Waste paper mill sludges originating from different effluent treatment and de-inking installations are complex mixtures of inorganic and organic particles. Due to their favourable physico-chemical, and microbiological characteristics, they may be conveniently reused for different purposes as such or after appropriate pretreatment. Sludges from the Slovenian paper industry were extensively tested for their chemical, stability and sealing properties. During the biodegradability tests, evolutions of greenhouse gases CO2, CH4 and H2 S as well as the concentrations of released volatile organic acids, such as acetic, propionic, butyric, lactic and glycollic acids as the typical degradation products of organic materials, were measured. Some other important parameters of water leachates such as pH, redox potential, content of starch and leachable ions were also evaluated. The results indicate that most of them can be efficiently applied as alternative hydraulic barrier layers for landfill construction and covering instead of the more expensive clay due to their good geomechanical properties, chemical inertness and microbiological stability. Such replacement brings about considerable economical and ecological benefits as the waste is reprocessed as secondary raw material.
Andersland, O.B. & Laza, R.W. (1972) Permeability of high ash paper mill sludge. Journal of the Sanitary Engineering Division, 98, 927—936.
2.
Bower, T. (1973) Residuals in manufacture of paper. Journal of the Environmental Engineering Division, 99, 1—16.
3.
Charlie, W.A. (1977) Pulp and paper mill solid waste disposal: a review, geotechnical practice for disposal of solid waste materials. In: Proc. of the ASCE Specialty Conference, pp. 71—86. ASCE, New York, American Society of Civil Engineers, New York, USA.
4.
Černec, F., Zule, J., Može, A. & Ivanuš, A. (2005) Chemical and microbiological stability of waste sludge from paper industry intended for brick production . Waste Management & Research, 23, 106—112.
5.
Dyer, J. (1996) Odor control in recycled fiber mills. Progress in Paper Recycling, 5, 87—90.
6.
Fourie, A.B. & Brown, R.A. (2001) Two examples illustrating the importance of correctly characterizing the engineering properties of paper mill sludge. In: Proc. of the Fifth International Workshop on the Use of Paper Industry Sludges in Environmental Geotechnology and Construction, 23—25 May, Manila, Philippines, pp. 50—57. Finnish Environment Institute , Helsinki.
7.
Geller, A. (1984). Korrosion, Schleim- und Geruchsbildung bei der Verringerung des spezifischen Abwasseranfalls in Papierfabriken, Wochenblatt fü Papierfabr, 112, 49—58.
8.
Gillespie, W.J. (1970) Recent paper industry waste treatment systems. Journal of the Sanitary Engineering Division, 96, 467—476.
9.
Göttsching, L. (1998) Totally closed white water system in the paper industry: a case study. Revue ATIP, 52, 131—138.
10.
Gudlauski, D.G. (1996) Whitewater system closure means managing microbiological buildup. Pulp & Paper, 70: 161—165.
11.
Heerenklage, J. & Stegmann, R. (2005) Analytical methods for the determination of the biological stability of waste samples. In: Proc. of Sardinia 2005, Tenth International Waste Management and Landfill Symposium . S. Margherita di Pula, Cagliary , Italy, 3—7 October 2005, Environmental Sanitary Engineering Centre, Italy.
12.
Hudson, J.A. & Lowe, P. (1996) Current technologies for sludge treatment and disposal. Journal of Water and EnvironmentalManagement, 10, 436—441.
13.
Hynninen, P. (ed.) (1998) Environmental Control (Book 19 from a series `Papermaking Science and Technology'), Fapet Oy, Jyväskylä, Finland.
14.
Ishimoto, H., Origuchi, T. & Yasuda, M. (2000) Use of papermaking sludge as new material. Journal of Materials in Civil Engineering, 12, 310—313.
15.
Jokela, J. , Rintala,J.Oikari, A., Reinikainen, O., Mutka, K. & Nyronen, T. (1997) Aerobic composting and anaerobic digestion of pulp and paper mill sludges. Water Science & Technology, 36, 181—188.
16.
Krogman, U. (1998) Biosolids and sludge management. WaterEnvironment Research, 70, 560—580.
17.
LaPlante, C.M. & Zimmie, T.F. (2003) Monitoring freeze-thaw effects on waste paper sludge landfill covers. In: Proc. of the 18th International Conference on Solid Waste Technology and Management, 23—26 March, Philadelphia, PA, pp. 203—213. American Society of Civil Engineers, Baltimore, USA.
18.
Liaw, C., Chang, H., Hsu, W. & Huang, C. (1998) Novel method to reuse paper sludge and co-generation ashes from paper mill. Journal of Hazardous Materials, 58, 93—102.
