Effect of storage conditions on the calorific value of municipal solid waste

Abstract

Storage conditions are considered to be an important factor as far as waste material characteristics are concerned. This experimental investigation was conducted using municipal solid waste (MSW) with a high moisture content and varying composition of organic waste. The objective of this study was to understand the effect of storage conditions and temperature on the moisture content and calorific value of the waste. Samples were subjected to two different storage conditions and investigated at specified temperatures. The composition of sample materials investigated was varied for each storage condition and temperature respectively. Gross calorific value was determined experimentally while net calorific value was calculated using empirical formulas proposed by other researchers. Results showed minimal changes in moisture content as well as in gross and net calorific values when the samples were subjected to sealed storage conditions. Moisture content reduced due to the ventilation process and the rate of moisture removal increased with a rise in storage temperature. As expected, rate of moisture removal had a positive effect on gross and net calorific values. Net calorific values also increased at varying rates with a simultaneous decrease in moisture content. Experimental investigation showed the effectiveness of ventilation in improving the combustion characteristics of the waste.

Keywords

Municipal solid waste calorific value moisture storage degradation temperature

Get full access to this article

View all access options for this article.

References

Athanasopoulos

(2011) Laboratory testing of municipal solid waste. In: Zekkos

(ed.) Geotechnical Characterization, Field Measurement, and Laboratory Testing of Municipal Solid Waste. Reston, VA, pp.195–205.

ASTM (2009). Standard Test Method for Thermal Characteristics of Refuse-Derived Fuel Macrosamples (ASTM E955–88). West Conshohocken, PA: ASTM International.

ASTM (2012). Standard Guide for Characterization of Coal Fly Ash and Clean Coal Combustion Fly Ash for Potential Uses (ASTM D5759–12). West Conshohocken, PA: ASTM International.

Castaldi

Themelis

(2010) The case for increasing the global capacity for waste to energy (WTE). Waste and Biomass Valorization 1: 91–105.

Castrillón

Fernández-Nava

González

et al . (2013) A case study of the characteristics of municipal solid waste in Asturias (Spain): Influence of season and source. Waste Management and Research 31: 428–431.

China Greentech Initiative (2011) The Waste-to-Energy Market in China. China Greentech Report. Hong Kong: Greentech Networks.

Davidson

(2014) Mapping and influencing global perceptions of waste to energy policy. Waste Management World (Nov–Dec): 20–24.

De la Cruz

(2014) Fate and reactivity of lignin in municipal solid waste (MSW) landfill. PhD Thesis, North Carolina State University, USA.

Diaz

Savage

Eggerth

et al . (2005) Solid Waste Management. Paris: UNEP and Cal Recovery Inc.

10.

Flsmidth

A/S

Salmento

(2011) Integrated material cooler and heat recovery exchanger apparatus and process. PCT Patent No. WO/2011/082193.

11.

Haug

(1993) The Practical Handbook of Compost Engineering. Boca Raton, FL: Lewis Publishers.

12.

Ibrahim

Göransson

Kaczala

et al . (2013) Characterization of municipal solid waste temporary storage sites: Risks posed to surrounding areas as a consequence of fire incidents. Waste Management 33: 2296–2306.

13.

Ilinykh

(2013) Evaluation of MSW thermotechnical properties based on its composition. PNRPU. Applied Ecology. Urban Development 3: 125–137.

14.

Keey

(1992) Drying of Loose and Particulate Materials. New York: Hemisphere.

15.

Liu

Zhang

Shen

et al . (2004) Biodegradation kinetic models of organic compound in bioreactor landfill system. Journal of Harbin Institute of Technology [English Edition] 11: 307–309.

16.

Morton

Szabo

Nobis

et al . (2008) Method and apparatus for drying wet bio-solids using excess heat from a cement clinker cooler. US Patent No. US7434332.

17.

Liu

Girotto

et al . (2016) Targeted modification of organic components of municipal solid waste by short-term pre-aeration and its enhancement on anaerobic degradation in simulated landfill bioreactors. Bioresourource Technology 216: 250–259.

18.

Nzioka

Kim

Hwang

et al . (2016) Experimental investigation on the drying of loosely packed and heterogeneous municipal solid waste. Theoretical Foundations of Chemical Engineering 50: 414–421.

19.

Puyuelo

Colón

Martín

et al . (2013) Comparison of compostable bags and aerated bins with conventional storage systems to collect the organic fraction of municipal solid waste from homes. A Catalonia case study. Waste Management 33: 1381–1389.

20.

Qiu

(2012) Part I: Analysis of the economics of waste-to energy plants in China. Part II: MSW sorting models in China and potential for improvement. Master’s Thesis, Columbia University, USA.

21.

Rogoff

Ross

(2016) The future of recycling in the United States. Waste Management and Research 34: 181–183.

22.

Rotich

Zhao

Jun

(2006) Municipal solid waste management challenges in developing countries – Kenyan case study. Waste Management 26: 92–100.

23.

Themelis

Bourtsalas

(2016) The role of waste-to-energy in sustainable waste management. MSW Management (Jul–Aug): 56–58.

24.

Troshin

Nzioka

(2013) Method of processing unsorted municipal solid waste utilising heat energy from reciprocating grate cooler during cooling process [Ukrainian]. Ukraine Patent No. 83321 Cl. MPK (2013.01) F26B 3/00.

25.

Tugov

(2012). Study on process and technology for waste to energy utilization for development of thermal power plants using MSW [Russian]. PhD Thesis, Russian National Thermal Engineering Research Institute, Russian Federation.

26.

Valencia

Van der Zon

Woelders

et al . (2009) Achieving ‘final storage quality’ of municipal solid waste in pilot scale bioreactor landfills. Waste Management 29: 78–85.

27.

Wagner

Bilitewski

(2009) The temporary storage of municipal solid waste – Recommendations for a safe operation of interim storage facilities. Waste Management 29: 1693–1701.

28.

Wilkinson

(2015) How healthy is your MRF. Waste Management World (Jul–Aug): 14–17.

29.

Zhang

Shao

(2009) Sorting efficiency and combustion properties of municipal solid waste during bio-drying. Waste Management 29: 2816–2823.

30.

Zhang

Chen

(2002). Study on degradation law of organic substance of Tianziling MSW(municipal solid waste) landfill. Rock and Soil Mechanics – Wuhan 23: 60–62.