Use of waste paper sludge ash as a calcium-based stabiliser for clay soils

Abstract

Chemical ground improvement of soils of poor quality for construction has been increasingly used as a means of promoting sustainable construction practices. The production of conventional soil stabilisers such as cement or lime involves non-renewable natural resource and energy consumption and high carbon dioxide emissions; therefore, alternative stabilisers are sought. This study used waste paper sludge ash (PSA) to treat three different clays. The aim was to assess PSA effectiveness as an alternative to lime or cement for clay stabilisation based on plasticity characteristics, unconfined compressive strength (UCS), water retention and volumetric stability. PSA-treated soil specimens were shown to perform well compared to lime-treated or cement-treated ones: (a) PSA considerably lowered the plasticity indices of the two expansive clays, in a similar way as lime; (b) in most cases PSA dosages equal to or greater than the initial consumption of lime gave UCS at least twice as high compared to those obtained using commercial limes at equivalent dosages (> 1 MPa for the two expansive soils after 7 or 28 days of curing) and in the inspected cases also higher UCS than cement; and (c) consistently with the plasticity results PSA-treated specimens swelled less during wetting and had lower volumetric strains upon drying (better volumetric stability) compared to lime-treated or cement-treated soils. Overall the results give promise for a valorisation route of this waste material in the field of ground improvement.

Keywords

Solid waste management waste paper sludge ash chemical soil stabilisation geotechnical properties clay soils

Get full access to this article

View all access options for this article.

References

Andrews

(1955) Soil Cement Roads. 3rd edition. London, UK: Cement and Concrete Association.

Bhattacharja

Bhatty

Todres

(2003) Stabilization of clay soils by Portland Cement or lime –A critical review of literature. PCA R&D Serial No. 2066. Skokie, IL: Portland Cement Association.

Bernal

Ball

Hussein

et al . (2014) Paper sludge ash as a precursor for production of alkali-activated materials. In: 2nd International Conference on Advances in Chemically Activated Materials, 1–3 June 2014, Changsha, China. Bagneux: RILEM Publications S.A.R.L., pp. 140–149.

British Standards Institution (1990a) BS 1377-3: 1990 Soils for Civil Engineering Purposes. London, UK: British Standards Institution.

British Standards Institution (1990b) BS 1377-2: 1990 (Incorporating Amendment No. 1): Methods of test for Soils for civil engineering purposes —Part 2: Classification tests. London, UK: British Standards Institution.

Bujulu

PMS

Sorta

Priol

et al . (2007) Potential of wastepaper sludge ash to replace cement in deep stabilization of quick clay. In: Annual Conference of the Transportation Association of Canada Saskatoon, Saskatchewan, 14–17 October 2007. Available at: http://conf.tac-atc.ca/english/resourcecentre/readingroom/conference/conf2007/docs/s8/Bujulu.pdf (accessed 22 January 2018).

Dineen

(1997) The influence of soil suction on compressibility and swelling. PhD Thesis, Imperial College, London, UK.

Doudart de la Grée

GCH

(2012) Physical–chemical upgrading and use of bio energy fly ashes as building material in the concrete industry. MSc Dissertation, Eindhoven University of Technology, Eindhoven, Netherlands.

Dunster

(2007) Characterisation of Mineral Wastes, Resources and Processing technologies – Integrated waste management for the production of construction material. Case study: Paper sludge and paper sludge ash in Portland cement manufacture. WRT 177 / WR0115. Leeds, UK: University of Leeds. Available at: http://www.smartwaste.co.uk/filelibrary/Portland_cement_paper_sludge.pdf (accessed 22 January 2018).

10.

Eades

Grim

(1966) A quick test to determine lime requirements for soil stabilization. Washington, DC: Transportation Research Board, Highway Research Record No. 139: 61–72. Available at: http://onlinepubs.trb.org/Onlinepubs/hrr/1966/139/139-005.pdf (accessed 22 January 2018).

11.

