Modelling,analysis and experimental study of the prop-rotor of vertical/short-take-off and landing aircraft

Abstract

The main objective of this work is to characterise the prop-rotor of V/STOL (Vertical/short-take-off and landing) aircraft in various operating conditions, especially in transition flight. To this end, a BET (Blade element theory) based analytic model/tool with a low computational cost has been built to predict the aerodynamic performance of the prop-rotor. This BET-based model can predict prop-rotor thrust, torque, normal force, and yaw moment as well as their corresponding 1P load (once-per-revolution load on the single blade) regarding oblique flow. This model is verified and shows good consistency with the wind tunnel experimental data and CFD simulation results. Furthermore, by using this BET model/tool, the effects of axial advance ratio, tilt angle and collective pitch angle on these component loads on the prop-rotor are explored. Moreover, the effects of these variables on the vibratory amplitudes of the 1P load on the single blade and 3P harmonic loads on the prop-rotor due to inclined flow are presented as well.

Keywords

proprotor aerodynamics simulation blade element momentum theory wind tunnel experiment 1P load 3P harmonic load short-take-off and landing/vertical/short-take-off and landing

Get full access to this article

View all access options for this article.

References

Bell XV-15 Tiltrotor | NASA . https://www.nasa.gov/centers/dryden/multimedia/imagegallery/XV-15/ECN-13850.html (accessed 29 August 2020).

Boeing: V-22 Osprey . https://www.boeing.com/defense/v-22-osprey/ (accessed 29 August 2020).

Bell V-280 - Search and rescue with revolutionary reach and capabilities . https://www.bellflight.com/products/bell-v-280 (accessed 29 August 2020).

Maisel

Giulianetti

Dugan

. The history of the XV-15 tilt rotor research aircraft: from concept to flight. Report. Washington DC, US: National Aeronautics and Space Administration, 2000.

Johnson

. Forward flight wake. In: Rotorcraft aeromechanics. Cambridge: Cambridge University Press, 2013, pp. 123–151.

Smith

. Engineering models of aircraft propellers at incidence. Phd Thesis. UK: University of Glasgow, 2015.

Freeman

. The effect of small angles of yaw and pitch.Report. Washington DC, US: National Advisory Committee For Aeronautics, 1931.

Yaggy

Rogallo

. A wind-tunnel investigation of three propellers through an angle-of-attack range from 0° to 85°. Report. Washington DC, US: National Advisory Committee For Aeronautics, 1960.

Kolaei

Barcelos

Bramesfeld

. Experimental analysis of a small-scale rotor at various inflow angles. Int J Aerosp Eng 2018; 2018: 1–14.

10.

Theys

Dimitriadis

Andrianne

, et al. Wind tunnel testing of tilted MAV propeller in tilted operating mode. In: International conference on unmanned aircraft systems, Orlando, US, 27-30 May 2014: 1064–1072.

11.

Zarev

Green

. Experimental investigation of the effect of yaw angle on the inflow of a two-bladed propeller. Aerosp Sci Technol 2020; 103: 105940.

12.

Stuermer

Rakowitz

. Unsteady simulation of a transport aircraft propeller using MEGAFLOW. DLR, Inst Aerodyn Flow Technol 2005; 1–14.

13.

Higgins

Zarev

Barakos

, et al. Numerical investigation of a two-bladed propeller inflow at yaw. J Aircr 2019; 57(2): 1–13. DOI: 10.2514/1.C035647.

14.

Glauert

. A general theory of the autogyro. Report. Washington DC, US: National Advisory Committee For Aeronautics, 1926.

15.

Ribner

. Propellers in yaw. Report. Washington DC, US: National Advisory Committee For Aeronautics, 1945.

16.

Crigler

Gilman

. Calculation of aerodynamic forces on a propeller in pitch or yaw. Report. Washington DC, US: National Advisory Committee For Aeronautics, 1952.

17.

Khan

Nahon

. A propeller model for general forward flight conditions. Int J Intell Unmanned Syst 2015; 3: 72–92.

18.

Theys

Dimitriadis

Hendrick

, et al. Experimental and numerical study of micro-aerial-vehicle propeller performance in oblique flow. J Aircr 2017; 54: 1076–1084.

19.

Pitt

Peters

. Theoretical prediction of dynamic-inflow derivatives. In: Sixth european rotorcraft and powered lift aircraft forum, Bristol, UK, 16-19 September 1980, paper no. 47, pp. 1–18.

20.

Chen

. A survey of nonuniform inflow models for rotorcraft flight dynamics and control applications. Report. Washington DC, US: National Aeronautics and Space Administration, 1989.

21.

Montgomerie

. Methods for root effects, tip effects and extending the angle of attack range to +- 180, with application to aerodynamics for blades on wind turbines and propellers. Report. Stockholm, Sweden: Swedish Defence Research Agency, 2004.

22.

Drela

. XFOIL 6.9 user primer. November 2001.

23.

Ashby

. Potential flow theory and operation guide for the panel code PMARC. Report. Washington DC, US: National Aeronautics and Space Administration, 1999.

24.

Drela

. XFOIL: an analysis and design system for low reynolds number airfoils. In: Lecture Notes in Engineering. Springer-Verlag Berlin Heidelberg, 1989, pp. 1–12.

25.

Dorfling

Rokhsaz

. Integration of airfoil stall and compressibility models into a propeller blade element model. J Aerosp Eng 2016; 29: 04016014.

26.

Marcus

. Aerodynamic modelling and performance analysis of over-the-wing propellers: a combined numerical and experimental study. MSc Thesis, Netherland; Delft University of Technology, 2018.

27.

Schmitz

Chattot

. Characterisation of three-dimensional effects for the rotating and parked NREL phase VI wind turbine. J Sol Energy Eng Trans ASME 2006; 128: 445–454.

28.

Herráez

Akay

van Bussel

GJW

, et al. Detailed analysis of the blade root flow of a horizontal axis wind turbine. Wind Energy Sci 2016; 1: 89–100.

29.

MathWorks . Decompose signals into time-aligned components - MATLAB - MathWorks https://ww2.mathworks.cn/help/wavelet/ref/signalmultiresolutionanalyser-app.html?requestedDomain=cn (accessed 6 August 2020).