Thermo-stress coupling field of friction lining during high-speed slide of wire rope in a mine friction-drive hoist

Abstract

In order to seek the intrinsic reason for the serious high-speed slide accident in a mine hoist, the thermo-stress coupling field of friction lining was studied during the high-speed slide. First, the helical contact characteristics were analysed. Subsequently, the thermomechanical properties and the dynamic coefficient of linear expansion were studied, and the thermomechanical constitutive relation was obtained. Then, the theoretical model of thermo-stress was established with the consideration of the helical contact characteristics and the thermomechanical constitutive relation. Also, the numerical simulation was performed by the finite element analysis. Finally, the experiment was carried out on a friction tester. It is found that the temperature is the highest at the contact zone II and the friction heat focuses on the contact surface layer. The variation frequency of the stress is 6.98 Hz at 0.5 m/s. Besides, the catastrophe for the strain and coefficient of friction occurs at 3 m/s. The thermo-stress concentration occurs at contact zone II. The experiment results agree with the simulation ones, which validates the theoretical model of thermo-stress.

Keywords

Friction lining thermo-stress thermomechanical relation wire rope mine hoist

Get full access to this article

View all access options for this article.

References

Peng YX. Thermo-stress coupling behavior of lining during sliding in friction hoist. PhD Dissertation, China University of Mining and Technology, 2009, pp. 1–2.

. and Xia RH. Research on the measuring condition for friction coefficient of lining in a friction hoist. Coal Sci Technol 1992; 6: 43–48.

. Friction coefficients between the steel rope and polymer lining in frictional hoisting. Wear 1992; 152(1): 21–29.

Peng

Zhu

Chen

. Dynamic mechanical properties of polymer-lining and their effect on coefficient of friction. Proc Inst Mech Eng Part J J Eng Tribol 2009; 223(7): 1067–1072.

Peng

Zhu

Chen

. Effect of tension on friction coefficient between lining and wire rope with low speed sliding. J. China Univ Min Technol 2007; 17(3): 409–413.

Zhu

Chen

. Influence of wire rope’s lay direction on the tribological properties of friction linings. J China Univ Min Technol 2008; 37(5): 690–693.

Wan

Ding

. Experimental investigation of multirope friction hoist lining hardness effect on friction coefficient. Coal Mine Mach 2008; 29(8): 31–33.

Xia

. Calculation of temperature rise of lining of friction winder. J. China Coal Soc 1990; 15(2): 1–9.

Liu

Mei

. Approximate method of calculating friction temperature in friction winder lining. J China Univ Min Technol 1997; 26(1): 70–72.

10.

Peng

Zhu

Chen

. Numerical simulation of lining’s transient temperature field during sliding of friction hoist’s sliding. J China Univ Min Technol 2008; 37(4): 526–531.

11.

Singh

Saxena

. Temperature dependence of effective thermal conductivity and effective thermal diffusivity of Se₉₀In₁₀ bulk chalcogenide glass. Curr Appl Phys 2008; 8(2): 159–162.

12.

Isoda

Kawashima

. Temperature dependence of thermal property for lead nitrate crystal. J Phys Chem Solids 2007; 68(4): 561–563.

13.

Hegeman

JBJ

Van der Laan

Van Kranenburg

. Mechanical and thermal properties of SiC_f/SiC composites irradiated with neutrons at high temperatures. Fusion Eng Des 2005; 75–79: 789–793.

14.

Peng

Zhu

Chen

. Dynamic thermophysical properties of friction lining and their effect on transient temperature field. J Cent South Univ 2009; 40(2): 436–440.

15.

Peng YX, Zhu ZC, Chen GA, et al. Numerical analysis of friction lining’s temperature field during helically sliding contact with wire rope. In: Proceedings of the second international joint conference on computational sciences and optimization, Sanya, China, 24–26 April 2009, pp. 237–241. Los Alamitos, CA: IEEE Computer Society Conference Publishing Services.

16.

Peng YX, Zhu ZC, Chen GA, et al. Theoretical analysis of sliding friction contact between friction lining and wire rope. In: Proceedings of the 2009 international conference on mechanical and electrical technology, Beijing, China, 8–11 August 2009, pp.165–170. New York: ASME Press.

17.

Peng YX, Zhu ZC, Chen GA, et al. Thermoviscoelastic constitutive model of friction lining in mining hoist. In: Proceedings of the second international joint conference on computational sciences and optimization, Sanya, China, 24–26 April 2009, pp. 283–285. Los Alamitos, CA: IEEE Computer Society Conference Publishing Services.

18.

Peng

Zhu

Chen

. Theoretical analysis of thermoviscoelastic contact between friction lining and wire rope in mine friction hoists. Min Sci Technol 2009; 19(4): 518–521.

19.

Deng

Hou

. Temperature-dependent elastic moduli of epoxies measured by DMA and their correlations to mechanical testing data. Polym Test 2007; 26(6): 803–813.

20.

Ebert

Hufenbach

Langkamp

. Modelling of strain rate dependent deformation behavior of polypropylene. Polym Test 2011; 30(2): 183–187.

21.

Johnson

Chen

. Approximating thermo-viscoelastic heating of largely strained solid rubber components. Comput Meth Appl Mech Eng 2005; 194(2–5): 313–325.

22.

Editorial Committee of Mine Safety Handbooks. Safety regulations for coal mine. Beijing: China Coal Industry Publishing House, 2004.

23.

Suetin

. Chebyshev polynomials. In: Hazewinkel

(ed.) Encyclopaedia of Mathematics. New York: Springer, 2001.

24.

Bhushan

. Introduction to tribology. Beijing: China Machine Press, 2007, pp. 60–61.

25.

Goryacheva

. Contact mechanics in tribology. Dordrecht: Kluwer Academic Publishers, 1998, pp. 73–77.

26.

Peng YX, Zhu ZC, Chen GA, et al. The measuring method and device for the sliding friction temperature and strain between lining and wire rope, China, 201010121802.X.