Degradation mechanism of automatic transmission fluid by water as a contaminant

Abstract

The degradation mechanism of water-contaminated automatic transmission fluids (ATF) was experimentally investigated. Water-contaminated ATF was tribotested in a full-scale wet clutch test rig to monitor the friction durability during clutch aging, and was also statically aged in oven to evaluate the interaction of ATF with water. The bulk properties and chemical nature of the ATF were analyzed using viscosity measurements, Fourier transform infrared spectroscopy and thermogravimetric analysis. It was shown that presence of water in the ATF can increase the mean friction coefficient over a short time period, though in the long-term perspective there is a higher loss of mean friction. Phase separation of the water-in-oil emulsion by centrifugation at 20,000 r/min made it possible to examine the water phase using infrared spectroscopy. The spectroscopic analysis revealed the hydrophilic nature of certain ATF constituents, although the impact of water on the bulk properties like lubricant viscosity and thermal stability was insignificant. The analysis of the tribotests showed that the friction increase for water contamination was a short-term effect and likely due to the interaction between polar surface active additives and water. Even though no significant change has been found for thermal degradation or in bulk properties of the lubricant, the initially changed action of the water soluble additives and generation of high friction resulted in a total deterioration of the clutch performance during long-term use.

Keywords

Wet clutch automatic transmission fluid friction lubricant degradation water contamination

Get full access to this article

View all access options for this article.

References

Zhao

Neville

Morina

. A new method to evaluate the overall anti-shudder property of automatic transmission fluids – Multiple parameters spider chart evaluation. Proc IMechE, Part J: J Engineering Tribology 2008; 222: 459–469.

Tohyama M, Ohmori T and Ueda F. Anti-shudder mechanism of ATF additives at slip-controlled lock-up clutch. SAE technical paper 1999-01-3616, 1999.

Ingram

Noles

Watts

. Frictional properties of automatic transmission fluids: Part II – Origins of friction-sliding speed behaviour. Tribol Trans 2011; 54(1): 154–167.

Ingram

Noles

Watts

. Frictional properties of automatic transmission fluids: Part II – Origins of friction-sliding speed behaviour. Tribol Trans 2011; 54(1): 145–153.

Eguchi

Yamamoto

. Shear characteristics of a boundary film for a paper based wet friction material: Friction and real contact area measurement. Tribol Int 2015; 38: 327–335.

Cameron TM, Tersigni SH, McCombs T, et al. ATF effects on friction stability in slip-controlled torque converter clutches. SAE technical paper 2003-01-3255, 2003.

Berglund

Marklund

Larsson

. Lubricant ageing effects on the friction characteristics of wet clutches. Proc IMechE, Part J: J Engineering Tribology 2010; 224(7): 639–647.

Lancaster

. A review of the influence of environmental humidity and water on friction, lubrication and wear. Tribol Int 1990; 23(6): 371–389.

Cen

Morina

Neville

. Effect of water on ZDDP anti-wear performance and related tribochemistry in lubricated steel/steel pure sliding contacts. Tribol Int 2012; 56: 47–57.

10.

Williamson W and Rhodes B. The effects of water on cellulose-based frictional surfaces in automatic transmission clutch plates. SAE Transactions 1996; 105(4): 1332–1339.

11.

Fatima

Marklund

Larsson

. Water contamination effect in wet clutch system. Proc IMechE, Part D: J Automobile Engineering 2012; 227: 376–389.

12.

Fatima N, Marklund P and Larsson R. Study on the wet clutch friction interfaces for humid lubrication condition. In: The 3rd international tribology symposium of IFToMM, Luleå, Sweden, 19–21 March 2013.

13.

Berglund K, Marklund P, Larsson R, et al. Wet clutch degradation monitored by lubricant analysis. SAE technical paper 2010-01-2232, 2010.

14.

Ompusunggu AP, Janssens T, Al-Bender F, et al. Contact stiffness characteristics of a paper-based wet clutch at different degradation levels. In: The 17th international colloquium tribology 2010 – Solving friction and wear problems, 2010, pp.150–163. http://www.fmtc.be/downloads/Monitoring%26Diagnostics/Contact_Stiffness_Characteristics_of_Paper-Based_Wet_Clutch.pdf (2010, accessed 3 April 2014).

15.

Fewkes R, Calcut B and Willis A. General motors DEXRON®-VI global service-fill specification. SAE technical paper 2006-01-3242, 2006.

16.

Guan J, Willermet P, Carter R, et al. Interaction between ATFs and friction material for modulated torque converter clutches. SAE technical paper 981098, 1998.

17.

Pavia

. Introduction to spectroscopy with techniques & experiments, 2nd edn. New York: Harcourt Brace College Publishers, 1996.

18.

Landry

Automatic transmission fluids. In: Rudnick

Shubkin

(eds). Synthetic lubricants and high-performance functional fluids, revised and expanded, 2nd edn. New York: Marcel Dekker, Inc., 1999, pp. 42–479.

19.

Colyer

Gergel

Detergents/dispersants. In: Mortier

Orszulik

(eds). Chemistry and technology of lubricants, 1st edn. New York: VCH Publishers, Inc., 1994, pp. 64–77.

20.

Crawford

Psaila

Miscellaneous additives. In: Mortier

Orszulik

(eds). Chemistry and technology of lubricants, 1st edn. New York: VCH Publishers Inc., 1994, pp. 161–163.

21.

Stuart

. Infrared spectroscopy: Fundamentals and applications, 1st edn. New York: Wiley, 2004, pp. 71–88.

22.

Puttnam

Baxter

. IR Spectroscopy of aqueous detergent solutions. J Soc Cosmet Chem 1966; 17: 391–400.