Time-Dependent Behaviour and Viscoelastic Constitutive Modelling of an Epoxy Polymer

Abstract

The time-dependent behaviour of a cold cure epoxy polymer was investigated by different types of tests including compression, tension, biaxial loading, strain recovery, stress relaxation, creep and cyclic creep. This epoxy showed nonlinear viscoelastic behaviour since strains were fully recovered after stresses were removed and sufficient time was allowed for the recovery. A linear viscoelastic constitutive model has been extended to the nonlinear regime, and used to simulate the test results. It was found that the model is capable of predicting the observed trends for different types of tests. With one set of specified material constants, the model provides a fairly good prediction for several types of tests. However, this trend may not hold for other types of tests, for which the material constants were not calibrated, although the general trend would be predicted satisfactorily.

Get full access to this article

View all access options for this article.

References

Kujawski

and Ellyin

, “Rate/Frequency-Dependent Behaviour of Fiberglass/Epoxy Laminates in Tensile and Cyclic Loading”, Composites, 26 (1995) 719.

Rotem

, “Load Frequency Effect on the Fatigue Strength of Isotropic Laminates”, Compos. Sci. Technol., 46 (1993) 129.

Krempl

and Niu

T.M.

, “Graphite/Epoxy [±45]_s Tubes. Their Static Axial and Shear Properties and Their Fatigue Behavior under Completely Reversed Load Controlled Loading”, J. Compos. Mater., 16 (1982) 172.

Ward

I.M.

, “Mechanical Properties of Solid Polymers”, Second Edition, John Wiley & Sons, Reprinted with correction July (1990) Great Britain.

Ferry

J.D.

, “Viscoelastic Properties of Polymers” Wiley, New York (1980).

Arridge

R.G.C.

, “An Introduction to Polymer Mechanics”, Taylor & Francis, London and Philadelphia, (1985).

Aklonis

J.J.

and Macknight

W.J.

, “Introduction to Polymer Viscoelasticity”, John Wiley and Sons, (1983).

Scott

D.W.

, Lai

J.S.

and Zureik

A-H.

, “Creep Behavior of Fiber-Reinforced Polymeric Composites: a Review of the Technical Literature”, J. Reinforced Plastics and Composites, 14 (1995) 588.

Schapery

R.A.

and Sicking

D.L.

, “On Nonlinear Constitutive Equations for Elastic and Viscoelastic Composites with Growing Damage”, in: Mechanical Behaviour of Materials (ed. Bakker

), Delft University Press, Delft, The Netherlands, (1995) 45.

10.

Krausz

A.S.

and Krausz

, “Unified Constitutive Laws of Plastic Deformation”, Academic Press, United States of America, (1996).

11.

Findley

W.N.

, Lai

J.S.

and Onaran

, “Creep and Relaxation of Nonlinear Viscoelastic Materials with an Introduction to Linear Viscoelasticity”, Dover Publications, Inc., New York, (1989).

12.

Ellyin

, “Fatigue Damage, Crack Growth and Life Prediction” Chapman & Hall, London, (1997).

13.

Kinloch

A.J

and Young

R.J.

, “Fracture Behaviour of Polymers”, Applied Science Publishers, London and New York, (1983).

14.

Zienkiewicz

O.C.

, Watson

and King

I.P.

, “A Numerical Method of Visco-Elastic Stress Analysis”, Int. J. Mech. Sci., 10 (1968) 807.

15.

Asp

L.E.

, Berglud

L.A.

and Talreja

, “A Criterion for Crack Initiation in Glassy Polymers Subjected to a Composite-Like Stress State”, Composites Science and Technology, 56 (1996) 1291.