The paper proposes a novel dual-redundancy motor pump for the electro-hydrostatic actuator. Rather than the traditional single motor pump electro-hydrostatic actuator system, the system proposed in this paper can operate in three working modes and automatically adjust its operating condition in accordance with task requirements. The novel dual-redundancy electro-hydrostatic actuator system prototype was developed, and a high-performance control method was proposed and applied to the system, combining proportional–integral–derivative and sliding mode control to study the control strategy and implementation method of double closed loop. In addition, a physical model simulation was conducted on the basis of Amesim for this electro-hydrostatic actuator under several working conditions. Results showed that the dual-redundancy electro-hydrostatic actuator can decrease power loss and demonstrate excellent performance and reliability.
NavathaABelladKHiremathSS, et al.Dynamic analysis of electro hydrostatic actuation system. Procedia Technol2016; 25: 1289–1296.
2.
HabibiSRSinghG. Derivation of design requirements for optimization of a high performance hydrostatic actuation system. Int J Fluid Power2000; 1: 11–27.
3.
SakainoSTsujiT. Resonance suppression of electro-hydrostatic actuator by full state feedback controller using load-side information and relative velocity. IFAC PapersOnLine2017; 50: 12065–12070.
4.
ZhangJChaoQXuB. Analysis of cylinder block tilting inertia moment and its effect on the performance of high-speed electro-hydrostatic actuator pump of aircraft. Chinese J Aeronaut2018; 31: 169–177.
5.
ChaoQZhangJXuB, et al.A review of high-speed electro-hydrostatic actuator pumps in aerospace applications: challenges and solutions. ASME J Mech Des2019; 141: 050801-050801–13.
6.
SakumaTTsudaKUmedaK, et al.Modeling and resonance suppression control for electro-hydrostatic actuator as a two-mass resonant system. Adv Robot2018; 32: 1–11.
7.
RehmanWUWangSPWangXJ, et al.Motion synchronization in a dual redundant HA EHA system by using a hybrid integrated intelligent control design. Chinese J Aeronaut2016; 29: 789–798.
8.
TianYPlummerAIravaniP, et al.Testing an electrohydrostatic powered ankle prosthesis with transtibial and transfemoral amputees. IFAC PapersOnLine2016; 49–21: 185–191.
9.
TriNMNamDNCParkHG, et al.Trajectory control of an electro hydraulic actuator using an iterative backstepping control scheme. Mechatronics2015; 29: 96–102.
10.
AltareGVaccaA. A design solution for efficient and compact electro-hydraulic actuators. Procedia Eng2015; 106: 8–16.
11.
MacalusoaAJacazioG. Prognostic and health management system for fly-by-wire electro-hydraulic servo actuators for detection and tracking of actuator faults. Procedia CIRP2017; 59: 116–121.
12.
GuoQSunPYinJ-m, et al.Parametric adaptive estimation and backstepping control of electro-hydraulic actuator with decayed memory filter. ISA Trans2016; 62: 202–214.
13.
MengFShiPKarimiHR, et al.Optimal design of an electro-hydraulic valve for heavy-duty vehicle clutch actuator with certain constraints. Mech Syst Signal Process2016; 68–69: 491–503.
14.
GuoKWeiJHFangJH, et al.Position tracking control of electro-hydraulic single-rod actuator based on an extended disturbance observer. Mechatronics2015; 27: 47–56.
15.
AlfayadSOuezdouaFBNamounF, et al.High performance integrated electro-hydraulic actuator for robotics. Part II Theoretical modelling, simulation, control comparison with real measurements. Sensors Actuat A2011; 169: 124–132.
16.
LeeSYChoHS. A fuzzy controller for an electro-hydraulic fin actuator using phase plane method. Control Eng Pract2003; 11: 697–708.
17.
NiksefatNSepehriN. Design and experimental evaluation of a robust force controller for an electro-hydraulic actuator via quantitative feedback theory. Control Eng Pract2000; 8: 1335–1345.
18.
AliSAChristenABeggS, et al.Continuous–discrete time-observer design for state and disturbance estimation of electro-hydraulic actuator systems. IEEE Trans Ind Electron2016; 63: 4314–4324.
19.
KimWHShinDHWonDH, et al.Disturbance-observer-based position tracking controller in the presence of biased sinusoidal disturbance for electrohydraulic actuators. IEEE Trans Control Syst Technol2013; 21: 2290–2298.
20.
ZhouHLaoLMChenYL, et al.Discrete-time sliding mode control with an input filter for an electro-hydraulic actuator. IET Control Theory Appl2017; 11: 1333–1340.
21.
KimHGLeeJWChoiYH, et al.Simulations and experiments on the force control of hydraulic servo system for hydraulic robots. Appl Mech Mater2016; 826: 128–133.
22.
Kaminaga H, Amari T, Katayama Y, et al. Backdrivability analysis of electro-hydrostatic actuator and series dissipative actuation model. In: Proceedings of 2010 IEEE international conference on robotics and automation (ICRA), 2010, pp.4204–4211. Anchorage: IEEE.
