Theoretical and experimental investigation about dynamic characteristics of two-lobes misaligned pads hybrid foil magnetic bearings concerned active control
Restricted accessResearch articleFirst published online 2025
Theoretical and experimental investigation about dynamic characteristics of two-lobes misaligned pads hybrid foil magnetic bearings concerned active control
Hybrid foil magnetic bearing is a non-contact levitation bearing coupling with the active magnetic bearing (AMB) and gas foil bearing (GFB). Aiming at the question that GFB has obvious gas oscillation and lower stability, the two-lobe misaligned pads hybrid foil magnetic bearing (TLMP-HFMB) is proposed. Based on the N-S equation, Maxwell’s electromagnetic equation, and the equation of foil deformation, the theoretical model of dynamic characteristics about TLMP-HFMB is established and the effect of nominal clearance, static load, and loading sharing ratio on dynamic characteristics of TLMP-HFMB are calculated. The experimental platform of dynamic-load is set up and the effect of excitation amplitude, proportion gain, and difference gain on dynamic stiffness, dynamic damping, and loss factor of TLMP-HFMB are measured. The results show that the direct dynamic stiffness of TLMP-HFMB is higher than direct dynamic stiffness of GFB and AMB; the cross-coupled stiffness of TLMP-HFMB is lower than cross-coupled stiffness of GFB. The dynamic characteristics of TLMP-HFMB are decreasing with the increase of nominal clearance and loading sharing ratio, but the effect of rotational speed is just the opposite. The experimental results are in good agreement with the theoretical results; correctness of the proposed model is verified.
AhnHJPhamMN (2014) Experimental optimization of a hybrid foil–magnetic bearing to support a flexible rotor. Mechanical Systems and Signal Processing46(5): 361–372.
2.
BonfittoAGalluzziRMolinaLC (2021) Offset-free model predictive control for a cone-shaped active magnetic bearing system. Mechatronics78: 102612.
3.
CaoJCLiuTYZhangK, et al. (2024) A comprehensive analysis of gas fflm pressure distribution in gas foil thrust bearings with PVDF sensor array. Measurement237: 115153.
4.
ChenHMHeshmatHWaltonJFII (2000) On the performance of hybrid foil-magnetic bearings. Journal of Engineering for Gas Turbines & Power122(12): 73–82.
5.
ChengXDengSWuHC, et al. (2023a) Multi-objective optimization configuration of redundant electromagnetic actuators in fault-tolerant control of active magnetic bearing system. ISA Transactions140(5): 293–308.
6.
ChengMMFengKZhangH (2023b) Effect of equilibrium position offset on rotordynamics of a rigid rotor supported by hybrid foil magnetic bearings: numerical and experimental investigations. Mechanical Systems and Signal Processing205: 110848.
7.
ChengMMFengKZhangH, et al. (2023c) Investigations on the nonlinear dynamic characteristics of a rotor supported by hybrid foil magnetic bearings. Nonlinear Dynamics111: 14879–14899.
8.
ChengYJLiBZhangCB, et al. (2025) Bearing performances of gas dynamic bearing and friction/wear characteristics of elastic support structure in an oxygen-free atmosphere. Wear566-567: 205902.
9.
ChuJHWangJYWuSY, et al. (2025) Analysis of gas foil thrust bearing considering manufacturing errors: modeling and experiments. Mechanical Systems and Signal Processing232: 112698.
10.
DuJJLiCLZhaoXW, et al. (2025) Thermo-elasto-hydrodynamic analysis of gas foil bearings. International Journal of Mechanical Sciences287: 109940.
11.
FeiXYSunHYuN, et al. (2025) Rhombus-type magnetic-levitation structure for low-frequency vibration isolation. Mechanical Systems and Signal Processing225: 112289.
12.
FengKZhangH (2023) Experimental investigation on stiffness and damping characteristics of hybrid foil magnetic bearings. Journal of Vibration and Control30: 2939–2948.
13.
GaoQHSunWJZhangJZ, et al. (2025) Numerical assessment on a hybrid axial throughflow cooling scheme applied to the thermal management of bump-type gas foil bearings. Applied Thermal Engineering260: 125044.
