The polyunsaturated fatty acid methyl ester concentration in Prosopis juliflora biodiesel drops the cetane number and affects ignition quality. In this study, two fuel reformulation strategies, viz. partial hydrogenation and the inclusion of Di-tert-butyl peroxide (DTBP), are investigated for their ability to improve the combustion and performance of a diesel–biodiesel (B20) blend without compromising the emissions trade-off. An autoclave reactor utilizes partially hydrogenated juliflora biodiesel and gas chromatography to determine the altered fuel composition. The cetane improver is DTBP, which is mixed with B20 at a concentration of 2000 ppm. The filterability of the test fuel was evaluated using the Tamson filter blocking tendency apparatus. Engine parameters and emissions of the base diesel (D0), JB20, HJB20, and JB20 + DTBP test fuels were examined in a diesel engine. According to the FBT results, JB20 (1.36) and HJB20 (1.28) have good filterability, which is consistent with the ASTM standard (D2068-14). While comparing JB20 blend with modified JB20 fuels decreases NOx (up to 5.24%) and increases brake thermal efficiency (7.5%) at full load. Compared to diesel fuel, partially hydrogenated blend fuel emissions viz. HC, CO, and smoke were reduced by 15.24%, 7.76%, and 10.14%, respectively. Based on the above results, partial hydrogenation is more beneficial than the inclusion of DTBP in enhancing biodiesel's trade-off qualities.
MeiDGuoDChenZ,et al.Evaporation characteristics of N-tetradecane pendant droplets containing carbon nanotubes and cerium dioxide nanoparticles. Int J Green Energy [Internet]2023; 20: 52–62. Available from: https://www.tandfonline.com/doi/full/10.1080/15435075.2021.2023878
2.
EnnettaRSoyhanHSKoyunoğluC,et al.Current technologies and future trends for biodiesel production: a review. Arab J Sci Eng [Internet]2022; 47: 15133–15151. Available from:https://link.springer.com/10.1007/s13369-022-07121-9
AjalaOEAberuagbaFOdetoyeTE,et al.Biodiesel: sustainable energy replacement to petroleum-based diesel fuel – A review. ChemBioEng Rev [Internet]2015; 2: 145–156. Available from:https://onlinelibrary.wiley.com/doi/10.1002/cben.201400024
SaiBAVSLSubramaniapillaiNKhadhar MohamedMSB,et al.Optimization of continuous biodiesel production from rubber seed oil (RSO) using calcined eggshells as heterogeneous catalyst. J Environ Chem Eng [Internet]2020; 8: 103603. Available from:https://linkinghub.elsevier.com/retrieve/pii/S2213343719307262
7.
Aryasomayajula Venkata Satya LakshmSBSubramania PillaiNKhadhar MohamedMSB,et al.Biodiesel production from rubber seed oil using calcined eggshells impregnated with Al2O3 as heterogeneous catalyst: a comparative study of RSM and ANN optimization. Braz J Chem Eng [Internet]2020; 37: 351–368. Available from:http://link.springer.com/10.1007/s43153-020-00027-9
8.
SaiBAVSLNijuSMeeraBKM,et al.Optimization and modeling of biodiesel production using fluorite as a heterogeneous catalyst. Energy Sources, Part A Recover Util Environ Eff [Internet]2019; 41: 1862–1878. Available from:https://www.tandfonline.com/doi/full/10.1080/15567036.2018.1549165
9.
BharadwajAVSLSNijuSMeera Sheriffa BegumKM,et al.Performance and evaluation of calcined limestone as catalyst in biodiesel production from high viscous nonedible oil. Environ Prog Sustain Energy [Internet]2020; 39. Available from:https://onlinelibrary.wiley.com/doi/10.1002/ep.13342
10.
AsokanMASenthur PrabuSBadePKK, et al.Performance, combustion and emission characteristics of juliflora biodiesel fuelled DI diesel engine. Energy [Internet]2019; 173: 883–892. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0360544219302701
LeeYHuhKY. Analysis of different modes of low temperature combustion by ultra-high EGR and modulated kinetics in a heavy duty diesel engine. Appl Therm Eng [Internet]2014; 70: 776–787. Available from:https://linkinghub.elsevier.com/retrieve/pii/S1359431114004669
13.
Senthil KumarMJaikumarM. Studies on the effect of hydrogen induction on performance, emission and combustion behaviour of a WCO emulsion based dual fuel engine. Int J Hydrog Energy [Internet]2014; 39: 18440–18450. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0360319914024653
14.
VedaramanNPuhanSNagarajanG,et al.Preparation of palm oil biodiesel and effect of Various additives on NO x emission reduction in B20: an experimental study. Int J Green Energy [Internet]2011; 8: 383–397. Available from:http://www.tandfonline.com/doi/abs/10.1080/15435075.2011.557847
15.
WadumesthrigeKSalleySONgKYS. Effects of partial hydrogenation, epoxidation, and hydroxylation on the fuel properties of fatty acid methyl esters. Fuel Process Technol [Internet]2009; 90: 1292–1299. Available from:
16.
AlexandrinoCDMoraisSMOliveiraMSC, et al.Influence of hydrogenation and antioxidants on the stability of soybean oil biodiesels. Eur J Lipid Sci Technol [Internet]2013; 115: 709–715. Available from:https://onlinelibrary.wiley.com/doi/10.1002/ejlt.201200348
17.
ThunyaratchatanonCJitjamnongJLuengnaruemitchaiA, et al.Influence of Mg modifier on cis-trans selectivity in partial hydrogenation of biodiesel using different metal types. Appl Catal A Gen [Internet]2016; 520: 170–177. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0926860X16302034
18.