23.
KircanskiNMGoldenbergAA. An experimental study of nonlinear stiffness, hysteresis, and friction effects in robot joints with harmonic drives and torque sensors. Int J Robot Res1997; 16: 214–239.
24.
Frischemeier S. Electrohydrostatic actuators for aircraft primary flight control-types, modelling and evaluation. In: Proceedings of the fifth Scandinavian international conference on fluid power, Linköping, Sweden, 1997, pp.1–16.
25.
OhJYJungGHLeeGH, et al.Modeling and characteristics analysis of single-rod hydraulic system using electro-hydrostatic actuator. Int J Precis Eng Manuf2012; 13: 1445–1451.
26.
YunhuaLZhanlinW. Development of airborne intelligent power supply system. J Beijing Univ Aeronaut Astronaut2004; 30: 493–497.
27.
Yonglin L, Xingbin S, Haojun X, et al. Thermal-hydraulic modeling and simulation of high power hydro-motor. In: Asia Simulation Conference - 7th international conference on system simulation and scientific computing, 2008, pp.841–844.
28.
GuanCPanS. Nonlinear adaptive robust control of single-rod electro-hydraulic actuator with unknown nonlinear parameters. IEEE Trans Control Syst Technol2008; 16: 434–445.
29.
Navarro R. Performance of an electro-hydrostatic actuator on the F-18 systems research aircraft. Report No. NASA/TM-97-206224, 1997.
30.
Bildstein M. EHA for flight testing on Airbus A321 power losses of fix pump EHA versus variable pump EHA. In: Proceedings of the international conference on recent advances in aerospace hydraulics, Toulouse, France, 24-26 November 1998, pp.101–103.
31.
Olsson H. Power losses in an axial piston pump used in industrial hydrostatic transmissions. In: Proceedings of the 8th Scandinavian international conference on fluid power, Tampere, Finland, 7–9 May 2003, pp.491–505.
32.
GongGHHeldweinMLDrofenikU, et al.Comparative evaluation of three-phase high-power-factor AC-DC converter concepts for application in future more electric aircraft. IEEE Trans Ind Electron2005; 52: 727–737.
33.
AhnKKNamDNCJinM. Adaptive backstepping control of an electrohydraulic actuator. IEEE/ASME Trans Mechatron2014; 19: 987–995.
34.
TriNMNamDNCParkHG, et al.Trajectory control of an electro hydraulic actuator using an iterative backstepping control scheme. Mechatronics2014; 29: 96–102.
35.
Lafage R and Aubry S. The clean sky technology evaluator: review and results of the environmental impact assessment at mission level. In: 16th AIAA aviation technology, integration, and operations conference, 13–17 June 2016. Reston: AIAA.
36.
SunWCPanHHGaoHJ. Filter-based adaptive vibration control for active vehicle suspensions with electrohydraulic actuators. IEEE Trans Veh Technol2016; 65: 4619–4626.
37.
ChaplinRPSLeeAJCHooperRM, et al.The mechanical properties of recovered PMMA bone cement: a preliminary study. J Mater Sci Mater Med2006; 17: 1433–1448.
38.
YaoJJiaoZHanS. Friction compensation for low velocity control of hydraulic flight motion simulator: a simple adaptive robust approach. Chinese J Aeronaut2013; 26: 822–841.
39.
ZhuWHPiedboeufJC. Adaptive output force tracking control of hydraulic cylinders with applications to robot manipulators. ASME J Dyn Syst Meas Control2005; 127: 206–217.
40.
LinYShiYBurtonR. Modeling and robust discrete-time sliding-mode control design for a fluid power electrohydraulic actuator (EHA) system. IEEE Trans Mechatron2013; 18: 1–10.
41.
RitelliGFVaccaA. Energetic and dynamic impact of counterbalance valves in fluid power machines. Energy Convers Manage2013; 76: 701–711.
42.
Mornacchi A, Vachtsevanos G and Jacazio G. Prognostics and health management of an electro-hydraulic servo actuator. In: Proceedings of the annual conference of the Prognostics and Health Management Society, Coronado, California, 18-24 October 2015, pp.1–17.
43.
KargovAWernerTPylatiukC, et al.Development of a miniaturised hydraulic actuation system for artificial hands. Sensors Actuat A2008; 141: 548–557.
44.
DeCarloRAZakSHMatthewsGP. Variable structure control of nonlinear multivariable systems: a tutorial. Proc IEEE1988; 76: 212–232. .
Supplementary Material
Please find the following supplemental material available below.
For Open Access articles published under a Creative Commons License, all supplemental material carries the same license as the article it is associated with.
For non-Open Access articles published, all supplemental material carries a non-exclusive license, and permission requests for re-use of supplemental material or any part of supplemental material shall be sent directly to the copyright owner as specified in the copyright notice associated with the article.
