.

Keywords

efficiency downsizing turbocharging variable compression ratio variable valve timing

Get full access to this article

View all access options for this article.

References

Clenci

Researches regarding the improvement of part loads SIE operation through the use of variable compression and pressurecharging. Doctoral Thesis, Brasov, Romania, 2003.

Takaoka

Tada

Hirose

Super efficient gasoline engine for the Toyota hybrid system. In Proceedings of the FISITA World Automotive Congress, Paris, France, 1998.

Ahmed

Advanced gasoline powertrain for reduced fuel consumption and CO₂ emissions. In Proceedings of the SIA Conference on Downsizing, 6 February 2003 (Société des Ingénieurs de L'Automobile, Suresnes).

Duchaussoy

Lefebvre

Bonetto

Dilution interest on turbocharged SI engine combustion. Rev. Ingrs Auto., June-July 2003, 762, 52–58.

Reinmann

Drangel

Olofsson

Future near term SI engine concepts for fuel fuel consumption reduction with worldwide compliant emissions. In Proceedings of the FISITA World Automotive Congress, Helsinki, Finland, 2002.

Turner

J. W. G.

Pearson

R. J.

Bassett

M. D.

Performance and fuel economy enhancement of pressure charged SI engines through turbo-expansion - an initial study. SAE paper 2003–01-0401, 2003.

Clenci

Descombes

Podevin

Hara

Some aspects concerning the geometry of a hinged engine with a variable compression ratio. Proc. IMechE, Part D: J. Automobile Engineering, 2006, 220 (1), 103–110.

Clenci

Hara

The turbocharged engine with variable compression ratio. In Proceedings of the Seventh EAEC Congress on Vehicle Systems Technology for the Next Century, Barcelona, Spain, 30 June-2 July 1999.

10.

Hara

Clenci

Adaptive thermal engine with variable compression ratio and variable intake valve lift, 2002 (University of Pitesti, Pitesti).

11.

Hara

Clenci

The adaptive thermal engine - a self-regulation system with fast response time. In Proceedings of the Global Powertrain Congress, Detroit, Michigan, USA, 2001.

12.

13.

Adams

T. G.

Comparison of a turbocharger to a supercharger on a spark ignited engine. IMechE Conference C425/84, 1984.

14.

Wolters

Fuel economy concepts for gasoline engines in connection with future emission legislation. In Proceedings of the FISITA World Automotive Congress, Paris, France, 1998.

15.

Clenci

Descombes

Podevin

Hara

Throttle-less operation by variable valve lift and timing. In Proceedings of the Ninth International Congress on Automotives (CAR2005), University of Pitesti, Romania, 2005.