MathewBCThangarajaJSivaramakrishnaA. Combustion, performance and emission characteristics of blends of methyl esters and modified methyl esters of karanja and waste cooking oil on a turbocharged CRDI engine. Clean Technol Environ Policy [Internet]2019; 21: 1791–1807. Available from:http://link.springer.com/10.1007/s10098-019-01750-9
19.
McArdleSGirishSLeahyJJ,et al.Selective hydrogenation of sunflower oil over noble metal catalysts. J Mol Catal A Chem2011; 351: 179–187.
20.
NumwongNLuengnaruemitchaiAChollacoopN,et al.Effect of SiO2 pore size on partial hydrogenation of rapeseed oil-derived FAMEs. Appl Catal A Gen2012; 441–442: 72–78.
21.
KumarCBLataDB. Effect of di-tert butyl peroxide (DTBP) on combustion parameters and NOx in dual fuel diesel engine with hydrogen as a secondary fuel. Int J Hydrog Energy [Internet]2021; 46: 4507–4525.
22.
KumarCBLataDBMahtoD. Analysis of ignition delay by taking Di-tertiary-butyl peroxide as an additive in a dual fuel diesel engine using hydrogen as a secondary fuel. Int J Hydrog Energy [Internet]2020; 45: 14806–14820.
GotoSLeeD. SAE TECHNICAL Development of an LPG DI Diesel Engine using Cetane Number Enhancing Additives. 2018;(724).
25.
JoyNYuvarajanDBeemkumarN. Performance evaluation and emission characteristics of biodiesel-ignition enhancer blends propelled in a research diesel engine. Int J Green Energy [Internet]2019; 16: 277–283. Available from:https://www.tandfonline.com/doi/full/10.1080/15435075.2018.1561455
26.
ZhengZJoshiUHeneinN,et al.Effect of cetane improver on combustion and emission characteristics of coal-derived sasol isomerized paraffinic kerosene in a single cylinder diesel engine. J Eng Gas Turbines Power2015; 137(7): 071506.
27.
Örsİ. Experimental investigation of the cetane improver and bioethanol addition for the use of waste cooking oil biodiesel as an alternative fuel in diesel engines. J Braz Soc Mech Sci Eng2020; 42(4): 177.
28.
ChackoNJohnsonCVaradarajanP, et al.A comparative evaluation of cetane enhancing techniques for improving the smoke, NOx and BSFC trade-off in an automotive diesel engine. Fuel [Internet]2021; 289: 119918. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0016236120329148
29.
RajendranSGanesanPAnandkumarG. A comparative assessment on performance, combustion and emission characteristics of diesel engine fuelled by juliflora biodiesel-diesel blends. Aust J Mech Eng [Internet]2023; 21: 257–269. Available from:https://www.tandfonline.com/doi/full/10.1080/14484846.2020.1842294
30.
MusthafaMMKumarTAMohanrajT,et al.A comparative study on performance, combustion and emission characteristics of diesel engine fuelled by biodiesel blends with and without an additive. Fuel [Internet]2018; 225: 343–348. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0016236118305556
31.
AgarwalAKDharAGuptaJG, et al.Effect of fuel injection pressure and injection timing of Karanja biodiesel blends on fuel spray, engine performance, emissions and combustion characteristics. Energy Convers Manag [Internet]2015; 91: 302–314. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0196890414010334
32.
Senthur PrabuSAsokanMARoyR, et al.Performance, combustion and emission characteristics of diesel engine fuelled with waste cooking oil bio-diesel/diesel blends with additives. Energy [Internet]2017; 122: 638–648. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0360544217301263
33.
MathewBCThangarajaJSivaramakrishnaA. Combustion, performance and emission characteristics of blends of methyl esters and modified methyl esters of karanja and waste cooking oil on a turbocharged CRDI engine. Clean Technol Environ Policy [Internet]2019; 21: 1791–1807.
34.
SaravananBMusthafaBAsokanMA. A combined study of filterability and soaking strength of fuel filter and effect of injection timing on CI engine characteristics using Ceiba pentandra biodiesel. Biofuels [Internet]2023; 0: 1–9. Available from:https://doi.org/10.1080/17597269.2023.2167270
35.
PatelNKSinghRN. Optimization of NOx emission from soya biodiesel fuelled diesel engine using cetane improver (DTBP). Jordan J Mech Ind Eng2014; 8: 213–217.
36.
AsokanMASenthur prabuSKameshS,et al.Performance, combustion and emission characteristics of diesel engine fuelled with papaya and watermelon seed oil bio-diesel/diesel blends. Energy [Internet]2018; 145: 238–245. Available from:https://linkinghub.elsevier.com/retrieve/pii/S0360544217321837
37.
HeywoodJB. Internal combustion engine fundamentals. New York: McGraw-Hill, 1988. 491–547 p.
38.
JeyaseelanTChackoNNandimandalamP, et al.Partial hydrogenation and hydrogen induction: a comparative study with B20 operation in a turbocharged CRDI diesel engine. Int J Hydrog Energy [Internet]2021; 46: 22659–22669.
Supplementary Material
Please find the following supplemental material available below.
For Open Access articles published under a Creative Commons License, all supplemental material carries the same license as the article it is associated with.
For non-Open Access articles published, all supplemental material carries a non-exclusive license, and permission requests for re-use of supplemental material or any part of supplemental material shall be sent directly to the copyright owner as specified in the copyright notice associated with the article.
