The contribution of extreme ultraviolet (EUV) and vacuum ultraviolet (VUV) from a laser-sustained plasma on mass loss phenomenon of fluorinated polymer in the ground-based laser-detonation atomic oxygen (AO) beam source was evaluated. The AO beam and EUV/VUV from an oxygen plasma were separated by a high-speed chopper wheel installed in the beam source. Mass changes of fluorinated polymer and polyimide were measured from the frequency shift of the quartz crystal microbalances during the beam exposures. It has been made clear that the fluorinated polymer is eroded by EUV/VUV exposure alone. In contrast, no erosion was detected for polyimide by EUV/VUV alone. The AO-induced erosion was measured for both materials even without EUV/VUV exposure. However, no strong synergistic effect was observed for the fluorinated polymer even under the simultaneous exposure condition of AO and EUV/VUV. Similar results were observed even in the simultaneous exposure condition of AO (without EUV/VUV from the laser plasma) and VUV from the 172 nm excimer lamp and D2 lamp. These experimental results suggest that the primary origin of the accelerated erosion of fluorinated polymer observed in the laser detonation AO source is not EUV/VUV from the laser-sustained plasma.
Weihs, B. and van Eesbeek, M. ( 1994). Secondary VUV Erosion Effect on Polymers in the ATOX Atomic Oxygen Exposure Facility, Proceedings of 6th International Symposium on Materials in a Space Environment, ESA SP-368 , ESA, Noordwijk, The Netherlands: 277-283.
2.
Shepp, A., Haghighat, R., Lennhoff, J., Schuler, P., Connell, J., St. Clair, T., Vaughn, J. and, Swiener, J. ( 1999). TOR and COR AO-VUV Resistant Polymers for Space, In Kleiman J.I. and Tennyson R.C. (eds), Protection of Materials and Structures from the Low Earth Orbit Space Environment, Kluwer Academic Publisher, Dordrecht: 235-254.
3.
van Eesbeek, M., Levadou, F., Skurat, V.E., Dorofeev, Y.I., Vasilets, V.N. and Babashev, E.A. (1994). Degradation of Teflon FEP due to VUV and Atomic Oxygen Exposure, Proceedings of 6th International Symposium on Materials in a Space Environment, ESA SP-368 , ESA, Noordwijk, The Netherlands: 165- 173.
4.
Skurat, V.E., Samsonov, P.V. and Nikiforov, A.P. ( 2006). Vacuum Ultraviolet Radiation in Sources of Hyperthermal Atomic Oxygen. Photodestruction of Polytetrafluoroethylene (PTFE) and Teflon FEO for Indication of Radiation, High Perform. Polym., 16: 339-355.
5.
Grossman, E., Gouzman, I., Lempert, G., Noter, Y. and Lifshitz, Y. ( 2004). Assessment of Atomic-oxygen Flux in Low-earth-orbit Ground Simulation Facilities, J. Spacecraft Rockets, 41: 356-359.
6.
Minton, T.K., Zhang, J., Garton, D.J. and Seale, J.W. ( 2000). Collision-assisted Erosion of Hydrocarbon Polymers in Atomic-oxygen Environments, High Perform. Polym., 12: 27-42.
7.
Scoles, G.,Bassi, D.,Buck, U. and Laine, D. (eds) (1988). Atomic and Molecular Beam Methods, Volume 1, Oxford University Press, New York.
8.
Zhang, J., Garton, D.J. and Minton, T.K. ( 2002). Reactive and Inelastic Scattering Dynamics of Hyperthermal Oxygen Atoms on a Saturated Hydrocarbon Surface, J. Chem. Phys., 117: 6239-6251.
9.
Garton, D.J., Minton, T.K., Alagia, M., Balucani, N., Casavecchia, P. and Gualberto Volpi, G.G. ( 2000). Comparative Dynamics of Cl.2P. and O.3P. Interactions with a Hydrocarbon Surface, J. Chem. Phys., 112: 5975-5984.
10.
