The hydrogen induced cracking of X70 pipeline steel was investigated in low temperature and low dissolved oxygen seawater (4°C and 3-4 mg L−1 dissolved oxygen) by potentiodynamic polarisation, slow strain rate tests and hydrogen permeation measurements. The results showed that the hydrogen evolution potential of X70 steel in low temperature and low dissolved oxygen seawater decreased compared with the normal shallow seawater. The susceptibility to hydrogen embrittlement increased as the potential shifted in the negative direction. When the polarisation potentials were below −1050 mV(SCE) in low temperature and low dissolved oxygen seawater, the fracture surfaces exhibited quasi-cleavage fracture.
FitzgeraldJ.: ‘Cathodic protection—its history and application’Corrosion Asia: 1st NACE Asian Conf., Singapore, September 1992, NACE.
2.
HarttW. H.ChenS.: Corrosion199854317.
3.
MarshP. G. and GerberichW. W.: ‘Stress corrosion cracking’, (ed. JonesR. H.), 63; 1992Materials Park, OHASM International.
4.
ChuW. Y.QiaoL. J.ChenQ. Z. and GaoK. W.: ‘Fracture and environmental fracture’; 2000BeijingScience Press.
5.
BillinghamJ.SharpJ. V. and SpurrierJ.: ‘Review of the performance of high strength steels used offshore’111–117; 2003SuffolkHealth & Safety Executive.
6.
CaoS. S. and SunJ. X.: J. Chin. Soc. Corros. Prot.200727114.
7.
DuY. X. and ZhangG. Z.: J. Chin. Soc. Corros. Prot.200626346.
8.
StoreM. E.: ‘Hydrogen embrittlement of ferrous materials’Universite Libre De Bruxelles, Brussels, Belgium2006.
9.
OniA.: Constr. Build. Mater.19961081.
10.
KimS. J.OkidoM. and MoonK. M.: Korean J. Chem. Eng.200320560.
11.
KimS. J.JangS. K. and KimJ. I.: Met. Mater. Int.20051163.
12.
ChangE.YanY. G.LiQ. F. and MaL.: J. Chin. Soc. Corros. Prot.20103083.
13.
KimS. J.JangS. K. and KimJ. I.: Met. Mater. Int.20051163.
14.
QiuK. Y.WeiB. M. and FangY. H.: J. Nanjing Inst. Chem. Technol.199218.
15.
DevanathanM. A. V. and StachurskiZ.: J. Electrochem. Soc.1963110886.
16.
TangX.: ‘Hydrogen permeation behavior of hot-dipped steels in seawater and its effect on the mechanical properties of steel substrate (marine chemistry)’; 2006QingdaoInstitute of Oceanology, Chinese Academy of Sciences.
17.
HardieD.CharlesE. A. and LopezA. H.: Corros. Sci.2006484378.
18.
ChawlaK. K. and RigsbeeJ. M.: J. Mater. Sci.19862177.
19.
TanW. Z.DuY. L.FuC. and LuZ.: Mater. Prot.19882110.
20.
CrankJ.: ‘The mathematics of diffusion’51; 1979OxfordOxford University Press.
21.
LiM.LiX. G.ChenG. and LiuZ. Y.: J. Univ. Sci. Technol. Beijing20072939.
22.
BandyyopadhyN.KamedaJ. and McmahonC. J.: Metall. Trans. A198314A881.
23.
BeahemC. D.: Metall. Trans.19723441.
24.
JinS. and AtrensA.: Appl. Phys. A198742A149.
25.
AddachH.BercotP.RezraziM. and WeryM.: Mater. Lett.2005591347.
26.
OlsenS. and HesjevikS. M.: ‘Hydrogen embrittlement from CP on supermartensitic stainless steels—recommendations for new qualification methods’CORROSION 2004, Houston, TX, USA, February 2004, NACE, paper no. 045461–12.
