Life-cycle assessment (EASEWASTE) of two municipal solid waste incineration technologies in China

Abstract

The environmental profile of two municipal solid waste incineration (MSWI) technologies with semi-dry flue gas cleaning, namely grated firing incinerators (GFI) and fluidised bed incinerators (FBI) that are commonly used in China were evaluated and compared by life-cycle assessment (LCA) using the EASEWASTE model. All emissions of key pollutants as well as energy, resource and material inputs and outputs associated with the two MSWI technologies were determined and the corresponding environmental impact potentials were modelled. Incineration of MSW with a lower heating value (LHV) around 4.5 MJ kg^—1 demands that auxiliary fuel is used, and both GFI and FBI caused environmental loads by contributing with environmental impact potentials in most categories except for some saving in global warming (GW100) and hazardous waste (HW). Coal combustion in FBI is a main contributor to the environmental impact potentials and thus should always be limited to a minimum. Auxiliary fuels can be avoided when the LHV of MSW is higher than 5—6 MJ kg^{— 1}. For all scenarios, GFI saves more global warming potentials than FBI due to its higher net power generation from combustion of MSW itself. Leachate from the bunker could be sprayed into the furnace for evaporation under high temperature, as an alternative to waste-water treatment, without major changes in the environmental profile of the incinerator. The presented evaluations may contribute to a more balanced environmental assessment of the two incineration technologies with respect to incineration of MSW with low heating values as often found in Asia and China.

Keywords

Municipal solid wastes management life-cycle assessment EASEWASTE fluidised bed incinerator grate firing incinerator China

Get full access to this article

View all access options for this article.

References

Asme (1999) Fired steam generators performance test code. ASME PTC 4-1998[S]. New York.

Rand T. , Haukohl J. , and Marxen U. ( 2000) Municipal solid waste incineration, A Decision Maker’s Guide (2000). The international Bank for Reconstruction and Development, public disclosure authorized. p12. <http://www.-wds.worldbank.org/servlet/WDSContentServer/WDSP/IB/2000/11/04/000094946_0010250532405/Rendered/PDF/multi_page.pdf&gt ;

Bjarndottir H. , Fridriksson GB , Johnsen T. , and Sletsen H. ( 2002) Guidelines for the use of LCA in the waste management sector. November 2002, Nordtest Project nr. 1537-01, Espoo , Finland.

Cao Y. , Yan J. , and Li X. ( 2005) Co-firing MSW with coal in fluidized incinerator and pollutant emission characteristics thereof. Thermal Power Generation (in Chinese) 34: 57-60, 63.

China National Development and Reform Commission, Ministry of Finance and China State Administration of Taxation (2006 ) Administration rules for cognizance of state-encouraging integrated resources utilization project. Document No.[2006]1864 issued on 7 September 2006. <http://www.sdpc.gov.cn/zcfb/zcfbtz/tz2006/t20060913_84382.htm>

Di X. , Nie Z. , and Zuo T. ( 2005) Life cycle emission inventories for the fuels consumed by thermal power in China. China Environmental Science (in Chinese) 25: 632-635.

Feng JK , Shen YT , and Yang RC ( 2003) Boiler theory and calculation. Beijing : Science Press, 18-32.

Fujimura H. , Oshita T. , and Naruse K. ( 2001) Fluidized-bed gasification and slagging combustion system. Presented at the 2001 IT3 Conference (International Conference on Incineration and Thermal Treatment Technologies), 14-18 May 2001, Philadelphia , USA.

Gullett BK , Dunn JE , and Raghunathan K. ( 2000) Effect of co-firing coal on formation of polychlorinated dibenzo-p-dioxins and dibenzofurans during waste combustion. Environmental Science & Technology 34: 282-290.

10.

Kirkeby JT , Bhander GS , Birgisdottir H. , Hansen TL , Hauschild M. , and Christensen TH ( 2006) Environmental assessment of solid waste systems and technologies: EASEWASTE. Waste Management & Research 24: 3-15.

11.

Kraft DL , Orender HC ( 1991) Considerations using sludge as a fuel. TAPPI Engineering Conference, Nashville TN , 2 October 1991, pp. 331-337.

12.

Louhimo JT , Mullen JF ( 1990) Sludge burning in fluidized bed boilers. TAPPI Engineering Conference, 1990, 885-900.

13.

McDermott RJ , Morris KW , and Sanderson JG ( 1981) A better boiler for wet hog fuel. Pulp & Paper Canada 82: 133-138.

14.

Ministry of Environment Protection of China and National Development and Reform Commission (2006) Notification of enhancing environmental assessment of projects on power generation fuelled with bio-mass. Document No.[2006]82 issued on 1 June 2006. <http://big5.sepa.gov.cn/gate/big5/www.zhb.gov.cn/info/gw/huangfa/200606/t20060601_77260.htm&gt ;

15.

Riber C. , Bhander GS , and Christensen TH ( 2008) Environmental assessment of waste incineration in a life-cycle-perspective (EASEWASTE). Waste Management & Research 26: 96-103.

16.

Statistics & Information Department, China Electricity Council (2008) Brief summary of electricity production in China during January to October 2008. Electricity Industry Information, 20, 7-11. <http://www.cec.org.cn/html/news/2008/11/18/20081118174476710.html>

17.

Stranddorf HK , Hoffmann L. , Schmidt A. ( 2005) Impact categories, normalisation and weighting in LCA, Updated on selected EDIP97-data. Environmental News No. 78 2005. Danish Environmental Protection Agency, Danish Ministry of the Environment , Copenhagen, Denmark.

18.

Yokoyama T. , Suzuki Y. , and Akiyama H. ( 2001) Improvements and recent technology for fluidized bed waste incinerators. NKK Technical Review 85: 38-43.

19.

Wenzel H. , Hauschild M. , and Alting L. ( 1997) Environmental assessment of products, vol. 1: Methodology, tools and case studies in product development. Hingham, MA, USA: Kluwer Academic Publishers.

20.

Xiao B. , Zhang A. , and Chen G. ( 2005) Life cycle inventory of clean coal-fired power generation in China. Clean Coal Technology (in Chinese) 11: 1-4, 14.

21.

Yan JH , Chen T. , Li XD , et al. (2006) Evaluation of PCDD/Fs emission from fluidized bed incinerators co-firing MSW with coal in China. Journal of Hazardous Materials A135: 47-51.

22.

Yan JH , Lu SY , Gu YL , et al. (2005) Trace organic pollutants emission from large-scale circulating fluidized bed incinerators of co-firing Chinese MSW and coal. Proceedings of the 18th International Conference on Fluidized Bed Combustion, 22-25 May 2005, Toronto, ON, Canada, pp. 345-352.

23.

Zhang HJ , Ni YW , Chen JP , and Zhang Q. ( 2008) Influence of variation in the operating conditions on PCDD/F distribution in a full-scale MSW incinerator. Chemosphere 70: 721-730.

24.

Zhang YG , Li QH , and Kang JB ( 2004) Power generation technology from clean incineration of MSW (in Chinese). Beijing: China Water Power Press, 111.