Yokota, K. , Ohnae, N. and Tagawa, M. (2004). Effect of Relative Intensity of 5 eV Atomic Oxygen and 172 nm Vacuum Ultraviolet in the Synergism of Polyimide Erosion, High Perform. Polym., 16: 221-234.
11.
Caledonia, G.E., Krech, R.H.and Green, D.B. (1987). A High Flux Source of Energetic Oxygen Atoms for Material Degradation Studies, AIAA Journal, 25: 59-63.
12.
Okamoto, A. and Matsunaga, S. ( 2004). The Modification of Fluorocarbon Resin Composite Thin Film by Plasma Assist Film Formation Method, Book of Abstracts the 45th Vacuum Conference, 72 (in Japanese).
13.
Anderson, J.B. (ed,) (1994 ). Natural Orbital Environment Guidelines for Use in Aerospace Vehicle Development, NASA-TM 4527, NASA, Washington D.C.
14.
Yokota, K. , Tagawa, M. and Ohnae, N. (2002). Impingement Angle Dependence of Erosion Rate of Polyimide in Atomic Oxygen Exposures, J. Spacecraft Rockets, 39: 155-156.
15.
Koontz, S. , Leger, L., Albyn, K. and Cross, J., (1990). Vacuum Ultraviolet Radiation/Atomic Oxygen Synergism in Materials Reactivity, J. Spacecraft Rockets , 27: 346-348.
16.
Grossman, E., Noter, Y. and Lifshitz, Y. ( 1997). Oxygen and VUV Interaction of Polymers: Degradation Mechanism and Synergistic Process, Proceedings of the 7th International Symposium on Materials in a Space Environment, ESA SP-399, ESA, Noordwijk, The Netherlands: 217-224.
17.
Grossman, E. and Gouzman, I., (1997). Space Environmental Effects on Polymers in Low Earth Orbit, Nucl. Instrum. Methods Phys. Res. B: Beam Interact. Mater. Atoms, 208: 48-57.
18.
Zhang, J., Lindholm, N.F., Brunsvold, A.L., Upadhyaya, H.D. and Minton, T.K., (2008). Studies of the Individual and Combined Effects of VUV and Hyperthermal O or Ar Atoms on FEP and PMMA surfaces, Proceedings of the 9th International Conference, Protection of Materials from Space Environment, AIP Conference Proceedings 1087, AIP, N.Y.: 170-184.
19.
Zhang, J. , Lindholm, N.F., Brunsvold, A.L., Upadhyaya, H.D., Monton, T.K. and Tagawa, M., (2009). Erosion of FEP Teflon and PMMA by VUV Radiation and Hyperthermal O or Ar Atoms, ACS Applied Materials and Interfaces, 1: 653-660.
20.
de Groh, K.K., Banks, B.A., McCarthy, C.E., Rucker, R.N., Roberts, L.M. and Berger, L.A., (2008). MISSE 2 PEACE Polymers Atomic Oxygen Erosion Experiment on the International Space Station, High Perform. Polym., 20: 388-409.
21.
Garton D.J. , Minton T.K., Maiti B., Troya D. and Schatz G.C. (2003). A Crossed Molecular Beam Study of the O(3P) +H2 Reaction: Comparison of Excitation Function with Accurate Quantum Reactive Scattering Calculations, J. Chem. Phys., 118: 1585-1588.
22.
Minton, T.K. , Zhang, J., Garton, D.J. and Seale, J.W. (2000). Collision-assisted Erosion of Hydrocarbon Polymers in Atomic-oxygen Environments, High Perform . Polym., 12: 27-42.
23.
Rutledge, S.K. , Banks, B.A. and Kitral, M. (1998). A Comparison of Space and Ground Based Facility Environmental Effects for FEP Teflon, NASA-TM 1998-207918/REV1 , NASA, Washington D.C.
24.
Cross, J.B. , Koontz, S.L. and Hunton, DE (1995). Flight Mass-spectrometer Calibration in a High-velocity Atomic-oxygen Beam, J. Spacecraft Rockets, 32: 496-501.
