Development of the active disturbance rejection control method for increasing the stability of the long articulated vehicle

Abstract

Today, with the increasing growth in road traffic, many countries are welcoming long articulated vehicles because of their economic and environmental benefits and the positive effects on the problem of traffic congestion and the reduction in fuel consumption and environmental pollutants. The major problem with such vehicles is poor maneuverability at low speeds and inappropriate lateral performance at high speeds, resulting in accidents and financial losses. Therefore, in order to improve their safety, they need a control system that can improve the performance of the long articulated vehicles. In this article, a 19-degree of freedom dynamic model of the long articulated vehicle has been developed in MATLAB software. This vehicle consists of a tractor and two semi-trailer units. To adjust the articulated vehicle lateral dynamics, a robust control method based on the combination of active disturbance rejection control and back-stepping sliding mode control is introduced. Four control variables such as yaw rate and lateral velocity of the tractor and also first and second articulation angles are regulated by steering the axles of the tractor and two trailers. Furthermore, in order to measure the state variables of the long articulated vehicle, the extended Kalman filter is used. The results of the simulation in high-speed lane change and low-speed steep steer maneuvers indicate the superiority of this method over linear-quadratic regulator and sliding mode controllers. Finally, the robustness of this controller than conventional sliding mode and active disturbance rejection sliding mode controllers have been shown in the presence of noises.

Keywords

Articulated vehicle lateral stability extended Kalman filter active disturbance rejection controller back-stepping sliding mode controller

Get full access to this article

View all access options for this article.

References

Sadeghi Kati

. Definitions of performance based characteristics for long heavy vehicle combinations. Göteborg: Chalmers University, 2013.

Moon

. Method for control of steering angles for articulated vehicles using virtual rigid axles. Int J Automot Technol 2009; 10: 441−449.

Lee

. The articulated vehicle dynamic analysis using the AWS (All Wheel Steering) ECU (Electronic Control Unit) test. J Mech Sci Technol 2009; 23: 923–926.

Islam

Webster

. An integrated design method for articulated heavy vehicles with active trailer steering systems. SAE Int J Passenger Cars-Mech Syst 2010; 3: 158–174.

Islam

Ding

. A closed-loop dynamic simulation-based design method for articulated heavy vehicles with active trailer steering systems. Vehicle Syst Dyn 2012; 50: 675–697.

Islam

. An automated design method for active trailer steering systems of articulated heavy vehicles. J Mech Design 2012; 134: 041002.

Ding

Mikaricand

. Design of an active trailer-steering system for multi-trailer articulated heavy vehicles using real-time simulations. Proc IMechE, Part D: J Automobile Engineering 2013; 227: 643–655.

Tabatabaei Oreh

Kazemi

. A new desired articulation angle for directional control of articulated vehicles. Proc IMechE, Part K: J Multi-body Dynamics 2012; 226: 23–36.

Odhams

Roebuck

Jujnovich

, et al. Active steering of a tractor-semi-trailer. Proc IMechE, Part D: J Automobile Engineering 2011; 225: 847–869.

10.

Jujnovich

Cebon

. Path-following steering control for articulated vehicles. Trans ASME 2013; 135: 1–19.

11.

Kharrazi

Lidberg

. A generic controller for improving lateral performance of heavy vehicle combinations. Proc IMechE, Part D: J Automobile Engineering 2013; 227: 619–642.

12.

Islam

. Parallel design optimization of multi trailer articulated heavy vehicles with active safety systems. PhD Thesis, 2013, https://ir.library.dc-uoit.ca/xmlui/handle/10155/309.

13.

Islam

. A comparative study of multi-trailer articulated heavy-vehicle models. Proc IMechE, Part D: J Automobile Engineering 2015; 229: 1200–1228.

14.

Pacejka

. Tyre and vehicle dynamics. Oxford: Butterworth-Heinemann, 2005.

15.

Zhu

. Active disturbance rejection sliding mode altitude and attitude control of a quadrotor with uncertainties. In: 2016 12th world congress on intelligent control and automation (WCICA), Guilin, China, 12–15 June 2016.

16.

Dou

Kong

. Altitude and attitude active disturbance rejection controller design of a quadrotor unmanned aerial vehicle. Proc IMechE, Part G: J Aerospace Engineering 2016; 231: 1732–1745.

17.

Merkel

Jones

Klimo

. Motion-based active disturbance rejection control for a non-linear full-car suspension system. Proc IMechE, Part D: J Automobile Engineering 2017; 232: 616–631.

18.

Lam

. Experimental investigation of active disturbance rejection control for vehicle suspension design. Int J Theoret Appl Mech 2016; 1: 89–96.

19.

Cheng

Jiao

. Modified active disturbance rejection control for non-linear semi-active vehicle suspension with magneto-rheological damper. Trans Inst Measure Control 2018; 40: 2611–2621.

20.

Cao

Zeng

. Nonlinear multiple-input-multiple output adaptive backstepping control of underwater glider systems. Int J Adv Robot Syst 2016; 13: 1–14.

21.

Song

Sun

. Adaptive backstepping sliding mode control with fuzzy monitoring strategy for a kind of mechanical system. ISA Trans 2014; 53: 125–133.

22.

Cao

Yao

. Nonlinear pitch control of an underwater glider based on adaptive backstepping approach. J Shanghai Jiaotong Univ 2015; 20: 729–734.

23.

Luijten

MFJ

. Lateral dynamic behaviour of articulated commercial vehicles. Master’s thesis, Eindhoven University of Technology, Eindhoven, August 2010.

24.

Ghaffari

Tabatabaei Oreh

Kazemi

, et al. An intelligent approach to the lateral forces usage in controlling the vehicle yaw rate. Asian J Control 2011; 13: 1–19.

25.

Tabatabaei Oreh

Kazemi

Azadi

. A sliding-mode controller for directional control of articulated heavy vehicles. Proc IMechE Part D: J Automobile Engineering 2013; 228: 245–262.

26.

Abe

Kato

Suzuki

. Estimation of vehicle side-slip angle for DYC by using on-board-tire-model. In: 4th international symposium on advanced vehicle control, Nagoya, Japan, 14–18 September 1998, pp. 437–442. Tokyo, Japan: JSAE.

27.

Ahmadi Jeyed

Ghaffari

. Nonlinear estimator design based on extended Kalman filter approach for state estimation of articulated heavy vehicle. Proc IMechE, Part K: J Multi-body Dynamics 2019; 233(2): 254–265. DOI: 10.1177/1464419318772173.

28.

Esmaeili

Kazemi

Tabatabaei Oreh

. An adaptive sliding mode controller for lateral control of articulated long vehicle. Proc IMechE, Part K: J Multi-body Dynamics 2019; 233(3); 487–515. DOI: 10.1177/1464419318806801.

29.

Ahmadi Jeyed

Ghaffari

. Development of a novel nonlinear estimator based on state-dependent Riccati equation technique for articulated vehicles. Proc IMechE Part K: J Multi-body Dynamics 2019; 233(3): 516–530. DOI: 10.1177/1464419318811254.