European Commission (2003) Council Decision 2003/33/EC: Establishing criteria and procedures for the acceptance of waste at landfills pursuant to Article 16 of and Annex II to Directive 1999/31/EC. Brussels, Belgium: European Commission.

12.

European Commission (2008) Directive 2008/98/EC: Waste Framework Directive. Brussels, Belgium: European Commission.

13.

Frías

García

Vigil

et al . (2008) Calcination of art paper sludge waste for the use as a supplementary cementing material. Applied Clay Science 42: 189–193.

14.

Gluth

Lehmann

Rübner

et al . (2014) Reaction products and strength development of wastepaper sludge ash and the influence of alkalis. Cement and Concrete Composites 45: 82–88.

15.

Highways Agency (2007) Design Manual for Roads and Bridges: Volume 4, Section 1, Part 6. Geotechnics and Drainage. HA74/07, Treatment of Fill and Capping Materials Using Either Lime or Cement or Both. London, UK: The Stationery Office. Available at: http://www.standardsforhighways.co.uk/ha/standards/dmrb/vol4/section1/ha7407.pdf (accessed 22 January 2018).

16.

Kampala

Horpibulsuk

(2013) Engineering properties of silty clay stabilized with calcium carbide residue. Journal of Materials in Civil Engineering 25: 632–644.

17.

Khalid

Mukri

Kamarudin

et al . (2012) Clay soil stabilized using waste paper sludge ash (WPSA) mixtures. Electronic Journal of Geotechnical Engineering 17: 1215–1225.

18.

Kumara

GHAJJ

Tani

(2011) Use of improved dredged clay by paper sludge ash in slope stability of river embankments. Annual Research Journal of SLSAJ 11: 35–42.

19.

Mavroulidou

Ziniatis

Gray

et al . (2017) Alternative calcium-based chemical stabilisers for ground improvement: Paper Sludge Ash treatment of London Clay. In: 15th International Conference on Environmental Science and Technology CEST2017, Rhodes, Greece, 31 August to 2 September 2017. Available at: https://cest2017.gnest.org/taxonomy/term/523 (accessed 22 January 2018).

20.

Mozaffari

Kinuthia

Bai

et al . (2009) An investigation into the strength development of Wastepaper Sludge Ash blended with Ground Granulated Blastfurnace Slag. Cement and Concrete Research 39: 942–949.

21.

Paige-Green

Netterberg

(2004) Cement stabilization of road pavement layers: Laboratory testing programme Phase 1. Report No: CR-2003/42, Pretoria, South Africa: CSIR Transportek. Available at: https://researchspace.csir.co.za/dspace/bitstream/handle/10204/3142/Paige-Green_2004.pdf?sequence=1 (accessed 22 January 2018).

22.

Petry

Little

(2002) Review of stabilization of clays and expansive soils in pavement and lightly loaded structures – History, practice and future. Journal of Materials in Civil Engineering 14: 447–460.

23.

Rahmat

Kinuthia

(2011) Effects of mellowing sulfate-bearing clay soil stabilized with wastepaper sludge ash for road construction. Engineering Geology 117: 170–179.

24.

Spathi

(2015) Novel applications for paper sludge ash. PhD Thesis, Imperial College, London, UK. Available at: https://spiral.imperial.ac.uk/bitstream/10044/1/31599/3/Spathi-C-2016-%20PhD-Thesis.pdf (accessed 22 January 2018).

25.

Tagnit-Hamou

Tognonvi

Davidenko

et al . (2015) From ancient to modern sustainable concrete. In: Scrivener

Favier

(eds) Calcined clays for sustainable concrete. Proceedings of the 1st International Conference on Calcined clays for sustainable concrete, RILEM Bookseries, Volume 10. Dordrecht, The Netherlands: Springer, pp.75–82.

26.

Zaman

Mostari

Al Mahmood

et al . (2018) Evolution and characterization of eggshell as a potential candidate of raw material. Cerâmica 64: 236–241.

27.

Zhang

Mavroulidou

Gunn

(2017) A study of the water retention curve of lime-treated London Clay. Acta Geotechnica 12: 23–45.