19.
Moo-Young, H.K. & Zimmie, T.F. (1997) Waste minimization and reuse of paper sludge in landfill covers: a case study. Waste Management and Research , 15, 593—605.
20.
Mroueh, U.M., Mäkelä, E., Wahlström, M., Kauppila, J., Sorvari, J., Puolanne, J., Juvankoski, M., Tammirinne, M., Heikkinen, P. & Salminen, R. (2001) Finnish guidance for the use of secondary products in earth and road construction. In: Proc. of the International Conference on Practical Applications in Environmental Geotechnology Ecogeo 2000, Geological Survey of Finland, Special Paper 32, pp. 15—21. Geological Survey of Finland, Helsinki.
21.
Palko, J., Huttunen, E. & Soikkeli, J. (2001) Biodegradation of paper sludge and its effect on volume change of hydraulic barrier layer in landfill cover structure. In: Proc. of the Fifth International Workshop on the Use of Paper Industry Sludge in Environmental Geotechnology and Construction, pp. 62—66. Finnish, Environment Institute, Helsinki .
22.
Quiroz, J.D. & Zimmie, T.F. (1999) Technical possibilities for paper sludge utilization . In: Proc. of the Third International Workshop on the Use of Paper Industry Sludges in Environmental Geotechnology and Construction , 1—4 June, Helsinki, Finland, pp. 8—19.
23.
Quiroz, J.D. & Zimmie, T.F. (1998) In-situ strength testing on a paper mill sludge landfill cover. In: Proc. of the Second International Workshop on the Use of Paper Industry Sludges in Environmental Geotechnology and Construction, NY, pp. 30—38.
24.
Quiroz, J.D., Simpson, P.T. & Zimmie, T.F. (2000) Evaluation of paper sludge landfill cover settlement . In: Proc. of Session of Geo-Denver2000, pp. 16—31. Geotechnical Special Publication No. 265, ASCE, Reston, VA.
25.
Quiroz, J.D. & Zimmie, T.F. (2001) Long-term monitoring strategies and field performance of paper mill sludge landfill covers. In: Proc. of the Fifth International Workshop on the Use of Paper Industry Sludges in Environmental Geotechnology and Construction, 23—25 May, Manila, Philippines, pp. 67—80.
26.
Sand, W. (2000) Mechanisms of microbial deterioration. Investigacion y Tecnica del Papel146, 507—519.
27.
Simpson, P.T. & Zimmie, T.E. (2004) Waste Paper sludge — an update on current technology and reuse. In: Sydilek, A.H. & Wartman, J. (eds): Recycled Materials in Geotechnics, pp. 75—90. ASCE, Baltimore, MD.
28.
Simpson, P.T., Zimmie, T.F. & Lahtinen, P. (2004) Potential uses of waste paper sludge as roadbed material. In: Proc. of the 19th International Conference on Solid Waste Technology andManagement, 21—24 March, Philadelphia, PA, American Society of Civil Engineers, Baltimore, USA.
29.
Sorvari, J. & Tenhunen, J. (2001a) Definition of environmental criteria for industrial by-products used in earth construction. In: International Conference on Practical Applications in Environmental Geotechnology Ecogeo 2000, Geological Survey of Finland, Special Paper 32, pp. 91—98, Geological Survey of Finland, Helsinki.
30.
Sorvari, J. & Tenhunen, J. (2001b) Finnish guidance for the use of secondary products in earth and road construction. International Conference on Practical Applications in Environmental Geotechnology Ecogeo 2000, Geological Survey of Finland, Special Paper 32, pp. 91—98.
31.
Tähtinen, M. (1999) Environmental prospects of paper sludge utilization . In: Proc. of the Third International Workshop on the Use of Paper Industry Sludges in Environmental Geotechnology and Construction, 1—4 June, Helsinki, Finland, pp. 52—55. Finnish Environment Institute, Helsinki.
32.
Tenorio, D.O., Calonge, C.J.M.& Pelkonen, H. (2001) Generation and characterization of paper mill sludge . In: Proc. of the Fifth International Workshop on the Use of Paper Industry Sludges in Environmental Geotechnology and Construction , Manila, 23—24 May, pp. 15—22. Finnish Environment Institute, Helsinki.
33.
Zimmie, T.F. (1997) Utilizing a paper sludge barrier layer in municipal landfill covers. In: Proc. of the First International Workshop on the Use of Paper Industry Sludges in Environmental Geotechnology and Construction, 11—16 August, Helsinki, Finland, pp. 9—22. Finnish Environment Institute, Helsinki.
