Enhanced solubilization and anaerobic biodegradability of source-separated kitchen waste by microwave pre-treatment

Abstract

Results from an investigation of the effect of high temperature and pressure microwave (MW) pre-treatment of source-separated kitchen waste (SSKW) are presented. MW pre-treatment to a temperature of 175°C (1 min holding time) at a heating rate of 7.9°C min^-1, enhanced SSKW solubilization by 40% in comparison with control; yielding higher soluble chemical oxygen demand (sCOD), total sugars and proteins concentrations in the soluble phase (<45 μm). Batch biochemical methane potential tests (BMP) at 33°C, indicated an enhanced anaerobic biodegradability compared to non-pretreated samples. However, the comparative analysis of semi-continuous anaerobic digesters performance for pre-treated and non-treated SSKW, indicated that MW pre-treatment was successful at solids retention times (SRT) higher than 25 days, showing not only a robust performance in terms of volatile solids (VS) and total chemical oxygen demand (TCOD) removals (6 and 5% gain, respectively, in comparison with control). Effluent dewaterability was also enhanced by MW pre-treatment, showing a 20% increase for the best operation conditions. The study of biomass activity revealed the production of difficult to degrade compounds during pre-treatment conditions and also served as a tool to monitor reactor performance deterioration.

Keywords

Source-separated kitchen waste microwave pre-treatment anaerobic digestion XTT biomass activity

Get full access to this article

View all access options for this article.

References

Ackman RG ( 1972) Porous polymer bead packing and formic acid vapor in GLC of volatile fatty acids. Journal of Chromatography Science 10: 560-565.

Angelidaki I. , Alves M. , Bolzonella D. , Borzacconi L. , Campos JL , Guwy AJ , Kalyuzhnyi S. , Jenicek P. , and van Lier JB ( 2009) Defining the biomethane potential (BMP) of solid organic wastes and energy crops: a proposed protocol for batch assays. Water Science and Technology 59: 927-934.

Apha (1995) Standard Methods for the Examination of Water and Wastewater, 19th edn. Washington, DC, USA: American Public Health Association.

Bolzonella D. , Fatone F. , Pavan P. , and Cecchi F. ( 2005) Anaerobic fermentation of organic municipal solid wastes for the production of soluble organic compounds. Industrial and Engineering Chemistry Research 44: 3412-3418.

Bolzonella D. , Pavan P. , Battistoni P. , and Cecchi F. ( 2006a) Anaerobic co-digestion of sludge with other organic wastes and phosphorus reclamation in wastewater treatment plants for biological nutrients removal. Water Science and Technology 53: 177-186.

Bolzonella D. , Pavan P. , Mace S. , and Cecchi F. ( 2006b) Dry anaerobic digestion of differently sorted organic municipal solid waste: a full-scale experience. Water Science & Technology 53: 23-32.

Bolzonella D. , Battistoni P. , Susini C. , and Cecchi F. ( 2006c) Anaerobic codigestion of waste activated and OFMSW: the experiences of Viareggio and Treviso plants (Italy). Water Science and Technology 53: 203-211.

City of Ottawa (2009) The Green Bin Program. Available from the web: http://www.ottawa.ca/residents/recycling_garbage/green_bin_program/index_en.html (last accessed July 2009).

Davidson A. , Gruvberger C. , and Hallmer M. ( 2007) Anaerobic digestion potential of urban organic waste: a case study in Molmo. Waste Management & Research 25: 162-169.

10.

Dubois MG , Gilles KA , Hamilton JH , Rebers PH , and Smith F. ( 1956) Colorimetric method for determination of sugars and related substances. Analytical Chemistry 28: 330-356.

11.

Dogan I. , Sanin FD (2009) Alkaline solubilization and microwave irradiation as a combined sludge disintegration and minimization method. Water Research 43: 2139-2148.

12.

Environment Canada (2009) Waste Management Section. Available from the web: http://www.on.ec.gc.ca/pollution/ecnpd/organic-material_e.html (last accessed July 2009).

13.

Eskicioglu C. , Kennedy KJ , and Droste RL ( 2007a) Enhancement of batch anaerobic sludge digestion by microwave pre-treatment. Water Environment Research 79: 2304-2317.

14.

Eskicioglu C. , Droste RL , and Kennedy KJ ( 2007b) Performance of anaerobic waste activated sludge digesters after microwave pre-treatment. Water Environment Research 79: 2265-2273.

15.

Eskicioglu C. , Prorot A. , Marin J. , Droste RL , and Kennedy KJ ( 2008) Synergetic pre-treatment of sewage sludge by microwave irradiation in presence of H2O2 for enhanced anaerobic digestion. Water Research 42: 4674-4682.

16.

Frolund B. , Griebe T. , and Nielsen PH ( 1995) Enzymatic activity in the activated sludge floc matrix . Microbiology and Biotechnology 43: 755-761.

17.

Gavala HN , Angelidaki I. , and Ahring B. ( 2003) Kinetics and modeling of anaerobic digestion process. Advances in Biochemical Engineering and Biotechnology 81: 58-93.

18.

Ghanem I. , Guowei G. , and Jinfu Z. ( 2001) Leachate production and disposal of kitchen food solid waste by dry fermentation for biogas generation. Renewable Energy 23: 673-684.

19.

