Performance of a variety of low Reynolds number turbulence models applied to mixed convection heat transfer to air flowing upwards in a vertical tube

Abstract

The study reported here is concerned with mixed convection heat transfer to air flowing upwards in a vertical tube. Computational simulations of experiments from a recent investigation have been performed using an ‘in-house’ code which was written specifically for variable-property, developing, buoyancy-influenced flow and heat transfer in a vertical passage. The code incorporates a selection of two-equation, low Reynolds number turbulence models. The objective of the study was to evaluate the models in terms of their capability of reproducing the effects on turbulent heat transfer of non-uniformity of fluid properties and buoyancy. Direct comparisons have been made between results from the experimental investigation and those obtained by computational modelling for a range of conditions. The trends of impairment and enhancement of heat transfer owing to the influence of buoyancy found in the experiments were captured to some extent in the simulations using each of the models. However, none reproduced observed behaviour correctly over the entire range of buoyancy influence.

Keywords

low Reynolds number turbulence models mixed convection heat transfer vertical tube flow simulations thermal systems

Get full access to this article

View all access options for this article.

References

Hall

W. B.

Jackson

J. D.

Laminarization of a turbulent pipe flow by buoyancy. ASME paper 69-HT-55, 1969.

Jackson

J. D.

Hall

W. B.

Influences of buoyancy on heat transfer to fluids flowing in vertical tubes under turbulent conditions. In Advanced Study Institute Book: Turbulent Forced Convection in Channels and Rod Bun-dles-Theory and Applications to Heat Exchangers and Reactors (Eds Kakac

Spalding

D. B.

), 1979, Vol. 2, pp. 613–640 (Hemisphere, Washington DC).

Jackson

J. D.

Buoyancy-influenced variable property turbulent heat transfer to air flowing in a uniformly heated vertical tube. Presented at the 2nd EF Conference on Turbulent Heat Transfer, Manchester, 1998.

Jackson

J. D.

The influence of thermal boundary conditions on mixed convection heat transfer in vertical tubes. Invited Lecture, published in the Proceedings of the 3rd Baltic Heat Transfer Conference on Progress in Engineering Heat Transfer, Sopot, Poland, 1999, pp. 197–207.

Tanaka

Tsuge

Hirata

Nishiwaki

Effects of buoyancy and of acceleration owing to thermal expansion on turbulent forced convection in vertical tubes criteria of the effects, velocity and temperature profiles and reverse transition from turbulent to laminar flow. Int. J. Heat and Mass Transfer, 1973, 16, 1267–1288.

Axcell

B. P.

The effect of buoyancy on turbulent forced convection. PhD thesis, The University of Manchester, 1975.

Axcell

B. P.

Hall

W. B.

Mixed convection to air in a vertical pipe. In Proceedings of the 6th International Heat Transfer Conference, Toronto, 1978, Vol. 1, pp. 37–42 (Hemisphere, Washington DC).

Walklate

P. L.

A comparative study of theoretical models of turbulence for the numerical prediction of boundary layer flows. PhD thesis, UMIST, 1976.

Carr

A. D.

Connor

M. A.

Buhr

H. O.

Velocity, temperature and turbulence measurements in air pipe flow with combined free and forced convection. Trans. ASME. J. Heat Transfer, 1973, 95, 445–452.

10.

Jones

W. P.

Launder

B. E.

The prediction of laminarization with a two-equation model of turbulence. Int. J. Heat and Mass Transfer, 1972, 15, 301–314.

11.

Cotton

M. A.

Theoretical studies of mixed convection in vertical tubes. PhD thesis, The University of Manchester, 1987.

12.

Cotton

M. A.

Jackson

J. D.

Vertical tube air flows in the turbulent mixed convection regime calculated using a low-Reynolds number Î°-Ïμ model. Int. J. Heat and Mass Transfer, 1990, 33, 275–286.

13.

Launder

B. E.

Sharma

B. L.

Application of the energy-dissipation of turbulence to calculation of flow near a spinning disc. Lett. Heat and Mass Transfer, 1974, 1, 131–138.

14.

Steiner

A. A.

On the reverse transition of turbulent flow under the action of buoyancy forces. J. Fluid Mechanics, 1971, 47, 71–75.

15.

L. S. L.

A computational study of turbulent mixed convection in vertical tubes. PhD thesis, The University of Manchester, 1991.

16.

Mikielewicz

D. P.

Comparative studies of turbulence models under conditions of mixed convection with variable properties in heated vertical tubes. PhD thesis, The University of Manchester, 1995.

17.

Petukhov

B. S.

Kurganov

V. A.

Gladuntsov

A. I.

Turbulent heat transfer in tubes to gases with variable physical properties. Heat and Mass Transfer, 1972, 1, 117–127.

18.

Lam

C. K. G.

Bremhorst

A modified form of the Î°-Ïμ model for predicting wall turbulence. Trans. ASME, 1981, 103, 456–460.

19.

Chien

K. Y.

Predictions of channel and boundary-layer flows with a low-Reynolds number turbulence model. Am. Inst. Aeronaut. Astronaut. J., 1982, 20, 33–38.

20.

Myong

H. K.

Kasagi

A new approach to the improvement of Î°-Ïμ turbulence model for wall bounded shear flows. Jap. Soc. Mech. Engrs Int. J., 1990, 33, 63–72.

21.

Yang

Shih

T. H.

New time scale based Î°-Ïμ model for near-wall turbulence. Am. Inst. Aeronaut. Astronaut. J., 1993, 31, 1191–1198.

22.

Abe

Kondoh

Nagano

A new turbulence model for predicting fluid flow and heat transfer in separating and reattaching flow. Int. J. Heat and Mass Transfer, 1994, 37, 139–151.

23.

Wilcox

D. C.

Reassessment of the scale determining equation for advanced turbulence models. Am. Inst. Aeronaut. Astronaut. J., 1988, 26, 1299–1310.