14.
GengHPSunYHYangBS, et al. (2016) Dynamic characteristics of hybrid foil-magnetic bearings (HFMBs) concerning eccentricity effect. International Journal of Applied Electromagnetics and Mechanics52(8): 271–279.
15.
GuanHQYinQWZhangH, et al. (2021) Theoretical investigation of hybrid foil-magnetic bearings on operation mode and load sharing strategy. In: Proceedings of the Institution of Mechanical Engineers Part J-Journal of Engineering Tribology, 1–31.
16.
GuanHQLiJJWeiKX, et al. (2024) Rotordynamics of a rotor radially and axially supported by active bump-type foil bearings and bump-type thrust foil bearings. Mechanical Systems and Signal Processing208: 110995.
17.
HuttererMSchrödlM (2023) Modeling and mu-synthesis control of a flexible rotor stabilized by active magnetic bearings including current free control. Journal of Sound and Vibration546: 117439.
18.
JanaSSankarBSekharAS (2023) Estimation of magnetic bearing constant in active magnetic bearings. Mechanical Systems and Signal Processing198: 110411.
19.
JeonDYJeongSLeeYB (2016) Rigid mode vibration control and dynamic behavior of hybrid foil–magnetic bearing turbo blower. Journal of Engineering for Gas Turbines & Power139: 1–12.
20.
JinCZLiCLXuZN, et al. (2025) Creep behavior modeling of nickel-based superalloy foil structures in gas foil bearings. Thin-Walled Structures211: 113105.
21.
KeoghPSSaketFY (2023) Force-based feedforward control of persistent synchronous rotor/touchdown bearing contact in active magnetic bearing systems. Mechanical Systems and Signal Processing201: 110657.
22.
LiQHRenYLWangWM, et al. (2022) Impact factors on the rotor dynamic stability evaluation by the sine-sweep excitation with active magnetic bearing: numerical and experimental investigation. Journal of Sound and Vibration541: 117282.
23.
LiCLLiJZhaoXW, et al. (2025) A fully coupled model for tribo-dynamic performance analysis of gas foil bearing-rotor system during start-up. Mechanical Systems and Signal Processing232: 112699.
24.
LiebichRSarrazinM (2025) Experimental and theoretical analysis of the stability behaviour of a rigid rotor supported by conical gas foil bearings. Tribology International204: 110467.
25.
LiuZYWenTXiangB (2022) Vibration analysis, measurement and balancing of flywheel rotor suspended by active magnetic bearing. Measurement197: 111305.
26.
LuanWLWangHMWangYD, et al. (2024) The inffuence of spiral groove parameters on the performance of new hybrid gas foil spiral groove thrust bearings: experimental study. Mechanical Systems and Signal Processing221: 111752.
27.
LyuYWWangHWZhangJY, et al. (2025) Numerical investigation in characteristics of multi-layer thrust gas foil bearing based on fluid-structure coupling field. Chinese Journal of Aeronautics38: 103557.
28.
MajumderGTiwariR (2022) Application of active magnetic bearings in control and estimation of geared-rotor faults in high speed offset spur gear transmission system. Mechanical Systems and Signal Processing176: 109113.
29.
PiłatAKSikoraBM (2022) Analytical modeling and experimental validation of the six pole axial active magnetic bearing. Applied Mathematical Modelling104(3): 50–66.
30.
PiłatAKSikoraBM (2023) Interdisciplinary identification of the six-pole axial active magnetic bearing prototype. Mechatronics92: 102982.
31.
WangWYWuHCZhouJ, et al. (2022) Online unbalance compensation of a maglev rotor with two active magnetic bearings based on the LMS algorithm and the influence coefffcient method. Mechanical Systems and Signal Processing166: 108460.
32.
XuBYXuLXZhouJ (2024) Vibration suppression for a slice rotor supported by active magnetic bearings based on fractional-order adaptive back stepping control. Mechanical Systems and Signal Processing210: 111160.
33.
YanXSYangLZhangCA (2021) Multi-branch convolutional neural network with generalized shaft orbit for fault diagnosis of active magnetic bearing-rotor system. Measurement171: 108778.