Hansen LT , Jansen JL , Spliid C. , Davidsson A. , and Christensen TH ( 2007) Composition of source-sorted municipal organic waste collected in Danish cities. Waste Management 27: 510-518.

20.

Hong SM , Park JK , Teeradej N. , Lee YO , Cho YK , and Park CH ( 2004) Pretreatment of sludge with microwaves for pathogen destruction and improved anaerobic digestion performance. Water Environment Research 78: 76-83.

21.

Kaatze U. ( 1995) Fundamentals of microwaves. Radiation Physics and Chemistry 45: 539-548.

22.

Krupp M. , Schubert J. , and Widmann R. ( 2005) Feasibility study for co-digestion of sewage sludge with OFMSW on the wastewater treatment plants in Germany. Waste Management 25: 393-399.

23.

Li R. , Chen S. , Li X. , Lar JS , He Y. , and Zhu B. ( 2009) Anaerobic co-digestion of kitchen waste with cattle manure for biogas production. Energy & Fuels 23: 2225-2228.

24.

Lissens G. , Thomsen BA , Baere L. , Verstraete W. , and Ahring KB ( 2004) Thermal wet oxidation improves biodegradability of raw and digested wastes. Environmental Science and Technology 38: 3418-3424.

25.

Lopez, -Torres M , and Espinosa M. a Del C. ( 2008) Effect of alkaline pre-treatment on anaerobic digestion of solid wastes. Waste Management 28: 2229-2234.

26.

Marin J. , Kennedy KJ , and Eskicioglu C. Effect of microwave irradiation on anaerobic degradability of model kitchen waste. Waste Management. 2010; DOI:10.1016/j.wasman.2010.01.033.

27.

Mata-Alvarez J. , Cecchi F. , Pavan P. , and Llabres P. ( 1990) The performance of digesters treating the organic fraction of municipal solid wastes differently sorted. Biological Wastes 33: 181-199.

28.

Mohan S. , Bindhu BK ( 2008) Effect of phase separation on anaerobic digestion of kitchen waste. Journal of Environmental Engineering and Science 7: 91-103.

29.

Owen WF , Stuckey DC , Healy JB , Young LY , and McCarty PL ( 1979) Bioassay for monitoring biochemical methane potential and anaerobic toxicity. Water Research 13: 485-492.

30.

Pahl O. , Firt A. , MacLeod I. , and Baird J. ( 2008) Anaerobic co-digestion of mechanically biologically treated municipal waste with primary sewage sludge - a feasibility study. Bioresource Technology 99: 3354-3364.

31.

Penaud V. , Delgenes JP , and Moletta R. ( 1999) Thermo-chemical pretreatment of microbial biomass: influence of sodium hydroxide addition on solubilization and anaerobic biodegradability . Enzyme and Microbial Technology 25: 258-263.

32.

Ponne TC , Bertels VP ( 1995) Interaction of electromagnetic energy with biological material-relation to food processing. Radiation Physics and Chemistry 45: 591-607.

33.

Recycling Council of Alberta (2006) Municipal Solid Waste (MSW) Options: Integrating Organics Management and Residual Treatment/ disposal. Available from the web: http://www.recycle.ab.ca/Download/MSW_Options_Report.pdf (accessed June 2009).

34.

Roslev P. , King GM ( 1993) Application of a tetrazolium salt with a water-soluble formazan as an indicator of viability in respiring bacteria. Applied and Environmental Microbiology 59: 2891-2896.

35.

Schober G. , Schäfer J. , Schmid-Staiger U. , and Trösch W. ( 1999) One and two-stage digestion of solid organic waste. Water Research 33: 854-860.

36.

Shiue-Lin L. , Shih-Chiang L. , Jian-Sheng L. , Ze-Kun K. , Wang Y. , and Sheng-Shung C. ( 2008) Process performance evaluation of intermittent-continuous stirred tank reactor for anaerobic hydrogen fermentation with kitchen waste . International Journal of Hydrogen Energy 33: 1522-1531.

37.

Speece RE ( 1996) Anaerobic Technology for Industrial Wastewaters. Nashville, TN: Archea Press.

38.

Stuckey DC , MacCarty PL ( 1978) Thermochemical treatment of nitrogenous materials to increase methane yield. Biotechnology and Bioengineering 8: 219-233.

39.

Vavilin VA , Fernandez B. , Palatsi J. , and Flotats X. ( 2008) Hydrolysis kinetics in anaerobic degradation of particulate organic material: An overview. Waste Management 28: 932-951.

40.

van Huyssteen, JJ ( 1967) Gas chromatographic separation of anaerobic digester gases using porous polymer. Water Research 1:237-242.

41.

Wendland C. , Deegener J. , Thoshev P. , and Otterpohl R. ( 2007) Anaerobic digestion of black vacuum toilets and kitchen waste refuse in continuous stirred tank reactor. Water Science and Technology 55: 187-194.

42.

Wojciechowaska E. ( 2005) Application of microwaves for sewage sludge conditioning . Water Research 39: 4749-4754.

43.

Wuertz S. , Pfleiderer P. , Kriebitzsch K. , Spath R. , Griebe T. , Coello-Oviedo D. , Wilderer A. , and Flemming H. ( 1998) Extracellular redox activity in activated sludge. Water Science and Technology 37: 379-384.