Handling and driving characteristics for six-wheeled vehicles

Abstract

Handling performance of six-wheeled special-purpose vehicles is investigated in this study. Six-wheel drive (6WD) vehicles are believed to have good performance in off-the-road manoeuvring and to have fail-safe capabilities when one or two of their tyres are blown. However, the handling performance of six-wheel steering (6WS) vehicles is not yet well understood in the relevant literature. In this paper, six-wheeled vehicles are modelled as an 18 degree-of-freedom (DOF) system that considers non-linear vehicle dynamics, tyre models and kinematic effects. The vehicle model is constructed into a simulation tool using MATLAB/SIMULINK so that input/output and vehicle parameters can be changed easily using the modulated approach. Handling performance is analysed not only from the frequency domain but also from the time domain. Simulation results demonstrate that the effect of middle-wheel steering is not negligible from the viewpoint of handling characteristics such as yaw rate, lateral acceleration, etc. The simulation tool is also utilized for the manoeuvring analysis over a rough rigid surface, where the separation between the wheels and the road can be considered. In addition, a new 6WS control law is proposed in order to minimize the sideslip angle. Lane change simulation results show the advantage of 6WS vehicles with the proposed control law.

Keywords

6WD 6WS handling off-the-road sideslip angle lane change

Get full access to this article

View all access options for this article.

References

Smith

D. E.

Starkey

J. M.

Effects of model complexity on the performance of automated vehicle steering controllers: Model development, validation and comparison. Veh. System Dynamics, 1995, 24, 163–181.

Nalecz

A. G.

Bindermann

A. C.

Investigation into the stability of four wheel steering vehicles. Int. J. Veh. Des., 1988, 9 (2) 159–178.

Dugoff

Fancher

P. S.

Segel

An analysis of tire traction properties and their influence on vehicle dynamic performance. SAE paper 700377, 1970.

Allen

R. W.

Rosenthal

T. J.

Szostak

H. T.

Steady state and transient analysis of ground vehicle handling. SAE paper 870495, 1987.

Bakker

Pacejka

H. B.

Lidner

A new tire model with an application in vehicle dynamics studies. SAE paper 890087, 1989.

Metz

L. D.

Dynamics of four-wheel-steer off-highway vehicles. SAE paper 930765, 1993.

Xia

Law

E. H.

Nonlinear analysis of closed-loop driver/automobile performance with four wheel steering control. SAE paper 920055, 1992.

Abe

Handling characteristics of four wheel active steering vehicles over full maneuvering range of lateral and longitudinal accelerations. In Proceedings of 11th IAVSD Symposium on Vehicle System Dynamics, 1989, Vol. 18, pp. 1–14.

Pillar

D. R.

Braun

E. E.

All-wheel steering system for heavy truck application. SAE paper 952680, 1995.

10.

Das

N. S.

Suresh

B. A.

Wambold

J. C.

Estimation of dynamic rollover threshold of commercial vehicles using low speed experimental data. SAE paper 932949, 1993.

11.

Hata

Osanai

Hasegawa

Takahashi

Watanabe

An investigation into vehicle controllability and stability of an experimental medium-duty truck with rear-axle steering. AVEC, 1992, 923044, 239–244.

12.

Ogorkiewicz

R. M.

Design and Development of Fighting Vehicles, 1968, pp. 172–193 (Macdonald Company Limited).